Professional Documents
Culture Documents
p0024707
gaged by simply pressing a pushbutton
on top of the case. While the pushbutton
remains depressed, the damper can be
operated by hand.
Simple installation
The NM230-F, with its hollow shaft, is
placed over the 8 mm square spindle of
the damper and secured by two screws.
Wiring diagram
Electrical accessories
AC 230 V To isolate from the main power supply, the system
must incorporate a device which disconnects the phase SN1, SN2 Auxiliary switches
N L1
conductors (with at least a 3 mm contact gap).
Important
Read the notes about the use and torque
requirements of the damper actuators on
page 3 in the documentation 2. NM- .
1 2 3
5.2
p0025707
Automatic commissioning,
easy functional check
When the power supply is first switched
on, or when the override pushbutton is
pressed, the actuator performs an auto-
matic function test. It runs to each end
position and, in the process, adapts its
Wiring diagram
electrical working range of DC 210 V
and running time of 150 s to the effective
AC 24 V ! Connect via safety Control manufacturers: ABB, AEG, Blz, Centra, Con-
~ isolating transformer. mechanical angle of rotation of the damp-
T trolli, C.S.I., Danfoss, DIGIControl, Elesta, GA, H.C.
System, Honeywell, Inel, IWK, Johnson, Kieback & Peter, er. After performing this function, the
Y DC 0...10 V actuator moves to the position demanded
Landis & Staefa, Messner, Priva, RAM R+S, Samson,
Satchwell, Sauter, SE-Electronic, Siemens, TA, Trend. by the positioning signal.
A functional check of damper operation is
U DC 210 V Measuring voltage U for position indication or simplicity itself: the gearing can be disen-
as master-slave control signal.
gaged by simply pressing a pushbutton
on top of the case. While the pushbutton
1 2 3 4
remains depressed, the damper can be
operated by hand.
T ~
w0509807
m0036807
min
. 10
mm
1 2
BC NM24-F Form-fit damper actuator 8 Nm
2. NM/E2-2
Dampers up to approx. 1.5 m2
Open/Close actuator
(AC/DC 24 V)
Reversible
p0023707
gaged by simply pressing a pushbutton
on top of the case. While the pushbutton
remains depressed, the damper can be
operated by hand.
Simple installation
The NM24-F, with its hollow shaft, is
placed over the 8 mm square spindle of
Wiring diagram the damper and secured by two screws.
Electrical accessories
Single-wire control 2-wire control
T ~ T ~ SN1, SN2 Auxiliary switches
AC 24 V Connect via safety AC 24 V
! isolating transformer.
- + DC 24 V - + DC 24 V Important
Read the notes about the use and torque
requirements of the damper actuators on
page 3 in the documentation 2. NM- .
1 2 3 1 2 3