Professional Documents
Culture Documents
Data:
Length : 9.0m
Width: 10.70m
Height: 18.0m
Concrete: M30
Steel: Fe415
1.50 3.50 4.00
3.50
3.50
6.00
1.20
COLUMN SIZES - 0.45 X 0.23
BEAM SIZES 0.45 X 0.23
PLAN
1.Geometry Creation:
3. Supports :
Go to front view.
Click Support Create Fixed Add. Highlight support 2 and select bottom most
support nodes by windowing using node cursor Assign to selected nodes
Assign Yes Close De select the nodes and change to beam cursor.
4. Loads :
Click Load & Definitions Load case details Add. Primary Number 1 loading type
Dead Title: Selfweight Add. Click Load case details Add.
Number 2 Loading type: Dead Title: Wall Load Add. Click Load case details
Add. Number 3 Loading type: Dead Title: Slab loads Add.
Click Load case details Add.
Number 4 Loading type: Live Title: LL Add
Click Load case details Add. click load combination Load Comb no.5
Name: 1.5 (Self weight +Wall load + Slab loads+ LL) Factor Default =1.5
Select Load case 1 1=1.5
Select Load case 2 2=1.5
Select Load case 3 3=1.5
Select Load case 4 4=1.5 Add.
Click Shear Force Fy icon Results View ValueBeam Results Shear Force
Ends Annotate.
Click Axial Force Fx icon Results View ValueBeam Results Axial Force
Ends Annotate.
Note: Before going to another result remove the tick mark in Beam results.
Design Check:
Main menu Select By specificationAll failed beams.
Go to modeling mode.
Select Column (at bottom portion) Double click the columnConcrete design.
Check the bottom most storey column. If some columns in GF inner are failed,
change the size of the column for inner portion and again run the analysis, verify
the result.
Similarly check the beam by double click the particular beam for find the
reinforcement. If all are passed ok. Otherwise revise the beam section if failed.
Click report set up icon.
Available : Selected:
Input 1. Sections
2. Supports
3. Loadings
Report:
Click Report setup icon Click input from available from left side.
Select sections , Loadings and sent to Right side by clicking > Select output.
From output select Beam end forces, reactions, shear forces, axial forces, Beam
To Take picture:
Click take picture icon Enter the title of the sketch. Then Go to report set up.
Select picture Album. If you want to change the sketch title enter the title in
caption. Adjust the picture size by adjusting height & width. Select Full page.