Professional Documents
Culture Documents
There are more than 20 new Question not in any vaild Dump
which tow options are requirements for configuring ripv2 for ipv4?
Answer - B,E
http://www.cisco.com/c/en/us/support/docs/ip/routing-information-protocol-
rip/13730-ext-ping-trace.html#ext_troute
which port security mode can assist with troubleshooting by keeping count of
violations?
A. access
B. protect
C. restrict
D. shutdown
answer is restrict
Which function does IP SLA ICMP ECHO operation perform to assist with
troubleshooting one way jitter measurement
A. packet-loss detection
B. hop-by-hop response time
C. congestion detection
PAGP modes
Etherchannel (PAGP) about modes
a- auto
b- desirable
c- on
d-
.. something
Answer: B
which type of broadcast barely used in ipv4 which also exist in ipv6 like
A. unicast
B. multicast
C. broadcast
D. anycast
When a device learns multiple routes to a specific network, it installs the route
with?
1- Longest bit Match (highest subnet Mask)
2- lowest administrative distance
3- lowest metric
4- equal load balancing
which address prefix does OSPFv3 use when multiple IPv6 address are configured on a
single interface?
A. All prefix on the interface.
B. The prefix that the administrator configure for OSPFv3 use
C. The lowest prefix on the interface.
D. The highest prefix on the interface.
Which utility can you use to identify the cause of a traffic flow blockage between
two devices in a network?
A. ACL analysis tool in APIC-EM
B. ACL path analysis tool in APIC-EM
C. APIC-EM automation Scheduler
D. iWAN application
Which tool used to verify ACL Requirement to configure DHCP binding ?(2 options)
A. DHCP pool
B. IP address
C. Hardware address
D. other option
I answered C
Which statement describes the process of dynamically assigning IP addresses by the DHCP server?
A. Addresses are allocated after a negotiation between the server and the host to determine the length
of the agreement.
B. Addresses are permanently assigned so that the hosts uses the same address at all times.
C. Addresses are assigned for a fixed period of time, at the end of the period, a new request for an address
must be made.
D. Addresses are leased to hosts, which periodically contact the DHCP server to renew the lease.
Answer: D
which configuration command can you apply to a HSPR router so that its local
interface becomes active if all other routers in the group fail?
Which command can you enter to verify link speed and duplex setting on the
interface?
A. Scan Timer
B. TTD
C. Flow Label
D. Hop Limit
E. Hop Count
ICANN
APNIC
RIR
ISPs
There was a diagram with two switches (I think). Each switch had 3 hubs and each
hub had two PCs attached. The question asked how many broadcast domains.
A- 12
B- 6
C- 4
D- 2
Answer: D
Another question ask when to escalate a problem
The quriculum says :In some situations, it may not be possible to resolve the
problem immediately. A problem should be escalated when it requires a managers
decision, some specific expertise, or network access level unavailable to the
troubleshooting technician.
For example, after troubleshooting, the technician concludes a router module should
be replaced. This problem should be escalated for manager approval. The manager may
have to escalate the problem again as it may require the financial departments
approval before a new module can be purchased.
A companys policy should clearly state when and how a technician should escalate a
problem.
What two results would occur if the hub were to be replaced with a switch that is
configured with one Ethernet VLAN? (Choose two.)
C&D
In an Ethernet network, under what two scenarios can devices transmit? (Choose
two.)
Which two protocols are used by bridges and/or switches to prevent loops in a layer
2 network?
A. 802.1d
B. VTP
C. 802.1q
D. STP
E. SAP
Answer: AD
Why R1 can't establish an OSPF neighbor relationship with R3 according to the
following graphic?(Choose two)
Explanation:
A is not correct because configure EIGRP on these routers (with a lower
administrative distance) will force these routers to run EIGRP, not OSPF.
B is not correct because the backbone area of OSPF is always Area 0.
C and D are correct because these entries must match on neighboring routers:
Hello and dead intervals
Area ID (Area 0 in this case)
Authentication password
Stub area flag
Which command can you enter to troubleshoot the failure of address assignment?
A. Show ip DHCP database
B. Show ip DHCP pool
C. Show ip DHCP import
D. Show ip DHCP server statistics
Which symptom most commonly indicates that 2 connecting interface are configured
with a duplex mismatch?
A. an int with up/down state
B. an int with down/down state
C. collisions on the interface
D. the spanning tree process shutting down
Which configuration command can u apply to a HSRP router so that its local
interface becomes active if all other routers in the group fail?
A. no additional config is required
B. standby 1 track Ethernet
C. standby 1 preempt
D. standby 1 priority 250
Which component of the Cisco SDN solution serves as the centralized management
system?
Explanation:
Cisco ACI is a comprehensive SDN architecture. This policy-based automation
solution supports a business-relevant application policy language, greater
scalability through a distributed enforcement system, and greater network
visibility. These benefits are achieved through the integration of physical and
virtual environments under one policy model for networks, servers, storage,
services, and security.
http://vceguide.com/which-component-of-the-cisco-sdn-solution-serves-as-the-
centralized-management-system/
I answered B