Professional Documents
Culture Documents
CONTENTS
1 PURPOSE..............................................................................................................2
2 TARGET OF DESIGN...........................................................................................2
3 STANDARDS AND CODES.................................................................................2
4 UNIT OF MEASUREMENT.................................................................................2
5 DESIGN PARAMETERS......................................................................................2
5.1. Input data.......................................................................................................2
5.2. Output data....................................................................................................2
6 BASIS OF CALCULATION..................................................................................3
6.1. Capacity.........................................................................................................3
6.2. Bucket types..................................................................................................3
6.3. Pulley revolution............................................................................................4
6.4. Peripheral force..............................................................................................4
6.5. Power............................................................................................................. 5
6.6. Determination of belt type.............................................................................5
7 CALCULATION RESULTS..................................................................................6
8 APPENDIXES........................................................................................................6
QT1-PVE-00HTK-M-M5A-0004 PAGE: 1 of 8
QUANG TRACH 1
THERMAL POWER PLANT - 2x600MW
1 PURPOSE
With bucket elevators, different bulk loads can be conveyed either vertically
or sloping upwards. Belts with buckets attached are used as the carrying
medium. They run with low noise levels and low vibrations at a relatively
high speed. They require only a small ground area and are preferred in
buildings, silos and warehouses.
The bucket elevator selection through volumetric capacity, lift, lump size,
material characteristics and operating conditions will determine necessary
demand properly.
2 TARGET OF DESIGN
Design is to provide the optimal engineering solution meet to safety, reliable
& stable operating conditions for system.
4 UNIT OF MEASUREMENT
The unit of measurement in the design shall be SI unit (International System
of Units).
5 DESIGN PARAMETERS
QT1-PVE-00HTK-M-M5A-0004 PAGE: 2 of 8
QUANG TRACH 1
THERMAL POWER PLANT - 2x600MW
6 BASIS OF CALCULATION
6.1. Capacity
QT1-PVE-00HTK-M-M5A-0004 PAGE: 3 of 8
QUANG TRACH 1
THERMAL POWER PLANT - 2x600MW
6.5. Power
QT1-PVE-00HTK-M-M5A-0004 PAGE: 5 of 8
QUANG TRACH 1
THERMAL POWER PLANT - 2x600MW
7 CALCULATION RESULTS
See attached documents.
8 APPENDIXES
QT1-PVE-00HTK-M-M5A-0004 PAGE: 6 of 8
QUANG TRACH 1
THERMAL POWER PLANT - 2x600MW
Table 8 1. Values for fill factor, bulk density and conveying speed
QT1-PVE-00HTK-M-M5A-0004 PAGE: 7 of 8
QUANG TRACH 1
THERMAL POWER PLANT - 2x600MW
QT1-PVE-00HTK-M-M5A-0004 PAGE: 8 of 8