Professional Documents
Culture Documents
SCF Unicom
SERGEY STEPANISHCHEV
2311886
04.01.1975
Russian Federation
Show only wrong answers with negative score: No
CES 5.0.3847 26.08.2010 STCW
Management
CES version: Test date: Test type: Level:
Department/Function area: Deck Vessel type/Propulsion: Oil Tanker
Question asked (212):
Which organization or administration is responsible for surveys and inspections of ships,
and the issue of Safety Certificates? Selected answer:
Ships Classification Associations (Lloyd's, American Bureau of Shipping, The
Norwegian Veritas, Germanische Lloyd's, etc.) Correct answer:
Government Authorities of the Flag State
Question asked (2887):
Subject to allowance by the Port State Authority a tanker with defect oil discharge
monitoring and control system (ODME) may undertake? Selected answer:
The vessel will be detained until ODME is rectified. Correct answer:
One ballast voyage before proceeding to a repair port.
Question asked (2887):
Subject to allowance by the Port State Authority, a tanker with a defective oil discharge
monitoring and control system (ODME) may continue to trade for a limited period before
a repair is effected. What period is allowed and what conditions apply?
Selected answer:
The vessel may discharge her cargo but will then be detained in port until the ODME is
made fully operational and approval from the Port State Authority obtained.
Correct answer:
One ballast voyage before proceeding to a repair port.
Question asked (3005):
Some centrifugal cargo pumps on oil tankers are designed with an automatic stripping
system, which allows the cargo tank to fully discharge its contents. By what principle
does such a stripping system operate?
Selected answer:
By the optimum size and positioning of the suction inlet that feeds the automatic
stripping system, which ensures that the cargo oil tank is discharged to the maximum
possible extent.
Correct answer:
On the basis that, if cargo vapour can be stopped from entering the cargo pump suction
inlet, the flow will continue without cavitation.
Question asked (3242):
What does STCW deal with? Selected answer:
STCW deals with training centre and schools and standards for watch keepers Correct
answer:
STCW deals with minimum recommendation of education for seafarers and minimum
standards for training centre and schools
Question asked (3714):
A 6-men inflatable liferaft shall be carried as far forward as is reasonable and
practicable. Where is the best stowing position? Selected answer:
Aft of the forecastle secured with the use of hydrostatic release device. Correct
answer: Under the forecastle.
Question asked (5493):
The input of an area code prefix in (radio)telex-traffic:
Selected answer:
Has to be put in without the zero
Correct answer:
Differs for each country
Question asked (5500):
With what system is a NAVTEX-message transmitted? Selected answer:
Send a PDN, if the message has arrived in the mailbox Question asked (5583):
You receive via the 8 MHz a DSC distress alert. The received DSC message is however
distorted. The MMSI as well as the position are illegible. After listening at the 8 MHz
telephone distress frequency, nothing is heard. This is because:
Selected answer:
First an acknowledgement of a coastguard station must be received via the 8MHz
Correct answer:
Telephone signals in the same frequency band are generally weaker than DSC signals
At sea, outside territorial waters, and in port or harbour Question asked (5880):
Which of the following answers would best define the term "risk"? Selected answer:
Risk is the possibility that a dangerous situation is likely to occur Correct answer:
Risk is a situation involving exposure to danger and includes both identification of the
occurrence and the likelihood that it will happen. Question asked (10381):
*Which of the following items must be included in each fire drill? Selected answer:
Starting a fire pump using at least two required jets of water to show that the system is
in proper working order
Correct answer:
All the items mentioned
Question asked (20322):
Give the meaning of the following symbol
Selected answer:
Survival craft portable radio
Correct answer:
EPIRB
Question asked (20351):
A hand flare must have a burning period of at least Selected answer:
Correct answer:
Question asked (31027):
What is the period of validity of the Safety Management Certificate Selected answer:
1 Year
Correct answer:
5 years
Question asked (31464):
A ship in distress should transmit the appropriate alarm signal followed by the distress
call and message on one or all of the international distress frequencies. Which of
frequencies is in accordance with the present recommendations?
Selected answer:
550 kHz, 2182 kHz and 121.5 MHz Correct answer:
500 kHz, 2182 kHz and 156.8 MHz
Question asked (32111):
In which of these circumstances can your ship request a DoS? Selected answer:
Your ship is operating at a lower security level than the ship or port it is interfacing with.
Correct answer:
Your ship is conducting activities with a port or ship that is not required to implement an
approved security plan.
Question asked (32145):
Which of these measures would you implement to prevent drugs from being smuggled
onboard your ship while it's berthed? Selected answer:
"Search some of the packages, spares and stores received." Correct answer:
Maintain restricted areas.
Question asked (32206):
A tanker in ballast, having recently left the discharge port is involved in a collision. The
two vessels are still interlocked after the collision and a survey of the ships gives all
crew members are safe and the damage is focussed to the vicinity of the impact. What
should be the greatest concern at this time?
Selected answer:
The possibility of pollution. Correct answer:
The ships moving together in the swell/seaway will cause a spark and consequently an
explosion.
Question asked (32255):
A system for the continuous monitoring of the concentration of hydrocarbon gas shall be
fitted in cargo pump-rooms of oil tankers. A
continuous alarm shall be automatically activated when the hydrocarbon gas
concentration reaches a pre-set level. What are the criteria
for pre-setting the alarm level?
Selected answer:
No higher than 5% of LEL.
Correct answer:
No higher than 10% of LEL.
Question asked (32435):
A ship experiences an interaction effect known as "Squat" when moving in shallow
water. The amount of Squat is affected by the speed of the vessel through the water. If
the speed through the water is HALVED what will be the change in the affect of "Squat"
Selected answer:
The squat effect will also be halved. Correct answer:
The squat effect will be reduced to a quarter of its original value Question asked
(32842):
What actions should the Officer of the Watch take when the ship's steering gear fails?
Selected answer:
Stop engines and display the NUC signal Correct answer:
All of the suggested answers
Question asked (33619):
What, by definition in the International Collision Regulations, is a "vessel restricted in
her ability to manoeuvre"? Selected answer:
A vessel engaged in underwater work, such as the laying, picking up or servicing of a
pipeline, or which is in support of diving operations, performing dredging and mine-
clearance or is deploying or recovering a pilot.
Correct answer:
A vessel which from the nature of her work is restricted in her ability to manoeuvre as
required by the Rules and is therefore unable to keep out of the way of another vessel.
Question asked (33649):
Under most circumstances, how will communication be carried out between a ship and
a SAR helicopter? Selected answer: On 410 KHz. Correct answer: On VHF Ch 16.
Question asked (33661):
Substances, materials and articles shall be stowed as indicated in the Dangerous
Goods List of the IMDG Code, in accordance with a series of stowage categories. How
are those categories designated?
Selected answer:
Three categories, numbered I, ii and iii. Correct answer:
5 categories, labelled A-E.
Question asked (33668):
When conducting a risk assessment for a shipboard work activity, what are the two
elements to be considered? Selected answer:
The chance of an incident re-occuring and the potential effects of an loss. Correct
answer:
The potential severity of harm and the likelihood that harm will occur.
Question asked (34337):
After passing through the scrubbing tower in an inert gas system on an oil tanker, what
is the approximate level of carbon dioxide in the inert flue gas?
Selected answer:
1%
Correct answer:
13%
Installation CES version: CES
:i 5.0.3847
Name: i Test date: 19.08.201
0
User ID: | Test type: STCW
Date of Level: Operation
birth: al
Nationality: Russian Federation Department/Function Deck
area:
Academy: Vessel Oil Tanker
type/Propulsion:
Batch:
Show only wrong answers with negative
score: No
Question asked (157):
What other purposes may a fixed fire-detection and alarm system be used for, in
addition to fire indication? (SOLAS 11-2/13.1.14)
Selected answer:
Automatic closing of fire doors
Correct answer:
Controlled closing of fire doors
Question asked (378):
The vessel is to anchor with Pilot onboard. Which of the suggested answers most
accurately define the main duties of the Officer of the Watch on bridge?
Selected answer:
Follow the Master's orders at all times. Correct answer:
Assist the Master and pilot and monitor the ships position.
Question asked (433):
This vessel is encountered at the mouth of a river which leads to your discharge port.
What do the various shapes tell you? Selected answer:
This is a vessel engaged in dredging or underwater operations. The two balls in a
vertical line indicate the side on which it is safe to pass; the two diamonds in a vertical
line indicate the side on which an obstruction exists; the ball / diamond / ball indicate
that the vessel is restricted in her ability to manoeuvre.
Correct answer:
This is a vessel engaged in dredging or underwater operations. The two balls in a
vertical line indicate the side on which an obstruction exists; the two diamonds in a
vertical line indicate the side on which it is safe to pass; the ball / diamond / /ball in a
vertical line indiacte that the vessel is restricted in her ability to manoeuvre.
Question asked (773):
Two vessels are meeting each other in confined waters. What would be the effects of
interaction between the two vessels as they approach each other?
Selected answer:
Each vessel will experience an increase in speed Correct answer:
The bows of the ships will be pushed away from each other
Question asked (806):
What would be the stopping distance of a VLCC when proceeding at 8 knots in deep
water and the engines are put 'Full Astern'? Selected answer: 15 ship lengths
Correct answer:
Varies, but can be determined from trial data Question asked (1045):
What is the best way to avoid pollution from small oil-spills aboard a ship? Selected
answer:
Have dispersing chemicals ready for use in case of oil-spill Correct answer:
Sitting on a chair, leaning forward, with two fingers pressing the nose together.
Call the bridge and request for position and permission to discharge overboard through
The absolute vapour pressure of the liquid at 37.8 degrees C. Question asked
(3012):
In respect of exposure to vapours from oil cargoes, how is the value of "Short Term
Exposure Limit" determined? Selected answer:
The airborne concentration of a toxic substance averaged over any 30 minute period,
usually expressed in ppm. Correct answer:
The airborne concentration of a toxic substance averaged over any 15 minute period,
usually expressed in ppm.
Question asked (5476):
The traffic list of a coast-station is a list of: Selected answer:
Pertinent navigational -and weather information Correct answer:
(5523):
You wish to send a message via an Inmarsat-C installation to an Inmarsat-A telex
installation. The message is composed in 'ASCII'. The message can be sent:
Selected answer:
As a telex Correct answer:
As a fax
Question asked (5600):
For a "distress alert" via the DSC, the MF-band is used in the frequencies:
Selected answer:
TX: 2189.5 kHz RX: 2189.5 kHz
Correct answer:
TX: 2187.5 kHz RX: 2187.5 kHz
Question asked (5603):
What mode is used for broadcast an MF/HF-DSC message: Selected answer:
Correct answer:
J2B/F1B
Question asked (5636):
Is it necessary in case of a distress alert via the Inmarsat A terminal to use the distress
priority? Selected answer:
No, the connection could never be made faster than technique allows Correct answer:
Yes, by using "distress priority" one is always assigned a channel Question asked
(5764):
The correct functioning of a DSC-modem can be checked by means of: Selected
answer:
The testing-mode of the ever present VHF-DSC-EPIRB Correct answer:
The built-in test facility in the modem
Question asked (10226):
Which deck is the "bulkhead deck"? Selected answer:
A deck between two transverse bulkheads Correct answer:
The uppermost deck to which transverse bulkheads are carried Question asked
(20157):
Which item among those below is included in the normal equipment of every lifeboat?
Selected answer:
Sea-charts and navigating equipment
Correct answer:
One set of fishing tackle
Question asked (20315):
How many Radar Transponders (SART) are required to be carried onboard a ship for
use in survival crafts?
Selected answer:
Two on each side of the ship
Correct answer:
One on each side of the ship
Question asked (20371):
When mustered to an abandon ship drill, what is the first thing you do when entering the
muster station?
Selected answer:
Report your presence
Correct answer:
Put on a life jacket
Question asked (31307):
What is the main theme of modern safety practice? Selected answer:
Use the same practice that has been in place for some time Correct answer:
(31444):
What is the ideal humidity in a working environment? Selected answer: 70-85%.
Correct answer:
40-60%.
Question asked (31448):
How much can the concentration of oxygen in the air decrease before it is dangerous to
stay in the atmosphere without breathing apparatus?
Selected answer:
Correct answer:
2-3%
Question asked (31604):
The ship is involved in a collision, what is the immediate action by the Officer of the
Watch after the incident has taken place? Selected answer:
Call the Master and check the position for any immediate dangers. Correct answer:
Sound the General Alarm and stop engines.
Question asked (32021):
"What do crew, visitors and contractors all have in common?" Selected answer:
They're all trained in ship emergency procedures. Correct answer:
They all have opportunity to smuggle drugs.
Question asked (32274):
What is the purpose of the "Mud Box" on a tanker? Selected answer:
It is the box under the manifold to catch spills when connecting the discharge or loading
hose. Correct answer:
It is at the end of the pipeline in the tank and restricts any particles and solids entering
By taking a transit bearing of two fixed geographical positions and comparing it with the
The vessel has weighed the anchor and is heading for sea. The anchor is to be stowed
What possible reason could there be for the identification mark associated with a Racon
In oil cargo calculations, what is ASTM table 53A/B used for? Selected answer:
On entering with a standard density at 15 degrees Celsius, a correction factor is found
that will convert the volume in U.S. barrels (bbls) to cubic metres.
Correct answer:
On entering with a given density at the observed temperature, the corresponding
density at the standard 15 degrees Centigrade is found.
Question asked (2994):
If an oil tanker is built with a "free flow system", what does this mean? Selected
answer:
That the cargo is free flowing in all tanks at all times.
Correct answer:
A vessel without ordinary bottom lines where the cargo flows from tank to tank through
bulkhead valves.
Question asked (3234):
Are there any restrictions about how much sludge we can pump overboard on the sea
The IMO Standard Marine Communication Phrases are recommended to be used when
When on HF band a DSC distress alert is received, you have to listen to: Selected
answer:
The radio-telex distress frequency in the band in which the DSC distress alert was
received
Correct answer:
The radio telephony distress frequency in the band in which the DSC distress alert was
received
Question asked (5788):
A SART must, when the vessel sinks:
Selected answer:
Automatically released and then automatically activated
Correct answer:
Be taken by the crew to the rescue-boat and turned on manually
Question asked (5870):
What is important to check when transferring a position from the GPS output to a paper
Which of the following is the correct minimum carriage requirement for a ship of more
than 300 gross tons and operating in area A2: Selected answer:
1 VHF RT + DSC+ DSC watch receiver - 1 or 2 SART - 1 NAVTEX or 1 EGC receiver -
1 INMARSAT A,B or C - 1 EPIRB - 1 MF RT + DSC+ DSC watch receiver
Correct answer:
1 VHF RT + DSC+ DSC watch receiver - 1 or 2 SART - 1 NAVTEX or 1 EGC receiver -
2 or 3 VHF portable - 1 EPIRB - 1 MF RT + DSC+ DSC watch receiver
Question asked (10031):
A flame detector is activated by:
Selected answer:
Smoke, gas, sparks and high temperature
Correct answer:
The infrared radiation and ultraviolet radiation given off by flames
Question asked (10090):
The discharge arrangements for halogenated hydrocarbon total flooding systems shall
be so designed that the minimum quantity of medium can be discharged in (based on
the discharge of the liquid phase):
Selected answer:
45 seconds or less
Correct answer:
20 seconds or less
Question asked (20371):
When mustered to an abandon ship drill, what is the first thing you do when entering the
Why are the tank lids and other access points usually round on the deck of an oil
Installation: Name:
CES 5.0.3847
24.08.2010
STCW
User ID:
Date of birth:
Nationality:
Academy:
CES version: Test date: Test type: Level:
Operational
Department/Function area: Deck Vessel type/Propulsion: Oil Tanker
Batch:
Show only wrong answers with negative score: No Question asked (671):
What sound signal shall be used on ship's whistle when there is a man overboard?
Selected answer: 5 short blasts repeatedly Correct answer:
3 long blasts repeatedly
Question asked (681):
What can be used to reduce the effect of the state of sea-waves? Selected answer:
Crude Oil Correct answer:
Vegetable / Fish Oil
Question asked (697):
What would be considered the most favourable heading of a ship when launching a
lifeboat? Selected answer:
The ship should lie stopped in the water with the weather on the opposite side to the
boat to be launched Correct answer:
The ship should steer about 30 degrees off the prevailing weather and sea with the boat
This will give the stern a lift force to starboard Question asked (847):
What is the correct understanding of the term "bank effect"? If a ship was approaching
the bank at an angle, what would be the effect on the ship?
Selected answer:
The whole vessel would continue straight towards the bank and would require a large
helm order to avoid going aground. Correct answer:
The vessel's bow is pushed away from the bank
Question asked (1087):
When documenting Crude Oil Washing operations in the Oil Record Book, which of the
following must be included in the sequence of entries?
Selected answer:
The ullage in the tank at the commencement of washing Correct answer:
The method of establishing that the cargo tanks were dry
Question asked (1652):
What are class "C" bulkheads? Selected answer:
Bulkheads constructed of approved non-combustible materials that can withstand the
standard fire test for 15 minutes. Correct answer:
Bulkheads constructed of approved non-combustible materials but do not meet any of
the requirements relative to smoke and flame nor limitations relative to temperature rise.
Question asked (2451):
Why should Ground Stabilised True Motion display mode be avoided when using the
Arpa for anti-collision purposes Selected answer:
True motion does not provide the collision risk of other ships Correct answer:
The collision regulations are based on ship courses through the water. Question
asked (2771):
On oil tankers, the effluent water from an inert gas scrubber and the condensate water
which collects in the deck main has which of the following chemical characteristics?
Selected answer:
It is neutral. Correct answer:
It is acidic.
Question asked (2794):
When carrying out a Crude Oil Washing operation, why is it a necessary to partly
discharge the tank before commencing washing? Selected answer:
It is essential that the nozzles of a tank-washing machine can rotate freely at a minimum
distance of 1 metre above the surface of the cargo. By part-discharging the tank, this
distance is guaranteed.
Correct answer:
It is essential that only "dry" oil is used, to avoid the risk of electrostatic discharge from
water droplets. By part-discharging the tank, any water that has settled out on the
voyage and is lying under the oil will be removed.
Question asked (2885):
What does crude oil consist of? Selected answer:
A natural mixture of carbon and sulphur isomers. Correct answer:
A natural mixture of simple and complex hydrocarbon compounds.
Question asked (2920):
What is the purpose of the deck water seal on the deck of an oil tanker? Selected
answer:
To automatically compensate for temporary fluctuations in inert gas pressure within the
cargo spaces. Correct answer:
To prevent the passage of petroleum gases back to the machinery spaces. Question
asked (2922):
You are the Officer on Watch on an oil tanker during a discharging operation. An alarm
on the Inert Gas Plant indicates that no inert gas is being supplied to replace the
discharging cargo. What will you do?
Selected answer:
Activate the inert fans and blow fresh air into the cargo tanks.
Correct answer:
Immediately stop the discharging.
Question asked (2949):
The arrival ballast water on non SBT vessels must contain maximum 15ppm (parts pr.
million) of oil to fulfil the regulations in force. How many ppm is 1 % by volume.
Selected answer:
100 ppm.
Correct answer:
10,000 ppm.
Question asked (3295):
From where on board can you find out the different types of protection equipment
regarding where placed, how much, how many etc.?
Selected answer:
In the deck log book
Correct answer:
The ship's safety plan
Question asked (3772):
If Mouth - to - Mouth (M-T-M) ventilation by itself is unsuccessful and the casualty's
heart stops, or has stopped beating, you must perform External Chest Compression
(ECC) in conjunction with M-T-M. What is the complete rate when performing ECC?
Selected answer:
Complete 10 compressions at the rate of 40 compressions per minute. Correct
answer:
(5506):
In the traffic list a coast-station indicates that there is a radio telex-message for a
vessel. To call for the message one should put in: Selected answer:
After ga+ the radio telex-command msg+ Correct answer:
After ga+ the radio telex-command msg+?
Question asked (5527):
Inmarsat Telex Service code '31' can be used: Selected answer:
When technical problems are experienced with the Inmarsat terminal Correct answer:
To ask for maritime inquiries
Question asked (5613):
A DSC-message of the "safety" category is received from another vessel on VHF
channel 70. Conforming to the GMDSS rules, for the continuation of the safety traffic,
you must change to VHF-channel:
Selected answer: Correct answer:
Question asked (5684):
When onboard channel 16 is used fora shore radio-connection, you always work:
Selected answer: On low power Correct answer:
Simplex
Question asked (5767):
The proper operation of the telex mode of an Inmarsat-A terminal can be tested by:
Selected answer:
Sending a message to HF DSC
Correct answer:
Requesting an " automatic linetest"
Question asked (5779):
The position that is determined by built in GPS-receiver in an Inmarsat-EPIRB has an
accuracy of about: Selected answer: 4200 meters Correct answer:
200 meters
Question asked (5957):
What is the purpose of the SQUELCH on a VHF transmitter/receiver? Selected
answer:
increase the sound signal of the receiver Correct answer:
" reduce the ""noise"" in the background"
Question asked (6050):
" On area A4 the function "" Transmission and reception of on scene communications""
is mainly based on:"
Selected answer:
the use of HF DSC
Correct answer:
the use of MF and/or VHF R/T
Question asked (6122):
The normal mode of operation for each coast station shall be indicated in:
Selected answer:
The ITU List of Ship Stations
Correct answer:
The ITU List of Coast Station
Question asked (10031):
A flame detector is activated by: Selected answer:
Smoke, gas, sparks and high temperature Correct answer:
The infrared radiation and ultraviolet radiation given off by flames Question asked
(20168):
You are on board a ship which is not specially fitted for navigation in cold regions. At
what ambient temperature should the engine of the lifeboat *start within less than 2
minutes ?
Selected answer:
until - 5C Correct answer:
until - 15C
Question asked (31485):
What colour flare is used to signal a safe landing place for small boats ? Selected
answer:
The Metacentric Height (GM) would have to be considered. Question asked (32785):
Where can the size of the Magnetic Compass Error be found? Selected answer:
By taking the error from the Deviation Table on the bridge Correct answer:
By taking a transit bearing of two fixed geographical positions and comparing it with the
bearing of the same points on the chart
Question asked (32792):
Is the location of the Compass Binnacle critical? Selected answer:
Yes, it should be on the fore and aft centreline of the ship Correct answer:
Yes, for the reasons stated in all of the suggested answers Question asked (32809):
What is the direction of wind associated with an anticyclone (area of high pressure) in
the Northern Hemisphere? Selected answer:
Anticlockwise around the high pressure Correct answer:
Clockwise around the high pressure
Question asked (32853):
What can be done to minimize the reduction of GM due to free surface? Selected
answer:
Load fluids only into tanks with transverse subdivision bulkheads Correct answer:
Reduce the number of slack tanks.
Question asked (32886):
What are the ideal conditions required to satisfactorily conduct Selected answer:
Show only wrong answers with negative score: No Question asked (132):
According to basic principles regarding fire protection the ship is to be divided in zones
by structural and thermal boundaries. (SOLAS II- 2/2.2.1)
Selected answer:
In main zones according to utilization (Accommodation, Machinery, Cargo)
Correct answer:
In main vertical zones
Question asked (379):
The vessel has weighed the anchor and is heading for sea. The anchor is to be stowed
answer:
Correct answer:
32
Question asked (10031):
A flame detector is activated by:
Selected answer:
Smoke, gas, sparks and high temperature
Correct answer:
The infrared radiation and ultraviolet radiation given off by flames
Question asked (10067):
*For how long should the self contained air support system on a totally enclosed lifeboat
having its engine running be capable of providing safe and breathable air ?
Selected answer:
20 minutes
Correct answer:
10 minutes
Question asked (20349):
Hand flares and buoyant smoke signals can continue to burn or emit smoke after having
What is the purpose of having corrugations in the bulkheads in the cargo tanks of an oil
You are approaching the port entrance. What do these lights mean? Selected answer:
Vessels may proceed - two-way traffic.
Correct answer:
A vessel may proceed only when she has received specific orders to do so.
Question asked (33838):
The superstructure and deck houses of passenger ships carrying more than 36
passengers shall be divided into main vertical zones by
Selected answer:
Class "B" division
Correct answer:
Class "A" division
Question asked (33990):
In describing oil cargoes, what is "sour crude"?
Selected answer:
A crude oil cargo which has left substantial residues in the bottom of the tank after
discharge
Correct answer:
A term used to describe crude oil or products containing appreciable amounts of
hydrogen sulphide and / or mercaptans
Question asked (34506):
The abbreviation "NPSH" is often seen in connection with the efficiency of cargo pumps
on oil tankers. What does this abbreviation stand for?
Selected answer:
Nominal Pressure Suction Head.
Correct answer:
Net Pressure Suction Head.
Installation: Name: User ID: Date of birth: Nationality: Academy: Batch:
ration
No
Show only wrong answers with negative score:
CES version: CES 5.0.3847
Test date: 27.08.2010
Test type: STCW
Level: Management
Department/Function area: Deck Vessel type/Propulsion: Oil Tanker
Question asked (373):
You are the Master onboard at a VLCC of 280.000 tdw and have received a telex from
the Cargo Terminal asking if your SPM moorings are according to the OCIMF standard.
What fittings must you have to comply?
Selected answer:
One tongue-type/hinged bowstopper with centre bow closed fairlead - Capacity 200
tons Correct answer:
Wire from a deep sea tug connected to the ship's anchor chain. Question asked
(1017):
According to 33 CFR 156, oil tankers trading in US waters are required to test and
document the testing of cargo transfer hoses and transfer pipe system. What is the
minimum requirement when testing these components?
Selected answer:
That no leakage occurs under dynamic fluid pressure of less than 1.5 times the
maximum allowable working pressure. Correct answer:
That no leakage occurs under static liquid pressure of at least 1.5 times the maximum
allowable working pressure.
Question asked (1070):
When a vessel violates the oil pollution laws, who may be held responsible? Selected
answer: Shipowners only Correct answer:
Any one involved in the operation
Question asked (1083):
What is the definition of volatile liquids (oil/oil products? Selected answer:
Liquids with flashpoint below 40 degrees C. Correct answer:
Liquids with flashpoint below 60 degrees C.
Question asked (2446):
What is the correct setting of the "Anti sea clutter" control on the radar? Selected
answer:
No sea returns left on the screen which may confuse with small target echoes near the
ship. Correct answer:
A few sea returns remaining on the screen.
Question asked (3418):
What is the definition of "clingage"? Selected answer:
Cleanliness of cargo tanks on completion of Crude oil Washing (COW). Correct
answer:
On the bases of a six second minimum charge with six second incremental steps
Display NUC lights and investigate the tidal flow over the next 24 hours and the
Upper and lower connection of main side frames Question asked (34343):
In oil cargo calculations, what is the relationship between absolute and gauge pressure?
Selected answer:
Absolute pressure = gauge pressure x 0.947 barometric pressure. Correct answer:
Absolute pressure = gauge pressure + barometric pressure.
Name: User ID:
Installation: SCF Unicom
SERGEY STEPANISHCHEV 2311886
Date of birth: 04.01.1975 Nationality: Russian Federation Academy:
CES version:
Test date: Test type: Level:
CES 5.0.3847 26.08.2010 STCW
Management
Department/Function area: Deck Vessel type/Propulsion: Oil Tanker
Batch:
Show only wrong answers with negative score: No Question asked (212):
Which organization or administration is responsible for surveys and inspections of ships,
and the issue of Safety Certificates? Selected answer:
Ships Classification Associations (Lloyd's, American Bureau of Shipping, The
Norwegian Veritas, Germanische Lloyd's, etc.) Correct answer:
One ballast voyage before proceeding to a repair port. Question asked (2887):
Subject to allowance by the Port State Authority, a tanker with a defective oil discharge
monitoring and control system (ODME) may continue to trade for a limited period before
a repair is effected. What period is allowed and what conditions apply?
Selected answer:
The vessel may discharge her cargo but will then be detained in port until the ODME is
made fully operational and approval from the Port State Authority obtained.
Correct answer:
One ballast voyage before proceeding to a repair port. Question asked (3005):
Some centrifugal cargo pumps on oil tankers are designed with an automatic stripping
system, which allows the cargo tank to fully discharge its contents. By what principle
does such a stripping system operate?
Selected answer:
By the optimum size and positioning of the suction inlet that feeds the automatic
stripping system, which ensures that the cargo oil tank is discharged to the maximum
possible extent.
Correct answer:
On the basis that, if cargo vapour can be stopped from entering the cargo pump suction
inlet, the flow will continue without cavitation.
Question asked (3242):
What does STCW deal with? Selected answer:
STCW deals with training centre and schools and standards for watch keepers Correct
answer:
STCW deals with minimum recommendation of education for seafarers and minimum
standards for training centre and schools
Question asked (3714):
A 6-men inflatable liferaft shall be carried as far forward as is reasonable and
practicable. Where is the best stowing position? Selected answer:
Aft of the forecastle secured with the use of hydrostatic release device. Correct
answer: Under the forecastle.
Question asked (5493):
The input of an area code prefix in (radio)telex-traffic: Selected answer:
Has to be put in without the zero
Correct answer:
Differs for each country
Question asked (5500):
With what system is a NAVTEX-message transmitted? Selected answer:
ARQ
Correct answer:
FEC
Question asked (5518):
Via Inmarsat-C a message is sent to an Inmarsat-C mailbox with a positive delivery
notification (PDN). The ground station will:
Selected answer:
Not send any PDN for this message
Correct answer:
Send a PDN, if the message has arrived in the mailbox Question asked (5583):
You receive via the 8 MHz a DSC distress alert. The received DSC message is however
distorted. The MMSI as well as the position are illegible. After listening at the 8 MHz
telephone distress frequency, nothing is heard. This is because:
Selected answer:
First an acknowledgement of a coastguard station must be received via the 8MHz
Correct answer:
Telephone signals in the same frequency band are generally weaker than DSC signals
Risk is a situation involving exposure to danger and includes both identification of the
occurrence and the likelihood that it will happen. Question asked (10381):
*Which of the following items must be included in each fire drill? Selected answer:
Starting a fire pump using at least two required jets of water to show that the system is
in proper working order
Correct answer:
All the items mentioned
Question asked (20322):
Give the meaning of the following symbol Selected answer:
Survival craft portable radio
Correct answer:
EPIRB
Question asked (20351):
A hand flare must have a burning period of at least Selected answer:
5 Min
Correct answer:
1 Min
Question asked (31027):
What is the period of validity of the Safety Management Certificate Selected answer:
1 Year
Correct answer:
5 years
Question asked (31464):
A ship in distress should transmit the appropriate alarm signal followed by the distress
call and message on one or all of the international distress frequencies. Which of
frequencies is in accordance with the present recommendations?
Selected answer:
550 kHz, 2182 kHz and 121.5 MHz Correct answer:
500 kHz, 2182 kHz and 156.8 MHz
Question asked (32111):
In which of these circumstances can your ship request a DoS? Selected answer:
Your ship is operating at a lower security level than the ship or port it is interfacing with.
Correct answer:
Your ship is conducting activities with a port or ship that is not required to implement an
approved security plan.
Question asked (32145):
Which of these measures would you implement to prevent drugs from being smuggled
onboard your ship while it's berthed? Selected answer:
"Search some of the packages, spares and stores received." Correct answer:
Maintain restricted areas.
Question asked (32206):
A tanker in ballast, having recently left the discharge port is involved in a collision. The
two vessels are still interlocked after the collision and a survey of the ships gives all
crew members are safe and the damage is focussed to the vicinity of the impact. What
should be the greatest concern at this time?
Selected answer:
The possibility of pollution. Correct answer:
The ships moving together in the swell/seaway will cause a spark and consequently an
explosion.
Question asked (32255):
A system for the continuous monitoring of the concentration of hydrocarbon gas shall be
fitted in cargo pump-rooms of oil tankers. A continuous alarm shall be automatically
activated when the hydrocarbon gas concentration reaches a pre-set level. What are
the criteria for pre-setting the alarm level?
Selected answer:
No higher than 5% of LEL. Correct answer:
No higher than 10% of LEL.
Question asked (32435):
A ship experiences an interaction effect known as "Squat" when moving in shallow
water. The amount of Squat is affected by the speed of the vessel through the water. If
the speed through the water is HALVED what will be the change in the affect of "Squat"
Selected answer:
The squat effect will also be halved. Correct answer:
The squat effect will be reduced to a quarter of its original value Question asked
(32842):
What actions should the Officer of the Watch take when the ship's steering gear fails?
Selected answer:
Stop engines and display the NUC signal Correct answer:
All of the suggested answers
Question asked (33619):
What, by definition in the International Collision Regulations, is a "vessel restricted in
her ability to manoeuvre"? Selected answer:
A vessel engaged in underwater work, such as the laying, picking up or servicing of a
pipeline, or which is in support of diving operations, performing dredging and mine-
clearance or is deploying or recovering a pilot.
Correct answer:
A vessel which from the nature of her work is restricted in her ability to manoeuvre as
required by the Rules and is therefore unable to keep out of the way of another vessel.
Question asked (33649):
Under most circumstances, how will communication be carried out between a ship and
a SAR helicopter? Selected answer: On 410 KHz. Correct answer: On VHF Ch 16.
Question asked (33661):
Substances, materials and articles shall be stowed as indicated in the Dangerous
Goods List of the IMDG Code, in accordance with a series of stowage categories. How
are those categories designated?
Selected answer:
Three categories, numbered I, ii and iii.
Correct answer:
5 categories, labelled A-E.
Question asked (33668):
When conducting a risk assessment for a shipboard work activity, what are the two
elements to be considered? Selected answer:
The chance of an incident re-occuring and the potential effects of an loss. Correct
answer:
The potential severity of harm and the likelihood that harm will occur.
Question asked (34337):
After passing through the scrubbing tower in an inert gas system on an oil tanker, what
is the approximate level of carbon dioxide in the inert flue gas?
Selected answer:
1%
Correct answer:
13%
Name: User ID:
Installation: SCF Unicom
IGOR VALERYEVICH KARPOV 2311749
Date of birth: 24.03.1974 Nationality: Russian Federation Academy:
CES version:
Test date: Test type: Level:
CES 5.0.3847 26.08.2010 STCW
Management
Department/Function area: Deck Vessel type/Propulsion: Oil Tanker
Batch:
Show only wrong answers with negative score: No
Question asked (704):
What is EPIRB an abbreviation for? Selected answer:
Emergency Position Indication Radio Buoy. Correct answer:
Evaluation of the situation, rescue and life-saving, confinement of fire, extinction, then
length = 480 mm, breadth = 115 mm, depth = 25 mm Question asked (20388):
*When reasonable and practicable, how often shall rescue boats be launched with their
assigned crew aboard and manoeuvred in the water?
Selected answer:
Every six months
Correct answer:
Every month
Question asked (20428):
If a distress signal is received on board your ship, what should be the first action that
should be taken? Selected answer:
Contact SAR Authorities via nearest coastal Radio station Correct answer:
Attempt to establish contact with the distressed vessel
Question asked (32249):
According to MARPOL there are requirements regarding minimum amidships draught
for crude oil tankers in ballast condition. What is the formula for calculating minimum
draught amidships?
Selected answer:
2.0 + 0.02L Correct answer:
2.0 + 0.02L
Question asked (33628):
You are in an area of restricted visibility. You hear this sound signal. What does it
mean? Selected answer:
That there is a vessel at anchor in the vicinity. Correct answer:
That there is a vessel in distress nearby.
Question asked (33661):
Substances, materials and articles shall be stowed as indicated in the Dangerous
Goods List of the IMDG Code, in accordance with a series of stowage categories. How
are those categories designated?
Selected answer:
Three categories, numbered I, ii and iii.
Correct answer:
5 categories, labelled A-E.
Question asked (33664):
What may be issued by the shipper to indicate that a vessel or her operators will not be
held responsible for any damage that may arise from the carrier issuing a clean Bill of
Lading, even though the Mate's receipt is marked as "unclean", such as may apply to
atmospheric corrosion on steel plates that have been waiting in a port facility for some
time awaiting shipment?
Selected answer:
Don't know
Correct answer:
A Letter of Indemnity.
Question asked (33682):
Who will verify the computational results and actual ship data used by the calculation
program on a vessel's stability computer? Selected answer:
The engineer attending the installation and initial on-site testing.
Correct answer:
The Classification Society.
Question asked (33988):
Found in a commonly-used piece of equipment aboard an oil tanker, what does a
"pellistor" do? Selected answer:
It is the common term applied to the metal, ceramic or other heat-resisting material
which can cool even an intense flame below the temperature required for ignition, as
utilised in a flame arrester
Correct answer:
It is an electrical sensor unit fitted in a flammable gas detector for measuring
hydrocarbon vapours and air mixtures to determine whether the mixture is within the
flammable range
Question asked (34334):
In ISGOTT, petroleum products are divided into two general groups for the purposes of
indicating flammability, based on flashpoint and vapour pressure. These two groups are
named 'Volatile' and 'Non-volatile'. To be considered Non-volatile, which of the following
criteria must be met?
Selected answer:
With a Flashpoint of 60 degrees C or above (open cup method), these liquids produce,
when at any normal ambient temperature, equilibrium gas concentrations above the
Upper Flammable Limit.
Correct answer:
With a Flashpoint of 60 degrees C or above (closed cup method), these liquids produce,
when at any normal ambient temperature, equilibrium gas concentrations below the
Lower Flammable Limit.
Question asked (34344):
MARPOL Annex VI and IMO MSC Circ 585 "Standards for Vapour Emission Control
Systems" require that P/V valves in such a system on an oil tanker should relieve the
pressure or vacuum once they reach specified levels in a cargo tank. The design is
approved by the administration, but what are the usual pressure and vacuum levels
required to activate the P/V valves?
Selected answer:
Pressure: 3.2 psi (0.22 bar) Vacuum: 1 psi (0.069 bar) Correct answer:
Pressure: 1 psi (0.069 bar) Vacuum: 0.5 psi (0.034 bar) Question asked (34495):
What kind of Crude Oils are required by MARPOL to be specifically listed in a tanker's
Crude Oil Washing manual as unsuitable for cleaning by that method?
Selected answer:
Those on the IMO Oil Tanker Technical Committee COW banned list. Correct answer:
Those with high pour point or viscosity.
Name: User ID:
Installation: SCF Unicom
IGOR VALERYEVICH KARPOV 2311749
Date of birth: 24.03.1974 Nationality: Russian Federation Academy:
CES 5.0.3847
CES version:
Test date: Test type: Level:
19.08.2010
STCW
Management
Department/Function area: Deck Vessel type/Propulsion: Oil Tanker
Batch:
Show only wrong answers with negative score: No Question asked (1017):
According to 33 CFR 156, oil tankers trading in US waters are required to test and
document the testing of cargo transfer hoses and transfer pipe system. What is the
minimum requirement when testing these components?
Selected answer:
That no leakage occurs under dynamic fluid pressure of less than 1.5 times the
maximum allowable working pressure. Correct answer:
That no leakage occurs under static liquid pressure of at least 1.5 times the maximum
Likely cause a sudden or violent list due to the very large free surface in the broad
On the basis that, if cargo vapour can be stopped from entering the cargo pump suction
inlet, the flow will continue without cavitation. Question asked (3006):
According to the Oil Pollution Act of 1990 (OPA-90), oil carrying vessels trading in U.S.
waters are required to carry oil spill clean up equipment for the containment and
removal of on-deck spills. For a vessel of over 400 feet (121.9 metres) in length, what
volume of oil must they be able to handle?
Selected answer:
1 barrel (0.16 cubic metre). Correct answer:
12 barrels (1.91 cubic metres).
Question asked (3233):
How many annexes do we find in MARPOL 73/78 and what is the content of annex 1 ?
Selected answer:
We find 5 annexes in MARPOL 73/78 and annex 1 is the regulations for the prevention
of pollution by sewage Correct answer:
We find 6 annexes in MARPOL 73/78 and annex 1 is the regulations for the prevention
A traffic list with the call-sign of the ships involved in alphabetical numerical sequence
Only send a positive delivery notification (PDN) to the sender if the sender requested,
At sea, outside territorial waters, and in port or harbour Question asked (5883):
What is understood by the term "Balanced Rudder"?
Selected answer:
A rudder with equal rudder area forward and aft of the turning axis, the turning axis
Correct answer:
proper way:
it can be automatically compared and corrected
being at the geometrical centre of the rudder area the load on the steering motor.
A rudder with part of the rudder area forward of the turning axis, therefore reducing
Question asked (31029):
What does ISM stand for? Selected answer: Internal Ship Safety Management
Correct answer:
The International Management Code for the Safe Operation of Ships and for Pollution
"Seal spaces that are not in use while in port, and perform a search of the ship before
A report giving the result of the Conformance Test, issued by the Classification Society
asked (33936):
When does a bulk carrier experience extreme tension in bottom structure during fast
rate loading? Selected answer:
During correct loading pattern but with heavy cargo Correct answer:
Show only wrong answers with negative score: No Question asked (377):
A large vessel is coming alongside a pier with two tugs assisting and there is little wind
or current affecting the vessel. What would be considered the best use of the tugs and
at which position?
Selected answer:
Made fast Forward and Aft using the centre leads.
Correct answer:
Pushing on the ship's side and made fast in case the vessel's movement towards the
berth requires reducing by the tug pulling off. Question asked (838):
Your vessel is to leave a crowded anchorage making a 180 degrees turn. The ship has
a right-handed propeller and there is equal space either side of the ship (as illustrated).
What would be the most suitable method to make the turn using as little space as
possible?
Selected answer:
Rudder hard to starboard, full ahead. Rudder hard to port, full astern. Repeating this
manoeuvre until the turn has been made. Correct answer:
Rudder hard to port, full astern. After gaining some sternway, rudder hard to starboard
Disperse or dissolve the oil into the water Question asked (1060):
You are on a vessel 10 nautical miles off the coast of Nigeria, West Africa. Are you
allowed to dump empty glass bottles overboard ? Selected answer:
Yes, the bottles can be dumped if they are ground so that the resulting particles can
pass through a screen with 50 mm openings
Correct answer:
Yes, the bottles can be dumped if they are ground so that the resulting particles can
pass through a screen with 25 mm openings
Question asked (2000):
What is the result of a "high metacentric height"? Selected answer:
The vessel will have a great bending moment? Correct answer:
The vessel will roll violently?
Question asked (2027):
An Oil tanker experiences large bending moments and therefore the deck scantlings
must be maintained within "x" length amidships, where "x" is:
Selected answer:
Half Length Correct answer:
0.4 Length
Question asked (2181):
What is the name of the reference manual, jointly produced by the International
Maritime Organization and the International Civil Aviation Authority, which currently
outlines the organization and management of search and rescue activities at sea?
Selected answer:
The Internation Maritime Search and Rescue (IMARSAR) Manual. Correct answer:
The International Aeronautical and Maritime Search and Rescue (IAMSAR) Manual.
Wilful misconduct, gross negligence and violation of Federal Safety Question asked
(3212):
What are the conditions that influence the efforts for organising the fire fighting?
Selected answer:
Where the fire break out, how many fire teams are available, what is burning, distance
to the fire station Correct answer:
Where the fire breaks out, how many fire teams are available, the strength of the fire,
the ships mobility, what is burning and communication
Question asked (5493):
The input of an area code prefix in (radio)telex-traffic:
Selected answer:
Has to be put in without the zero
Correct answer:
Differs for each country
Question asked (5562):
When a coastguard-station wants to send a gale-warning by DSC it will happen in the
category:
Selected answer:
Urgency
Correct answer:
Safety
Question asked (5651):
The good operation in any location, whether the NAVTEX is working properly or not,
can be checked using: Selected answer:
Test transmissions specially broadcast for this purpose once a week Correct answer:
A testing program built in for this purpose
Question asked (5708):
By the degree of selectivity of a receiver is meant: Selected answer:
Ability to distinguish weak stations from adjacent stronger stations Correct answer:
Not less than half the total number of lifebuoys shall be provided with self-ignighting
In a secure and sheltered position and protected from damage by fire or explosion.
The ships moving together in the swell/seaway will cause a spark and consequently an
The ship should steer about 30 degrees off the prevailing weather and sea with the boat
This will give the stern a lift force to starboard Question asked (847):
What is the correct understanding of the term "bank effect"? If a ship was approaching
the bank at an angle, what would be the effect on the ship?
Selected answer:
The whole vessel would continue straight towards the bank and would require a large
helm order to avoid going aground. Correct answer:
The vessel's bow is pushed away from the bank
Question asked (1087):
When documenting Crude Oil Washing operations in the Oil Record Book, which of the
following must be included in the sequence of entries?
Selected answer:
The ullage in the tank at the commencement of washing Correct answer:
The method of establishing that the cargo tanks were dry
Question asked (1652):
What are class "C" bulkheads?
Selected answer:
Bulkheads constructed of approved non-combustible materials that can withstand the
standard fire test for 15 minutes. Correct answer:
Bulkheads constructed of approved non-combustible materials but do not meet any of
the requirements relative to smoke and flame nor limitations relative to temperature rise.
Question asked (2451):
Why should Ground Stabilised True Motion display mode be avoided when using the
Arpa for anti-collision purposes Selected answer:
True motion does not provide the collision risk of other ships Correct answer:
The collision regulations are based on ship courses through the water.
Question asked (2771):
On oil tankers, the effluent water from an inert gas scrubber and the condensate water
which collects in the deck main has which of the following chemical characteristics?
Selected answer:
It is neutral. Correct answer:
It is acidic.
Question asked (2794):
When carrying out a Crude Oil Washing operation, why is it a necessary to partly
discharge the tank before commencing washing? Selected answer:
It is essential that the nozzles of a tank-washing machine can rotate freely at a minimum
distance of 1 metre above the surface of the cargo. By part-discharging the tank, this
distance is guaranteed.
Correct answer:
It is essential that only "dry" oil is used, to avoid the risk of electrostatic discharge from
water droplets. By part-discharging the tank, any water that has settled out on the
voyage and is lying under the oil will be removed.
Question asked (2885):
What does crude oil consist of? Selected answer:
A natural mixture of carbon and sulphur isomers. Correct answer:
A natural mixture of simple and complex hydrocarbon compounds.
Question asked (2920):
What is the purpose of the deck water seal on the deck of an oil tanker? Selected
answer:
To automatically compensate for temporary fluctuations in inert gas pressure within the
cargo spaces. Correct answer:
To prevent the passage of petroleum gases back to the machinery spaces. Question
asked (2922):
You are the Officer on Watch on an oil tanker during a discharging operation. An alarm
on the Inert Gas Plant indicates that no inert gas is being supplied to replace the
discharging cargo. What will you do?
Selected answer:
Activate the inert fans and blow fresh air into the cargo tanks.
Correct answer:
Immediately stop the discharging.
Question asked (2949):
The arrival ballast water on non SBT vessels must contain maximum 15ppm (parts pr.
million) of oil to fulfil the regulations in force. How many ppm is 1% by volume.
Selected answer:
100 ppm.
Correct answer:
10,000 ppm.
Question asked (3295):
From where on board can you find out the different types of protection equipment
regarding where placed, how much, how many etc.? Selected answer: In the deck log
book Correct answer: The ship's safety plan
Question asked (3772):
If Mouth - to - Mouth (M-T-M) External Chest Compression
Selected answer:
Complete 10 compressions at the rate of 40 compressions per minute. Correct
answer:
(5506):
In the traffic list a coast-station indicates that there is a radio telex-message for a
vessel. To call for the message one should put in: Selected answer:
After ga+ the radio telex-command msg+ Correct answer:
ventilation by itself is unsuccessful and the casualty's heart stops, or has stopped
beating, you must perform (ECC) in conjunction with M-T-M. What is the complete rate
when performing ECC?
After ga+ the radio telex-command msg+?
Question asked (5527):
Inmarsat Telex Service code '31' can be used: Selected answer:
When technical problems are experienced with the Inmarsat terminal
Correct answer:
To ask for maritime inquiries
Question asked (5613):
A DSC-message of the "safety" category is received from another vessel on VHF
channel 70. Conforming to the GMDSS rules, for the continuation of the safety traffic,
you must change to VHF-channel:
Selected answer:
70
Correct answer:
16
Question asked (5684):
When onboard channel 16 is used for a shore radio-connection, you always work:
Selected answer:
On low power
Correct answer:
Simplex
Question asked (5767):
The proper operation of the telex mode of an Inmarsat-A terminal can be tested by:
Selected answer:
Sending a message to HF DSC
Correct answer:
Requesting an " automatic linetest"
Question asked (5779):
The position that is determined by built in GPS-receiver in an Inmarsat-EPIRB has an
accuracy of about: Selected answer: 4200 meters Correct answer:
200 meters
Question asked (5957):
What is the purpose of the SQUELCH on a VHF transmitter/receiver? Selected
answer:
increase the sound signal of the receiver Correct answer:
" reduce the ""noise"" in the background"
Question asked (6050):
" On area A4 the function "" Transmission and reception of on scene communications""
is mainly based on:"
Selected answer:
the use of HF DSC
Correct answer:
the use of MF and/or VHF R/T
Question asked (6122):
The normal mode of operation for each coast station shall be indicated in:
Selected answer:
The ITU List of Ship Stations
Correct answer:
The ITU List of Coast Station
Question asked (10031):
A flame detector is activated by: Selected answer:
Smoke, gas, sparks and high temperature Correct answer:
The infrared radiation and ultraviolet radiation given off by flames Question asked
(20168):
You are on board a ship which is not specially fitted for navigation in cold regions. At
what ambient temperature should the engine of the lifeboat *start within less than 2
minutes ?
Selected answer:
until - 5C Correct answer:
until - 15C
Question asked (31485):
What colour flare is used to signal a safe landing place for small boats ?
Selected answer:
White
Correct answer:
Green
Question asked (32217):
In discussing the chemistry of oil, to which of the following chemical groups do
Hydrocarbons belong? Selected answer:
Inorganic substances.
Correct answer:
Organic substances.
Question asked (32267):
What new stability problems would be caused by having deep double bottom tanks on
double hull oil tankers? Selected answer:
The depth of the Double bottom would require additional strength members. Correct
answer:
The Metacentric Height (GM) would have to be considered. Question asked (32785):
Where can the size of the Magnetic Compass Error be found? Selected answer:
By taking the error from the Deviation Table on the bridge
Correct answer:
By taking a transit bearing of two fixed geographical positions and comparing it with the
bearing of the same points on the chart
Question asked (32792):
Is the location of the Compass Binnacle critical? Selected answer:
Yes, it should be on the fore and aft centreline of the ship
Correct answer:
Yes, for the reasons stated in all of the suggested answers Question asked (32809):
What is the direction of wind associated with an anticyclone (area of high pressure) in
the Northern Hemisphere? Selected answer:
Anticlockwise around the high pressure
Correct answer:
Clockwise around the high pressure
Question asked (32853):
What can be done to minimize the reduction of GM due to free surface? Selected
answer:
Load fluids only into tanks with transverse subdivision bulkheads
Correct answer:
Reduce the number of slack tanks.
Question asked (32886):
What are the ideal conditions required to satisfactorily conduct an Inclining Experiment?
Selected answer:
All derricks lowered and no moving items on deck and in store rooms
Correct answer:
All of the suggested answers
Question asked (33689):
What is meant by the term "segregation"? Selected answer:
The planned adjacent stowage of packaged goods, thereby confining a listed hazard
within the same area of the ship. Correct answer:
The planned, separated stowage of cargoes that may react dangerously with each other
in the event of leakage or other damage.
Question asked (33692):
What do you understand by the term "luffing"? Selected answer:
The combined movement of hoisting a load and slewing the crane, employed when
lifting a load from a dockside over and into a ship's hold, or vica versa.
Correct answer:
The raising or lowering of a crane jib, moving the head of the crane and therefore a
suspended load horizontally towards or away from the crane.
Question asked (34506):
The abbreviation "NPSH" is often seen in connection with the efficiency of cargo pumps
on oil tankers. What does this abbreviation stand for?
Selected answer:
Nominal Pressure Suction Head. Correct answer:
Net Pressure Suction Head.
Name: User ID:
Installation: SCF Unicom
ARTUR MARTIROSYAN 2312569
Date of birth: 26.05.1966 Nationality: Russian Federation Academy:
CES 5.0.3847
CES version:
Test date: Test type: Level:
24.08.2010
STCW
Management
Department/Function area: Deck Vessel type/Propulsion: Oil Tanker
Batch:
Show only wrong answers with negative score: No Question asked (699):
Which method is used to make a physical connection between a rescue vessel and a
wreck?
Selected answer:
Heaving line
Correct answer:
Rocket line
Question asked (791):
A partially loaded VLCC is drifting with the main engine stopped and undergoing
repairs. The ship is observed to be drifting, due to wind and current towards a danger
area, although there is no immediate concern. What actions would be most suitable in
these circumstances?
Selected answer:
Contact the nearest Coast Radio Station and inform them of your situation. Send out a
navigational warning to ships in the vicinity Correct answer:
Use the Bow Thrusters to change the ships head and monitor any changes in the drift
Rudder hard to port, full astern. After gaining some sternway, rudder hard to starboard
If the whip-antenna is replaced by an antenna of about the same length as the original
Show only wrong answers with negative score: No Question asked (386):
You are on a tug and are towing an unmanned barge. You are restricted in your ability
to manoeuvre. The total length of the tow is 219 metres. What daylight signals are
required by the International Regulations for Preventing Collisions at Sea?
Selected answer:
A diamond shape, where it can best be seen, on the tug only. Three shapes shall also
be displayed, being three balls in a vertical line. Correct answer:
A diamond shape, where it can best be seen shall be displayed on the tug and the tow.
Three shapes shall also be displayed in a vertical line, the upper and lower being balls
and the middle one a diamond. Diamond shape
Question asked (688):
The bridge wheelman has not reported for duty and there is a suspected "Man
Overboard" situation on your vessel. The ship has been searched and there is one
seaman missing? The vessel turns round and retraces the course back, calling for
assistance from other vessels in the vicinity. What should be the focal point for any
search pattern to be established? Selected answer:
The focus of the search should be from the present position as he probably went
overboard when proceeding to the bridge for his watch. Correct answer:
Determine when the seaman was last sighted and concentrate the search round the
course line between the last sighting and present position, taking into account any
prevailing current.
Question asked (2181):
What is the name of the reference manual, jointly produced by the International
Maritime Organization and the International Civil Aviation Authority, which currently
outlines the organization and management of search and rescue activities at sea?
Selected answer:
The Merchant Ship Search and Rescue (MERSAR) Manual. Correct answer:
The International Aeronautical and Maritime Search and Rescue (IAMSAR) Manual.
One ballast voyage before proceeding to a repair port. Question asked (2943):
What is the minimum height of vent outlets of a controlled venting system from cargo
tanks? Selected answer: A height of not less than 3 m.
Correct answer:
A height of not less than 6 m.
Question asked (3005):
Some centrifugal cargo pumps on oil tankers are designed with an automatic stripping
system, which allows the cargo tank to fully discharge its contents. By what principle
does such a stripping system operate?
Selected answer:
By automatically reducing the rate at which oil cargo enters the cargo pump, such that
any vapour lifted along with the liquid does not cause a loss of suction.
Correct answer:
On the basis that, if cargo vapour can be stopped from entering the cargo pump suction
inlet, the flow will continue without cavitation. Question asked (5775):
The accuracy of an Inmarsat-E positioning-system is: Selected answer:
20 meters
Correct answer:
200 meters
Question asked (6035):
Which of the following is a coast station MMSI ? Selected answer:
22753000
Correct answer:
2275300
Question asked (20348):
A rocket parachute flare reaches an altitude of Selected answer:
not less than 40m
Correct answer:
not less than 300m
Question asked (31358):
Which one of the listed requirements regarding life-saving appliances corresponds to
present regulations? Selected answer:
All prescribed life-saving appliances shall be of such a colour that they are in contrast to
the surrounding colour Correct answer:
The risks to ships are not restricted to specific areas or trading routes. Question asked
(32256):
One or more pressure/vacuum-breaking devices shall be provided on the vent mains to
prevent the cargo tanks from being subject to a positive and negative pressure. What is
the normal pre-set point for negative pressure?
Selected answer:
Depending on the test pressure of the cargo tank. Correct answer:
Show only wrong answers with negative score: No Question asked (420):
You are in an area of restricted visibility and hear this signal. It is repeated at two minute
intervals. What does it indicate? Selected answer:
That there is another vessel nearby, but that she is at anchor.
Correct answer:
That there is another vessel nearby, that she is underway, but stopped and making no
(840):
A ship has turned a complete circle (360 degrees) in deep water at full ahead
throughout the turn. The same ship, in the same conditions, is now to make a complete
turn (360 degrees) at half ahead throughout the turn. Would there be any difference in
the size (diameter) of the turning circle?
Selected answer:
Yes, there would be a change of shape of the turning circle; it would have an increase in
the transfer, but not the advance. Correct answer:
No, the diameter of the turning circle would be almost the same. Question asked
(932):
Who will have the authority to take charge and make appropriate decisions in the event
of a vessel emergency when transiting the Panama Canal?
Selected answer:
The ship's Master
Correct answer:
The Panama Canal Authority
Question asked (2029):
A conventional tanker has most of its tanks slack during the discharging of oil cargo, it is
not of any great consequence; however, if an OBO has most of its holds slack during
discharging (or loading) of oil cargo this will:
Selected answer:
Cause extreme strain to the hull on the listed side if a list develops? Correct answer:
Likely cause a sudden or violent list due to the very large free surface in the broad
beamed holds?
Question asked (2251):
Which of the following requirements regarding on board stability data corresponds to
present regulations? (NSCL
4/12.1)
Selected answer:
Drawings and caculations documenting the stability of the ship, both in intact and all
possible damage condition. Correct answer:
A calculation example showing the use of "KG" limitation curves. Question asked
(2308):
Any ship of 10.000 tons gross tonnage and above shall be fitted with oily-water
separating equipment for the control of machinery space bilges.What kind of equipment
is required in this connection?
Selected answer:
Oily-water separating equipment only.
Correct answer:
The vapour pressure of the liquid at 37.8 degrees C. Question asked (3690):
How often shall crew members participate in fire drills? Selected answer: Once every
week Correct answer:
Once every month
Question asked (5536):
The log-in of an Inmarsat-C installation is important: Selected answer:
To keep watch on Sat-C for safety messages Correct answer:
To inform the NCS that one is available for messages offered Question asked
(5552):
To guarantee optimal reception of VHF-DSC-calls, every:
Selected answer:
DSC-calls are repeated untill received
Correct answer:
DSC-symbol is sent twice and checked extra by Error Check Character Question
asked (5638):
If one requires medical advice by means of an Inmarsat-C terminal one should use the
following address: Selected answer:
Radiomedical
Correct answer:
32
Question asked (6049):
" On area A3 the function "" Transmission and reception of on scene communications""
is mainly based on:"
Selected answer:
The use of MF and/or H F R/T
Correct answer:
The use of MF and/or VHF R/T
Question asked (6114):
Operator connected R/T calls are charged Selected answer:
On the basis of a six second minimum charge with one second incremental steps
Correct answer:
On the basis of a three minute minimum charge with one minute incremental steps
Equally spaced and not less than 300 mm or more than 380 mm Question asked
(31373):
Which one of the listed requirements regarding service and maintenance of life-saving
appliances correspond to present regulations? Selected answer:
Maintenance and repair of all the life-saving equipments will be carried out ashore in
work shop only
Correct answer:
(32843):
What action should be taken by the Officer of the Watch when the GPS fails? Selected
answer:
Call the Master
Correct answer:
Inform the technical officer responsible for the electronic navigational equipment and
continue on passage using alternative navigational methods
Question asked (33650):
It has been shown that the controlled release of oil is effective in reducing the effects of
the sea, making it possible for a rescue craft to approach survivors in the water. How
many square metres does the IAMSAR Manual suggest may be calmed by releasing
200 litres of lubricating oil slowly through a rubber hose with the outlet maintained just
above the surface while the ship proceeds at slow speed?
Selected answer:
Approx 50 square metres. Correct answer:
Approx 5,000 square metres.
Question asked (33651):
The recommended distance between parallel tracks (track spacing) in a search for a
casualty by a surface vessel varies (amongst other factors) according to visibility and
the nature of the target in the IAMSAR Manual. These distances are then normally
adjusted for prevailing weather conditions. If visibility was 5 nautical miles and you were
looking for a six-person liferaft, what would the recommended uncorrected track spacing
be?
Selected answer:
5.0 nautical miles. Correct answer:
3.6 nautical miles.
Question asked (33773):
Onboard training should be organised in such a way that: Selected answer:
It does not contravene with the rest hours of the crew Correct answer:
Assist the Master and pilot and monitor the ships position. Question asked (433):
This vessel is encountered at the mouth of a river which leads to your discharge port.
What do the various shapes tell you? Selected answer:
This is a vessel engaged in dredging or underwater operations. The two balls in a
vertical line indicate the side on which it is safe to pass; the two diamonds in a vertical
line indicate the side on which an obstruction exists; the ball / diamond / ball indicate
that the vessel is restricted in her ability to manoeuvre.
Correct answer:
This is a vessel engaged in dredging or underwater operations. The two balls in a
vertical line indicate the side on which an obstruction exists; the two diamonds in a
vertical line indicate the side on which it is safe to pass; the ball / diamond / /ball in a
vertical line indiacte that the vessel is restricted in her ability to manoeuvre.
Question asked (773):
Two vessels are meeting each other in confined waters. What would be the effects of
interaction between the two vessels as they approach each other?
Selected answer:
Each vessel will experience an increase in speed Correct answer:
The bows of the ships will be pushed away from each other Question asked (806):
What would be the stopping distance of a VLCC when proceeding at 8 knots in deep
water and the engines are put 'Full Astern'? Selected answer: 15 ship lengths
Correct answer:
Varies, but can be determined from trial data Question asked (1045):
What is the best way to avoid pollution from small oil-spills aboard a ship? Selected
answer:
Have dispersing chemicals ready for use in case of oil-spill Correct answer:
Sitting on a chair, leaning forward, with two fingers pressing the nose together.
Call the bridge and request for position and permission to discharge overboard through
The absolute vapour pressure of the liquid at 37.8 degrees C. Question asked
(3012):
In respect of exposure to vapours from oil cargoes, how is the value of "Short Term
Exposure Limit" determined? Selected answer:
The airborne concentration of a toxic substance averaged over any 30 minute period,
usually expressed in ppm. Correct answer:
The airborne concentration of a toxic substance averaged over any 15 minute period,
usually expressed in ppm.
Question asked (5476):
The traffic list of a coast-station is a list of: Selected answer:
Pertinent navigational -and weather information Correct answer:
(5523):
You wish to send a message via an Inmarsat-C installation to an Inmarsat-A telex
installation. The message is composed in 'ASCII'. The message can be sent:
Selected answer:
As a telex
Correct answer:
As a fax
Question asked (5600):
For a "distress alert" via the DSC, the MF-band is used in the frequencies:
Selected answer:
TX: 2189.5 kHz RX: 2189.5 kHz
Correct answer:
TX: 2187.5 kHz RX: 2187.5 kHz
Question asked (5603):
What mode is used for broadcast an MF/HF-DSC message: Selected answer:
J3E
Correct answer:
J2B / F1B
Question asked (5636):
Is it necessary in case of a distress alert via the Inmarsat A terminal to use the distress
priority? Selected answer:
No, the connection could never be made faster than technique allows
Correct answer:
Yes, by using "distress priority" one is always assigned a channel
Question asked (5764):
The correct functioning of a DSC-modem can be checked by means of: Selected
answer:
The testing-mode of the ever present VHF-DSC-EPIRB Correct answer:
The built-in test facility in the modem
Question asked (10226):
Which deck is the "bulkhead deck"?
Selected answer:
A deck between two transverse bulkheads Correct answer:
The uppermost deck to which transverse bulkheads are carried Question asked
(20157):
Which item among those below is included in the normal equipment of every lifeboat?
Selected answer:
Sea-charts and navigating equipment
Correct answer: One set of fishing tackle
Question asked (20315):
How many Radar Transponders (SART) are required to be carried onboard a ship for
use in survival crafts?
Selected answer:
Two on each side of the ship
Correct answer:
One on each side of the ship
Question asked (20371):
When mustered to an abandon ship drill, what is the first thing you do when entering the
muster station? Selected answer:
Report your presence
Correct answer:
Put on a life jacket
Question asked (31307):
What is the main theme of modern safety practice? Selected answer:
Use the same practice that has been in place for some time Correct answer:
(31444):
What is the ideal humidity in a working environment? Selected answer: 70 - 85 %.
Correct answer:
40 - 60 %.
Question asked (31448):
How much can the concentration of oxygen in the air decrease before it is dangerous to
stay in the atmosphere without breathing apparatus?
Selected answer:
21 %
Correct answer:
2-3%
Question asked (31604):
The ship is involved in a collision, what is the immediate action by the Officer of the
Watch after the incident has taken place? Selected answer:
Call the Master and check the position for any immediate dangers. Correct answer:
Sound the General Alarm and stop engines.
Question asked (32021):
"What do crew, visitors and contractors all have in common?" Selected answer:
They're all trained in ship emergency procedures. Correct answer:
They all have opportunity to smuggle drugs.
Question asked (32274):
What is the purpose of the "Mud Box" on a tanker? Selected answer:
It is the box under the manifold to catch spills when connecting the discharge or loading
hose. Correct answer:
It is at the end of the pipeline in the tank and restricts any particles and solids entering
Show only wrong answers with negative score: No Question asked (187):
IMO MSC.1/Circ 1321 requires that cargo pump rooms on oil tankers shall be
mechanically ventilated, using non-sparking suction type fans. What is the minimum
number of changes of air per hour that a ventilation system must deliver?
Selected answer:
At least 15 per hour. Correct answer:
At least 20 per hour.
Question asked (2147):
According to the OCIMF Ship to Ship Transfer Guide (Petroleum), which of the following
is the required state of readiness on oil tankers engaged in a cargo transfer?
Selected answer:
The duty engineers of both vessels must be available to prepare the respective main
engines for use throughout the transfer operation. Correct answer:
The main engines of both vessels should be ready for immediate use. Question asked
(2316):
MARPOL 73/78 - Annex IV. Your ship has in operation an approved sewage treatment
plant certified by the Administration. During discharge, while vessel is awaiting pilot off
Cape Henry, USA, the surrounding water is discoloured. What kind of action would be
appropriate to take?
Selected answer:
Continue discharge since Annex IV of MARPOL is internationally not yet in force.
Correct answer:
Stop discharge.
Question asked (2446):
What is the correct setting of the "Anti sea clutter" control on the radar? Selected
answer:
No sea returns left on the screen which may confuse with small target echoes near the
ship. Correct answer:
A few sea returns remaining on the screen.
Question asked (5535):
An Inmarsat-C terminal is suitable for: Selected answer:
Telex only
Correct answer:
Store and forward message
Question asked (5626):
When may a call for radio medical advice be preceded by the urgency-signal: Selected
answer:
Always
Correct answer:
In urgent cases
Question asked (5863):
When initially setting up the GPS to provide positions for use with a paper chart, what
Chart Datum should be selected? Selected answer:
Select the datum stated on the chart in use Correct answer:
Select WGS84 and when plotting on the chart apply the stated corrections.
Question asked (20348):
A rocket parachute flare reaches an altitude of Selected answer: not less than 40m
Correct answer:
not less than 300m
Question asked (32003):
What is a Continuous Synopsis Record? Selected answer:
A plan for continuous maintenance of security equipment Correct answer:
A record of the vessels history
Question asked (32249):
According to MARPOL there are requirements regarding minimum amidships draught
for crude oil tankers in ballast condition. What is the formula for calculating minimum
draught amidships?
Selected answer:
2.0 + 0.02L Correct answer:
2.0 + 0.02L
Question asked (32253):
What is the purpose of "expansion couplings" on the longitudinal pipelines of oil
tankers? Selected answer:
To allow the pipeline to expand when loading a hot cargo through the pipeline. Correct
answer:
To allow the pipelines to follow the ships flexing movement when pitching.
Question asked (32255):
A system for the continuous monitoring of the concentration of hydrocarbon gas shall be
fitted in cargo pump-rooms of oil tankers. A continuous alarm shall be automatically
activated when the hydrocarbon gas concentration reaches a pre-set level. What are
the criteria for pre-setting the alarm level?
Selected answer:
No higher than 5% of LEL. Correct answer:
No higher than 10% of LEL.
Question asked (32420):
The engines have failed and will require at least 24 hours to be available as a reliable
means of propulsion. Your vessel is about 20 miles off the coast in a tidal area. What
are the initial steps that should be taken to ensure the safety of the ship?
Selected answer:
Display NUC lights and inform the nearest Coast Guard of you predicament. Correct
answer:
Display NUC lights and investigate the tidal flow over the next 24 hours and the
Show only wrong answers with negative score: No Question asked (370):
What will have a major effect on the performance of a tug when used to assist in the
manoeuvring of a large vessel?
Selected answer:
The experience of the tug crew.
Correct answer:
The position of the tug relative to the ship's pivot point
Question asked (1026):
Before starting a transfer of oil, the person in charge on the vessel and the person in
charge on the facility must hold a pre transfer conference. Who must decide to start the
transfer?
Selected answer:
The person in charge who is handling the pumping
Correct answer:
Both persons in charge
Question asked (1181):
Who is responsible for keeping the required official publications onboard?
Selected answer:
The owner.
Correct answer:
The master.
Question asked (1657):
ISGOTT draws attention to the risk of electrostatic potential in a mist produced by using
oil and water mixture in Crude Oil Washing operations. How does the Guide
recommend this is avoided?
Selected answer:
Crude Oil Washing, where the oil source is stored in a slop tank or other tank that has
previously contained slops, should be avoided.
Correct answer:
Before washing begins, any tank that is to be used as a source of oil for Crude Oil
Washing should be partly discharged to remove any water that has settled out during
the voyage. The discharge of a layer of at least 1 metreis necessary for this purpose.
Question asked (1721):
The emergency fire pump is in accordance with good seamanship and precautionary
routines run and tested weekly. Routine checks and maintenance are normally carried
out by dedicated personnel. To ensure safe and appropriate operation of the pump,
would you consider it beneficial that the same dedicated personnel operate the pump in
emergencies?
Selected answer:
Only senior engineers should operate the emergency pump.
Correct answer:
In case of accidents, it is important that a wide range of personnel must be permitted
and trained to operate the pump.
Question asked (1910):
Non distress calls on 2182 kHz and VHF channel 16 should not exceed:
Selected answer:
Two minutes.
Correct answer:
One minute.
Question asked (1936):
What medium is used to calibrate the ODME?
Selected answer:
Sea water.
Correct answer:
Fresh water.
Question asked (1996):
If all indications are that a cargo has been received without damages, irregularities or
short shipment and the phrase "apparent good order and condition" is entered on the
Bill of Lading, what type of Bill is this said to be?
Selected answer:
An endorsed Bill of Lading.
Correct answer:
A clean Bill of Lading.
Question asked (2455):
How can an ARPA assist the ship to steer a suitable course to make good the entrance
With respect to the ISM, what training in additional to lifeboat and fire drills must be
Which of the following is a definition of the "Proper Shipping Name", as found in the
During the 5-yearly overhaul and operational test of a lifeboat on-load release gear, to
Show only wrong answers with negative score: No Question asked (681):
What can be used to reduce the effect of the state of sea-waves?
Selected answer:
Foam
Correct answer:
Vegetable / Fish Oil
Question asked (1930):
ISGOTT requires that hoses used for tank-cleaning are tested for electrical continuity in
a dry condition prior to use. What is the reading that they must display?
Selected answer:
At least 8 ohms per metre length.
Correct answer:
Not greater than 6 ohms per metre length.
Question asked (1996):
If all indications are that a cargo has been received without damages, irregularities or
short shipment and the phrase "apparent good order and condition" is entered on the
Bill of Lading, what type of Bill is this said to be?
Selected answer:
A Bill of Lading completed for shipment.
Correct answer:
A clean Bill of Lading.
Question asked (3364):
Ship's personnel who assume overall charge of Crude Oil Washing operations must be
trained to the satisfaction of the Flag State administration. Which of the following is a
summary of the conditions that must be met before such persons can assume these
responsibilities?
Selected answer:
They must have at least 12 months equivalent experience on a tanker of any type,
provided at least three washing operations have been witnessed in a supernumary
capacity and be able to demonstrate full knowledge of Annex I of MARPOL 73/78.
Correct answer:
They must have at least one years appropriate experience on oil tankers, have
participated in at least two COW programmes and be fully knowledgeable of the
contents of the Operations and Equipment Manual.
Question asked (5370):
The type-indication of the radio set is mentioned in:
Selected answer:
The survey of equipment
Correct answer:
The safety certificate
Question asked (5501):
During a telex-connection with a subscriber it is:
Selected answer:
Obligatory to send the indication 'msg' at the beginning of the message
Correct answer:
Recommended at the beginning and at the end of the message-transport to exchanges
'answer back' s'
Question asked (5559):
On board a DSC-call is to be made in case of an OBS. Choose the category:
Selected answer:
Safety
Correct answer:
Routine
Question asked (5723):
The "clarifier" has only effect during:
Selected answer:
Transmitting in mode H3E
Correct answer:
Receiving in mode J3E
Question asked (5724):
During the 5-yearly overhaul and operational test of a lifeboat on-load release gear, to
Which of the below structures of bulk carriers are considered critical? Selected
answer:
Longitudinal deck plating outside hatches
Correct answer:
Upper and lower connection of main side frames
Question asked (33937):
What type of dynamic forces may cause indent in plating on forecastle deck and main
Show only wrong answers with negative score: No Question asked (77):
Watch keeping engineers shall have a minimum of knowledge of the vessel's engine
room and operation of its functions prior to being accepted as Engineer on Duty, and
shall acknowledge his familiarization with the equipment by signing a check list listing all
units he shall be able to operate. Minimum knowledge is:
Selected answer:
Start, operate and stop main and auxiliary machinery units, including switching between
automatic, remote and/or manual control functions, and operate the various units in
various modes.
Correct answer:
He shall have all the knowledge as listed in the other alternatives
Question asked (379):
The vessel has weighed the anchor and is heading for sea. The anchor is to be stowed
What possible reason could there be for the identification mark associated with a Racon
In oil cargo calculations, what is ASTM table 53A/B used for? Selected answer:
On entering with a standard density at 15 degrees Celsius, a correction factor is found
that will convert the volume in U.S. barrels (bbls) to cubic metres.
Correct answer:
On entering with a given density at the observed temperature, the corresponding
density at the standard 15 degrees Centigrade is found.
Question asked (2994):
If an oil tanker is built with a "free flow system", what does this mean? Selected
answer:
That the cargo is free flowing in all tanks at all times.
Correct answer:
A vessel without ordinary bottom lines where the cargo flows from tank to tank through
bulkhead valves.
Question asked (3234):
Are there any restrictions about how much sludge we can pump overboard on the sea
The IMO Standard Marine Communication Phrases are recommended to be used when
When on HF band a DSC distress alert is received, you have to listen to: Selected
answer:
The radio-telex distress frequency in the band in which the DSC distress alert was
received
Correct answer:
The radio telephony distress frequency in the band in which the DSC distress alert was
received
Question asked (5788):
A SART must, when the vessel sinks:
Selected answer:
Automatically released and then automatically activated
Correct answer:
Be taken by the crew to the rescue-boat and turned on manually
Question asked (5870):
What is important to check when transferring a position from the GPS output to a paper
Which of the following is the correct minimum carriage requirement for a ship of more
than 300 gross tons and operating in area A2: Selected answer:
1 VHF RT + DSC+ DSC watch receiver - 1 or 2 SART - 1 NAVTEX or 1 EGC receiver -
1 INMARSAT A,B or C - 1 EPIRB - 1 MF RT + DSC+ DSC watch receiver
Correct answer:
1 VHF RT + DSC+ DSC watch receiver - 1 or 2 SART - 1 NAVTEX or 1 EGC receiver -
2 or 3 VHF portable - 1 EPIRB - 1 MF RT + DSC+ DSC watch receiver
Question asked (10031):
A flame detector is activated by:
Selected answer:
Smoke, gas, sparks and high temperature
Correct answer:
The infrared radiation and ultraviolet radiation given off by flames
Question asked (10090):
The discharge arrangements for halogenated hydrocarbon total flooding systems shall
be so designed that the minimum quantity of medium can be discharged in (based on
the discharge of the liquid phase):
Selected answer:
45 seconds or less
Correct answer:
20 seconds or less
Question asked (20371):
When mustered to an abandon ship drill, what is the first thing you do when entering the
Why are the tank lids and other access points usually round on the deck of an oil
Show only wrong answers with negative score: No Question asked (772):
Your ship is approaching the berth as illustrated and has a right handed propeller and
no thrusters. What could be a method to retain full control of the vessel as it comes
alongside?
Selected answer:
Reduce speed by going astern on the engines.
Correct answer:
Let go starboard anchor to about 1 shackle on deck
Question asked (809):
The ship is approaching shallow water where the Under Keel Clearance will reduce to
about 0.25 of the ship's draught. Which of the following answers most accurately
summarizes the aspects to be considered when deciding a suitable speed?
Selected answer:
Don't know
Correct answer:
All of the suggested answers
Question asked (1017):
According to 33 CFR 156, oil tankers trading in US waters are required to test and
document the testing of cargo transfer hoses and transfer pipe system. What is the
minimum requirement when testing these components?
Selected answer:
That no leakage occurs at the nominal anticipated working pressure.
Correct answer:
That no leakage occurs under static liquid pressure of at least 1.5 times the maximum
allowable working pressure.
Question asked (1375):
Which PPM is allowed for discharging of "Bilge Water" overboard?
Selected answer:
0 PPM
Correct answer:
15 PPM
Question asked (1657):
Presence of water in the fluid for COW may result in excessive electrostatic generation.
To avoid this, any tank supplying crude to the COW system must first be discharged by
at least?
Selected answer:
2 metres
Correct answer:
1 metre
Question asked (1996):
If all indications are that a cargo has been received without damages, irregularities or
short shipment and the phrase "apparent good order and condition" is entered on the
Bill of Lading, what type of Bill is this said to be?
Selected answer:
A Due Title Bill of Lading.
Correct answer:
A clean Bill of Lading.
Question asked (2027):
An OBO or O/O carrier, due to the movement of liquid in a cargo hold during rough
weather, the possibility of liquid entering the inert gas piping is great. To avoid this U-
bends are sometimes fitted on the line emerging from the hatch coaming. These bends
generally have a drain cock at the bottom. These cocks should be:
Selected answer:
Opened and checked every day irrespective of the weather?
Correct answer:
Opened after rough weather or before loading/discharging or transferring cargo to check
for liquid accumulation and contents drained into a drip pan.
Question asked (2067):
At what calendar interval must lifting appliances on board a vessel be suitably tested by
a competent person?
Selected answer:
2 years.
Correct answer:
5 years.
Question asked (2251):
4/12.1)
Selected answer:
Drawings and caculations documenting the stability of the ship, both in intact and all
possible damage condition.
Correct answer:
A calculation example showing the use of "KG" limitation curves.
Question asked (2312):
MARPOL 73/78 - Annex V. Disposal of garbage outside "Special Areas". After
unpacking spares, you are left with a limited amount of packing materials. What will be
the nearest distance to land for disposal into the sea of this materials?
Selected answer:
12 miles
Correct answer:
25 miles
Question asked (2753):
Shipboard Emergency Drills must be carried out at least (OPA-90)
Selected answer:
Once every six months
Correct answer:
Once a month
Question asked (2797):
What does MARPOL 73/78 require in respect of the contents of lines and pumps on an
When initially setting up the GPS to provide positions for use with a paper chart, what
The operating mode of a pyrotechnic signal depends essentially on: Selected answer:
The fact that the user is on board a liferaft, a lifeboat or ship
Correct answer:
Instructions or diagrams printed on its casing by the manufacturer
Question asked (31303):
With respect to the ISM, what training in additional to lifeboat and fire drills must be
carried out?
Selected answer:
The boat drill and fire drill should be adequate to meet your needs
Correct answer:
Familiarization, and other drills identified as necessary by the ship
Question asked (31406):
The training manual shall contain instructions and information in easily understood
terms and illustrated wherever possible. Which of the following objects have to be
explained in detail in the manual according to present regulations?
Selected answer:
Donning of fire protection clothing
Correct answer:
Donning of lifejackets and immersion suits
Question asked (31486):
HEL-H is the abbreviation of a heavy helicopter radius of action for rescue purposes.
What do you think the radius and evacuating capacity of the helicopter is?
Selected answer:
100 nm and capacity for evacuating more than 10 persons.
Correct answer:
200 nm and capacity for evacuating more then 15 persons.
Question asked (31605):
Your vessel is involved in a collision with another vessel. What should you as Master tell
By which method is the Vapour Pressure of Crude Oil determined? Selected answer:
The True Vapour Pressure value is always used.
Correct answer:
The Reid Closed Test method.
Question asked (34502):
Fluid-driven eductors (as commonly found on crude oil tankers), operate on a principle
known as Bernoulli's principle. What does that state?
Selected answer:
The discharge rate is inversely proportional to the pressure applied in the drive inlet.
Correct answer:
The speed of a moving fluid increases as the pressure in the fluid decreases.
Name: User ID:
Installation: SCF Unicom
ANDREY IGOREVICH BELYAKOV 2318927
Date of birth: 08.02.1985 Nationality: Russian Federation Academy:
CES 5.0.3838 10.08.2010 STCW
CES version: Test date: Test type: Level:
Operational
Department/Function area: Deck Vessel type/Propulsion: Oil Tanker
Batch:
Show only wrong answers with negative score: No Question asked (412):
Rule 12 of the International Collision Regulations prescribes the action to be taken by a
sailing vessel when meeting another sailing vessel. This depends on the direction of the
wind relative to each vessel. In the situation shown here, which sailing vessel (A or B)
must keep out of the way of the other?
Selected answer:
Sailing vessel B must keep out of the way of sailing vessel A.
Correct answer:
Sailing vessel A must keep out of the way of sailing vessel B.
Question asked (441):
When navigating along a coastline what should be considered the most accurate
method of navigating?
Selected answer:
Use of radar ranges and bearings
Correct answer:
Use of Differential GPS
Question asked (442):
When taking a position using the Radio Directional Finder, a correction must be applied
to the bearings. What is the purpose of this correction (Half Convergency?)
Selected answer:
To correct for the refraction of the atmosphere
Correct answer:
To convert between great circle and rhumb line bearings
Question asked (561):
How can a new officer, just boarding a ship, ensure that he knows the location and
operation of all navigational and safety equipment and take account of the operating
limitations of such equipment?
Selected answer:
By using the equipment on regular watchkeeping duties
Correct answer:
By asking other officers and practicing with the use of the equipment
Question asked (681):
What can be used to reduce the effect of the state of sea-waves?
Selected answer:
Fuel Oil
Correct answer:
Vegetable / Fish Oil
Question asked (713):
What is the purpose of a sea anchor?
Selected answer:
To adjust the drifting speed of the lifeboat
Correct answer:
To keep the lifeboat steady against the sea/wind
Question asked (723):
The Urgency Message from a ship is used to notify other traffic of a situation where the
ship is not in imminent danger, but where the development of the situation is uncertain
and may need assistance in the near future. What is the telephony urgency message
like?
Selected answer:
MAYDAY
Correct answer:
PAN-PAN
Question asked (794):
A ship normally turns (swings) around a point which is not the centre of gravity. What is
this point normally called?
Selected answer:
Centre of Turn
Correct answer:
Pivot Point
Question asked (808):
The ship is required to be stopped in the water as quickly as possible, but without major
changes to the ship's heading. What is the most effective method to achieve this?
Selected answer:
Make a zig zag manoeuvre while reducing the engine power.
Correct answer:
The use of the rudder hard over both sides combined with reducing engine power, a
method known as "high frequency rudder cycling"
Question asked (1012):
SOLAS requires that an Inert Gas system on an oil tanker is capable of delivering inert
gas with a maximum level of oxygen at any required rate of flow. What is that level?
Selected answer:
Not less than 8% by volume.
Correct answer:
Not more than 5% by volume.
Question asked (1015):
You are the officer in charge of discharging an oil tanker of 15000 DWT in Corpus
Christi, USA. Where shall the Oil Transfer Procedure be located?
Selected answer:
Available in the Chief Officers office, or Captains office
Correct answer:
Posted or available where it can be easily seen and used by crew-members engaged in
the discharge operation.
Question asked (1088):
What is the purpose of the decanting line between two slop tanks on an oil tanker that is
using water for the washing of the cargo tanks? Selected answer:
To avoid a build-up of static electricity during water washing, caused by air being drawn
in as the primary slop tank empties.
Correct answer:
To enable most of the recovered oil to be retained in the primary slop tank, while the
cleaner part of the water will flow into the secondary slop tank, where it can be re-used
as wash-water.
Question asked (1498):
What will you serve seafarers who has been exposed to cold?
Selected answer:
Brandy, whiskey or other strong drinks.
Correct answer:
Warm nutritious drinks.
Question asked (1637):
"A" Class divisions in ships are constructed so that they are capable of preventing the
passage of smoke and flame to the end of a standard fire test held for how many
minutes?
Selected answer:
15 minutes.
Correct answer:
60 minutes
Question asked (1931):
Measurement of oil cargoes is often achieved with a "UTI" device. What do the letters
"UTI" stand for?
Selected answer:
Ullage Topping Instrument.
Correct answer:
Ullage Temperature Interface.
Question asked (2154):
Which type of water can be discharged into the sea without using the ODME?
Selected answer:
Water from slop tanks.
Correct answer:
Ballast from segregated ballast tanks (SBT)
Question asked (2446):
What is the correct setting of the "Anti sea clutter" control on the radar?
Selected answer:
All of the suggested answers
Correct answer:
A few sea returns remaining on the screen.
Question asked (2929):
What can a quick change of liquid flow in a pipe line lead to? Selected answer:
The terminal gives the order of what to do.
Correct answer:
Pressure surge and liquid pressure.
Question asked (2936):
Before commencing loading an oil cargo, the cargo tanks are surveyed. How do we
refer to any small amount of liquid, sludge and sediment found in the cargo tanks and
assessed for the purposes of including in the calculation of cargo quantity loaded?
Selected answer:
TSV (Total Surveyed Volume).
Correct answer:
OBQ (On Board Quantity).
Question asked (2940):
To discharge the last amount of cargo ashore, the stripping pump through the small
diameter line is used. Where does this small diameter line come from in the pump room
and where is the line ending at the manifold?
Selected answer:
From the stripping pump's delivery side to a particular shore line.
Correct answer:
From the stripping pump's delivery side directly to the manifold's presentation flange.
Question asked (3016):
The successive stages of all cargo and ballast handling operations on an oil tanker must
be recorded on board. What is the name of the book where these details are listed?
Selected answer:
The Deck Operations Logbook.
Correct answer:
The Oil Record Book.
Question asked (3191):
The Master arrives on the bridge obviously under the influence of alcohol and states he
is taking over the "con" of the ship. What actions should the Officer of the Watch (OOW)
take in this situation?
Selected answer:
Tell the Master you do not think this is a good idea and retain control of the watch.
Correct answer:
Attempt to diplomatically avoid taking any actions that would put the ship or crew into
danger and call the Chief Officer for assistance.
Question asked (3204):
answer:
Watertight doors can be closed locally and also a remote control station within the
accommodation
Correct answer:
Watertight doors can be closed adjacent to the door and remotely from bridge and also
one emergency remote control station
Question asked (3702):
An alarm signal consisting of seven short blast followed by one prolonged blast is
sounded by the ship's whistle and alarm bells. What are you to do?
Selected answer:
Go to (or remain in) your cabin and await further orders
Correct answer:
Go to your lifeboat station
Question asked (3703):
What is the meaning of this symbol ?
Selected answer:
Secure hatches
Correct answer:
Fasten seat belts
Question asked (5406):
A vessel is equipped for all sea areas. In the middle of the Indian Ocean the EGC-
receiver appears out of order. Is it still possible to receive MSI-messages?
Selected answer:
Yes with VHF DSC
Correct answer:
Yes, with the MF/HF-radio telex
Question asked (5559):
On board a DSC-call is to be made in case of an OBS. Choose the category:
Selected answer:
Safety
Correct answer:
Routine
Question asked (5756):
What mode must be used on the MF/HF transmission when making a radiotelephone
call:
Selected answer:
H3E
Correct answer:
J3E
Question asked (5794):
The following information must be given on the SART:
Selected answer:
The date of replacement of the hydrostatic release unit
Correct answer:
Date of replacement of the battries
Question asked (5862):
Can an ECDIS be used for voyage planning?
Selected answer:
The ECDIS can not be used for passage planning
Correct answer:
Normally the ECDIS could be used, but in conjunction with paper charts
Question asked (5873):
What is the shortest distance between two points on the surface of the earth?
Selected answer:
Composite great circle
Correct answer:
Great Circle
Question asked (5888):
How many total frequencies are available for DSC distress alerting?
Selected answer:
One (1).
Correct answer:
Seven (7).
Question asked (5936):
" On area A3 the function "" Transmission and reception of signals for locating "" is
mainly based on:"
Selected answer:
the use of SARSAT COSPAS Epirbs
Correct answer:
the use of SART transponders
Question asked (6044):
" On area A4 the function "" Transmission of ship to shore distress alerts"" is mainly
based on:"
Selected answer:
The use of VHF DSC and VHF Epirbs
Correct answer:
The use of HF DSC and COSPAS SARSAT Epirbs
Question asked (6084):
What is the required number of hours that a SART's battery must be able to operate the
unit in the standby mode?
Selected answer:
Forty-eight (48) hours
Correct answer:
Four (4) days
Question asked (6114):
Operator connected R/T calls are charged
Selected answer:
On the basis of a one minute minimum charge with one minute incremental steps
Correct answer:
On the basis of a three minute minimum charge with one minute incremental steps
Question asked (6115):
answer:
On the basis of a six second minimum charge with one second incremental steps
Correct answer:
On the bases of a six second minimum charge with six second incremental steps
Question asked (6116):
Messages sent via INMARSAT C are charged:
Selected answer:
On the basis of a six second minimum charge with six second incremental steps
Correct answer:
On the number of kilobits of information transmitted per block of 256 bits
Question asked (10089):
The halogenated hydrocarbons (halon), are hydrocarbons in which the molecules have
one (or more) atom(s) of hydrogen replaced by another atom (or atoms) of
Selected answer:
Nitrogen and/or fluorine
Correct answer:
Fluorine and/or bromine
Question asked (20353):
Buoyant smoke signals shall be so designed as to burn or emit smoke:
Selected answer:
Only when not in the water
Correct answer:
Continuously after having been immersed for a period of 10 seconds under 100 mm of
water when underwater
Question asked (31307):
What is the main theme of modern safety practice?
Selected answer:
Health & Safety at Work Act
Correct answer:
Making use of Risk Assessment as a means to improving safety
Question asked (31439):
What is an oxygen analyzer used for?
Selected answer:
Check if there is explosive atmosphere in the oxygen.
Correct answer:
Measure oxygen contents in the atmosphere.
Question asked (32267):
What new stability problems would be caused by having deep double bottom tanks on
What is the purpose of having corrugations in the bulkheads in the cargo tanks of an oil
What could be the reason for the magnetic compass to swing through large angles
What are the ideal conditions required to satisfactorily conduct an Inclining Experiment?
Selected answer:
All derricks lowered and no moving items on deck and in store rooms
Correct answer:
All of the suggested answers
Question asked (33612):
What are we seeing here?
Selected answer:
A sailing vessel, seen from astern, where the edges of her sidelights are both visible.
Correct answer:
A sailing vessel less than 20 metres in length, displaying the optional combined lantern
in lieu of standard sailing lights, seen head-on.
Question asked (33686):
What is this?
Selected answer:
The United Nations stamp used for endorsing international shipping certificates.
Correct answer:
The United Nations Packaging symbol used for Dangerous Goods.
Question asked (33688):
What is the name given to the special list of cargo loaded on board a ship that needs to
be prepared for reporting and other administrative purposes?
Selected answer:
Stowage Plan.
Correct answer:
Manifest.
Question asked (33736):
What does the word "pyrotechnics" mean?
Selected answer:
Pyrotechnics is a group word to cover all the required activities in the event of a man
overboard
Correct answer:
Pyrotechnics are the items which are capable of self-contained chemical reactions for
the production heat, light, smoke and/or sound
Question asked (33741):
What would be the correct method to report to other ships in the vicinity that a person
has fallen overboard from your vessel?
Selected answer:
"Man overboard"
Correct answer:
"Vessel "name" has lost a person overboard in "position.
Question asked (33989):
In describing an oil cargo, what is its "pour point"?
Selected answer:
The temperature necessary for a cargo to load from shore by gravity alone
Correct answer:
The lowest temperature at which it will remain fluid
Name: User ID:
Installation: SCF Unicom
IGOR VALERYEVICH KARPOV 2311749
Date of birth: 24.03.1974 Nationality: Russian Federation Academy:
CES version:
Test date: Test type: Level:
CES 5.0.3838 10.08.2010 STCW
Management
Department/Function area: Deck Vessel type/Propulsion: Oil Tanker
Batch:
Show only wrong answers with negative score: No Question asked (369):
A large tanker is proceeding slowly up a narrow channel, using its own engines and
assisted by the use of one tug. Where should the tug be connected to assist the ship in
maintaining its course in the centre of the channel?
Selected answer:
Standing-by - Ready for use anywhere, as required.
Correct answer:
Made fast on a line through the centre lead astern.
Question asked (413):
You are on a power-driven vessel underway in open water. This vessel is sighted on the
port bow on a steady bearing. What kind of vessel is it and what will your action be?
Selected answer:
This is a sailing vessel not making way through the water. There is no risk of collision
and I will maintain my course and speed.
Correct answer:
This is a sailing vessel underway, seen head-on. It is my responsibility to keep clear
under rule 18 and I will take appropriate avoiding action.
Question asked (706):
What is SITREP an abbreviation for?
Selected answer:
Ship Transit Emergency Radio.
Correct answer:
Situation Report.
Question asked (791):
A partially loaded VLCC is drifting with the main engine stopped and undergoing
repairs. The ship is observed to be drifting, due to wind and current towards a danger
area, although there is no immediate concern. What actions would be most suitable in
these circumstances?
Selected answer:
Continue to plot the position and wait for the engines to be repaired. Ask the Engine
Room for an estimate of the time required.
Correct answer:
Use the Bow Thrusters to change the ships head and monitor any changes in the drift
Question asked (822):
When a conventional rudder is put hard over it creates a lift force and a drag force.
When the ship has started to turn, how much lift force do you think remains if the
rudder-angle is decreased to 20 degrees from hard over position (35 degrees)?
Selected answer: About 30 %
Correct answer:
About 80 %
Question asked (932):
Who will have the authority to take charge and make appropriate decisions in the event
of a vessel emergency when transiting the Panama Canal?
Selected answer:
The Master and Pilot will agree the best course of action to be taken to resolve the
emergency situation.
Correct answer:
The Panama Canal Authority
Question asked (1071):
Which of the following would be considered pollution, when discharged overboard,
under the US water pollution laws?
Selected answer: Garbage
Correct answer:
All of the mentioned
Question asked (1116):
How frequent should reports from protection and environmental work be send to shore
based management?
Selected answer:
Not mandatory to send reports.
Correct answer:
Annually.
Question asked (1917):
You are proceeding along a narrow channel and approaching a bend, on the inside
shore of which is a large hill, which obsures your view further up channel. What sound
signal will you make to indicate your presence to any vessel that is behind the
obstructing hill?
Selected answer:
Don't know
Correct answer:
One prolonged blast.
Question asked (1930):
ISGOTT requires that hoses used for tank-cleaning are tested for electrical continuity in
a dry condition prior to use. What is the reading that they must display?
Selected answer:
Not more than 10 ohms per metre length.
Correct answer:
Not greater than 6 ohms per metre length.
Question asked (1930):
Testing of tank cleaning hoses. All hoses supplied for tank washing machines should be
tested for electrical continuity in a dry condition prior to use. What are the maximum
ohms per metre length?
Selected answer:
10 ohms per metre length.
Correct answer:
6 ohms per metre length.
Question asked (2000):
What is the result of a "high metacentric height"?
Selected answer:
The vessel's tweendeck heights is too high?
Correct answer:
The vessel will roll violently?
Question asked (2147):
According to the OCIMF Ship to Ship Transfer Guide (Petroleum), which of the following
is the required state of readiness on oil tankers engaged in a cargo transfer?
Selected answer:
The main engine must be ready for immediate use only on the receiving vessel.
Correct answer:
The main engines of both vessels should be ready for immediate use.
Question asked (2154):
Which water can be discharged into the sea without using the ODME?
Selected answer:
Dirty ballast from cargo tanks.
Correct answer:
Ballast from segregated ballast tanks (SBT)
Question asked (2252):
Which of the following requirements to ships stability for normal operation corresponds
At present the MF/HF transmitter often has an automatic aerial turning unit. Should this
Which one of the listed requirements regarding service and maintenance of life-saving
The ship is involved in a collision, what is the immediate action by the Officer of the
The best way to prevent stowaways from boarding your ship is to: Selected answer:
Search the ship when you arrive at port and again just after leaving.
Correct answer:
"Seal spaces that are not in use while in port, and perform a search of the ship before
leaving."
Question asked (32217):
Hydrocarbons belongs to a chemical group named:?
Selected answer:
Carbohydrates.
Correct answer:
Organic substances.
Question asked (32220):
In discussing the effeciency of a cargo pump, such as may be used on an oil tanker,
what term is usually used to describe the absolute pressure of a liquid at the inlet to a
pump minus the vapour pressure of the liquid?
Selected answer:
Effective Suction Head Pressure.
Correct answer:
Net Positive Suction Head Available.
Question asked (32250):
Every oil tanker of 5,000 tonnes deadweight and above delivered on or after 1 February
2002 shall comply with intact stability. What is the minimum GM (metacentric height)
when the vessel is in port?
Selected answer:
Not less than 0.25 m
Correct answer:
Not less than 0.15 m
Question asked (32252):
To maintain good relationship among the crew on board a vessel, one must be:
Selected answer:
Polite and diplomatic while talking to crew members
Correct answer:
Understanding, Co-operative, and have respect from both sides
Question asked (34333):
According to the ISGOTT definition, what is "volatility"?
Selected answer:
The tendency of a crude oil or petroleum product to ignite.
Correct answer:
The tendency of a crude oil or petroleum product to produce gas.
Question asked (34494):
To allow efficient pumping of aromatic Crude Oil cargoes, they are usually heated to
reduce their viscosity. What is the ideal maximum viscosity that is normally achieved for
this purpose?
Selected answer:
1,250 cSt (1,250 mm2/s)
Correct answer:
250 cSt (250 mm2/s)
Installation: SCF Unicom
Name: SERGEY SERGEEVICH KALINICHENKO
User ID: 2313333
Date of birth: 19.07.1980
Nationality:
Academy:
Batch:
Show only wrong answers with negative score: No
CES 5.0.3838 09.08.2010 STCW Operational
CES version: Test date: Test type: Level:
Department/Function area: Deck Vessel type/Propulsion: Oil Tanker
Question asked (132):
According to basic principles regarding fire protection the ship is to be divided in zones
by structural and thermal boundaries. (SOLAS 2/2.2.1)
Selected answer:
In main zones according to utilization (Accommodation, Machinery, Cargo)
Correct answer:
In main vertical zones
Question asked (379):
The vessel has weighed the anchor and is heading for sea. The anchor is to be stowed
What is the purpose of having corrugations in the bulkheads in the cargo tanks of an oil
You are approaching the port entrance. What do these lights mean? Selected answer:
Vessels may proceed - two-way traffic.
Correct answer:
A vessel may proceed only when she has received specific orders to do so.
Question asked (33838):
The superstructure and deck houses of passenger ships carrying more than 36
passengers shall be divided into main vertical zones by
Selected answer:
Class "B" division
Correct answer:
Class "A" division
Question asked (33990):
In describing oil cargoes, what is "sour crude"?
Selected answer:
A crude oil cargo which has left substantial residues in the bottom of the tank after
discharge
Correct answer:
A term used to describe crude oil or products containing appreciable amounts of
hydrogen sulphide and / or mercaptans
Question asked (34506):
The abbreviation "NPSH" is often seen in connection with the efficiency of cargo pumps
on oil tankers. What does this abbreviation stand for?
Selected answer:
Nominal Pressure Suction Head.
Correct answer:
Net Pressure Suction Head.
CES version: Test date: Test type: Level:
CES 5.0.3838
09.08.2010
STCW
Name: User ID:
Management
Department/Function area: Deck Vessel type/Propulsion: Oil Tanker
Installation: SCF Unicom
YURIY SOPIN 7815639
Date of birth: 22.04.1965 Nationality: Russian Federation Academy:
Batch:
Show only wrong answers with negative score: No Question asked (1930):
Testing of tank cleaning hoses. All hoses supplied for tank washing machines should be
tested for electrical continuity in a dry condition prior to use. What are the maximum
ohms per metre length?
Selected answer:
8 ohms per metre length.
Correct answer:
6 ohms per metre length.
Question asked (2999):
The Reid Vapour Pressure (RVP) test is a simple and generally used method for
answer:
The ITU List of Callsigns and Numerical Identities of Stations used by the Maritime
Mobile and Maritime Mobile-Satellite Services
Correct answer:
The ITU List of Ship Stations
Question asked (10325):
*When should a crew member joining a ship for the first time be given some training and
instructions in the use of the ship's fire-fighting appliances ?
Selected answer:
As soon as possible but not later than 24 hours after he joins the ship
Correct answer:
As soon as possible but not later than 2 weeks after he joins the ship
Question asked (31373):
Which one of the listed requirements regarding service and maintenance of life-saving
appliances correspond to present regulations?
Selected answer:
At least one member of the crew shall hold a repairman certificate for life-saving
equipment
Correct answer:
Instructions for onboard maintenance of life-saving appliances in accordance with the
regulations shall be provided
Question asked (31589):
The Training Manual shall contain instructions and information on the life-saving
appliances and the best method of survival. The training manual shall contain detailed
explanations of crew duties in relation to emergency situations. Which of the following
tasks or duties shall be included in the manual according to present regulations?
Selected answer:
The use of escape routes and other escape methodes.
Correct answer:
The use of the ship's line throwing apparatus.
Question asked (32114):
Eavesdropping and phone taps are examples of which threat to information security?
Selected answer:
Terrorism
Correct answer:
Espionage
Question asked (32253):
Russian Federation
No
Show only wrong answers with negative score:
CES version: CES 5.0.3847
Test date: 26.08.2010
Test type: STCW
Level: Management
Department/Function area: Deck Vessel type/Propulsion: Oil Tanker
Question asked (212):
Which organization or administration is responsible for surveys and inspections of ships,
and the issue of Safety Certificates? Selected answer:
Ships Classification Associations (Lloyd's, American Bureau of Shipping, The
Norwegian Veritas, Germanische Lloyd's, etc.) Correct answer:
Government Authorities of the Flag State
Question asked (2887):
Subject to allowance by the Port State Authority a tanker with defect oil discharge
monitoring and control system (ODME) may undertake? Selected answer:
The vessel will be detained until ODME is rectified. Correct answer:
One ballast voyage before proceeding to a repair port.
Question asked (2887):
Subject to allowance by the Port State Authority, a tanker with a defective oil discharge
monitoring and control system (ODME) may continue to trade for a limited period before
a repair is effected. What period is allowed and what conditions apply?
Selected answer:
The vessel may discharge her cargo but will then be detained in port until the ODME is
made fully operational and approval from the Port State Authority obtained.
Correct answer:
One ballast voyage before proceeding to a repair port.
Question asked (3005):
Some centrifugal cargo pumps on oil tankers are designed with an automatic stripping
system, which allows the cargo tank to fully discharge its contents. By what principle
does such a stripping system operate?
Selected answer:
By the optimum size and positioning of the suction inlet that feeds the automatic
stripping system, which ensures that the cargo oil tank is discharged to the maximum
possible extent.
Correct answer:
On the basis that, if cargo vapour can be stopped from entering the cargo pump suction
inlet, the flow will continue without cavitation.
Question asked (3242):
What does STCW deal with? Selected answer:
STCW deals with training centre and schools and standards for watch keepers Correct
answer:
STCW deals with minimum recommendation of education for seafarers and minimum
standards for training centre and schools
Question asked (3714):
A 6-men inflatable liferaft shall be carried as far forward as is reasonable and
practicable. Where is the best stowing position? Selected answer:
Aft of the forecastle secured with the use of hydrostatic release device. Correct
answer: Under the forecastle.
Question asked (5493):
The input of an area code prefix in (radio)telex-traffic:
Selected answer:
Has to be put in without the zero
Correct answer:
Differs for each country
Question asked (5500):
With what system is a NAVTEX-message transmitted? Selected answer:
Send a PDN, if the message has arrived in the mailbox Question asked (5583):
You receive via the 8 MHz a DSC distress alert. The received DSC message is however
distorted. The MMSI as well as the position are illegible. After listening at the 8 MHz
telephone distress frequency, nothing is heard. This is because:
Selected answer:
First an acknowledgement of a coastguard station must be received via the 8MHz
Correct answer:
Telephone signals in the same frequency band are generally weaker than DSC signals
At sea, outside territorial waters, and in port or harbour Question asked (5880):
Which of the following answers would best define the term "risk"? Selected answer:
Risk is the possibility that a dangerous situation is likely to occur Correct answer:
Risk is a situation involving exposure to danger and includes both identification of the
occurrence and the likelihood that it will happen. Question asked (10381):
*Which of the following items must be included in each fire drill? Selected answer:
Starting a fire pump using at least two required jets of water to show that the system is
in proper working order
Correct answer:
All the items mentioned
Question asked (20322):
Give the meaning of the following symbol
Selected answer:
Survival craft portable radio
Correct answer:
EPIRB
Question asked (20351):
A hand flare must have a burning period of at least Selected answer:
Correct answer:
Question asked (31027):
What is the period of validity of the Safety Management Certificate Selected answer:
1 Year
Correct answer:
5 years
Question asked (31464):
A ship in distress should transmit the appropriate alarm signal followed by the distress
call and message on one or all of the international distress frequencies. Which of
frequencies is in accordance with the present recommendations?
Selected answer:
550 kHz, 2182 kHz and 121.5 MHz Correct answer:
500 kHz, 2182 kHz and 156.8 MHz
Question asked (32111):
In which of these circumstances can your ship request a DoS? Selected answer:
Your ship is operating at a lower security level than the ship or port it is interfacing with.
Correct answer:
Your ship is conducting activities with a port or ship that is not required to implement an
approved security plan.
Question asked (32145):
Which of these measures would you implement to prevent drugs from being smuggled
onboard your ship while it's berthed? Selected answer:
"Search some of the packages, spares and stores received." Correct answer:
Maintain restricted areas.
Question asked (32206):
A tanker in ballast, having recently left the discharge port is involved in a collision. The
two vessels are still interlocked after the collision and a survey of the ships gives all
crew members are safe and the damage is focussed to the vicinity of the impact. What
should be the greatest concern at this time?
Selected answer:
The possibility of pollution. Correct answer:
The ships moving together in the swell/seaway will cause a spark and consequently an
explosion.
Question asked (32255):
A system for the continuous monitoring of the concentration of hydrocarbon gas shall be
fitted in cargo pump-rooms of oil tankers. A
continuous alarm shall be automatically activated when the hydrocarbon gas
concentration reaches a pre-set level. What are the criteria
for pre-setting the alarm level?
Selected answer:
No higher than 5% of LEL.
Correct answer:
No higher than 10% of LEL.
Question asked (32435):
A ship experiences an interaction effect known as "Squat" when moving in shallow
water. The amount of Squat is affected by the speed of the vessel through the water. If
the speed through the water is HALVED what will be the change in the affect of "Squat"
Selected answer:
The squat effect will also be halved. Correct answer:
The squat effect will be reduced to a quarter of its original value Question asked
(32842):
What actions should the Officer of the Watch take when the ship's steering gear fails?
Selected answer:
Stop engines and display the NUC signal Correct answer:
All of the suggested answers
Question asked (33619):
What, by definition in the International Collision Regulations, is a "vessel restricted in
her ability to manoeuvre"? Selected answer:
A vessel engaged in underwater work, such as the laying, picking up or servicing of a
pipeline, or which is in support of diving operations, performing dredging and mine-
clearance or is deploying or recovering a pilot.
Correct answer:
A vessel which from the nature of her work is restricted in her ability to manoeuvre as
required by the Rules and is therefore unable to keep out of the way of another vessel.
Question asked (33649):
Under most circumstances, how will communication be carried out between a ship and
a SAR helicopter? Selected answer: On 410 KHz. Correct answer: On VHF Ch 16.
Question asked (33661):
Substances, materials and articles shall be stowed as indicated in the Dangerous
Goods List of the IMDG Code, in accordance with a series of stowage categories. How
are those categories designated?
Selected answer:
Three categories, numbered I, ii and iii. Correct answer:
5 categories, labelled A-E.
Question asked (33668):
When conducting a risk assessment for a shipboard work activity, what are the two
elements to be considered? Selected answer:
The chance of an incident re-occuring and the potential effects of an loss. Correct
answer:
The potential severity of harm and the likelihood that harm will occur.
Question asked (34337):
After passing through the scrubbing tower in an inert gas system on an oil tanker, what
is the approximate level of carbon dioxide in the inert flue gas?
Selected answer:
1%
Correct answer:
13%
Installation: Name: User ID: Date of birth: Nationality: Academy: Batch:
SCF Unicom
IGOR VALERYEVICH KARPOV
2311749
24.03.1974
Russian Federation
Show only wrong answers with negative score: No
CES 5.0.3847
24.08.2010
STCW
Management
CES version: Test date: Test type: Level:
Department/Function area: Deck Vessel type/Propulsion: Oil Tanker
Question asked (377):
A large vessel is coming alongside a pier with two tugs assisting and there is little wind
or current affecting the vessel. What would be considered the best use of the tugs and
at which position?
Selected answer:
Made fast Forward and Aft using the centre leads. Correct answer:
Pushing on the ship's side and made fast in case the vessel's movement towards the
berth requires reducing by the tug pulling off.
Question asked (838):
Your vessel is to leave a crowded anchorage making a 180 degrees turn. The ship has
a right-handed propeller and there is equal space either side of the ship (as illustrated).
What would be the most suitable method to make the turn using as little space as
possible?
Selected answer:
Rudder hard to starboard, full ahead. Rudder hard to port, full astern. Repeating this
manoeuvre until the turn has been made. Correct answer:
Rudder hard to port, full astern. After gaining some sternway, rudder hard to starboard
and full ahead
Question asked (1015):
You are the officer in charge of discharging an oil tanker in Corpus Christi, USA. The
applicable sections of the U.S. Code of Federal Regulations require that there be
current Oil Transfer Procedures available on board. What do the regulations require in
terms of the format of, and accessibility to, those Transfer Procedures? Selected
answer:
That the Master of the vessel engaged in a transfer shall, before commencing any
transfer operation, ensure that all crew members involved in that operation shall be
familiar with the applicable operating and emergency procedures and be capable of
communicating in a common language with terminal operators.
Correct answer:
That the procedures be legibly printed in a language or languages easily understood by
personnel engaged in the transfer operation and permanently posted or available at a
place where crew members can see and use them.
Question asked (1044):
If you use chemicals for cleaning up an oil-spill on the water, what would the chemicals
do?
Selected answer:
Remove the oil from the water
Correct answer:
Disperse or dissolve the oil into the water Question asked (1060):
You are on a vessel 10 nautical miles off the coast of Nigeria, West Africa. Are you
allowed to dump empty glass bottles overboard ? Selected answer:
Yes, the bottles can be dumped if they are ground so that the resulting particles can
pass through a screen with 50 mm openings
Correct answer:
Yes, the bottles can be dumped if they are ground so that the resulting particles can
pass through a screen with 25 mm openings
Question asked (2000):
What is the result of a "high metacentric height"? Selected answer:
The vessel will have a great bending moment? Correct answer:
The vessel will roll violently?
Question asked (2027):
An Oil tanker experiences large bending moments and therefore the deck scantlings
must be maintained within "x" length amidships, where "x" is:
Selected answer:
Half Length Correct answer:
0.4 Length
Question asked (2181):
What is the name of the reference manual, jointly produced by the International
Maritime Organization and the International Civil Aviation Authority, which currently
outlines the organization and management of search and rescue activities at sea?
Selected answer:
The Internation Maritime Search and Rescue (IMARSAR) Manual. Correct answer:
The International Aeronautical and Maritime Search and Rescue (IAMSAR) Manual.
Wilful misconduct, gross negligence and violation of Federal Safety Question asked
(3212):
What are the conditions that influence the efforts for organising the fire fighting?
Selected answer:
Where the fire break out, how many fire teams are available, what is burning, distance
to Correct answer:
the fire station
ships mobility, what is burning and
Where the fire breaks out, how many fire teams are available, the strength of the fire,
the communication
Question asked (5493):
The input of an area code prefix in (radio)telex-traffic:
Selected answer:
Has to be put in without the zero
Correct answer:
Differs for each country
Question asked (5562):
When a coastguard-station wants to send a gale-warning by DSC it will happen in the
category:
Selected answer:
Urgency
Correct answer: Question asked (5651):
The good operation in any location, whether the NAVTEX is working properly or not,
can be checked using: Selected answer:
Test transmissions specially broadcast for this purpose once a week Correct answer:
A testing program built in for this purpose
Question asked (5708):
By the degree of selectivity of a receiver is meant: Selected answer:
Ability to distinguish weak stations from adjacent stronger stations Correct answer:
Not less than half the total number of lifebuoys shall be provided with self-ignighting
In a secure and sheltered position and protected from damage by fire or explosion.
The ships moving together in the swell/seaway will cause a spark and consequently an
Show only wrong answers with negative score: No Question asked (369):
A large tanker is proceeding slowly up a narrow channel, using its own engines and
assisted by the use of one tug. Where should the tug be connected to assist the ship in
maintaining its course in the centre of the channel?
Selected answer:
Standing-by - Ready for use anywhere, as required.
Correct answer:
Made fast on a line through the centre lead astern.
Question asked (413):
You are on a power-driven vessel underway in open water. This vessel is sighted on the
port bow on a steady bearing. What kind of vessel is it and what will your action be?
Selected answer:
This is a sailing vessel not making way through the water. There is no risk of collision
and I will maintain my course and speed.
Correct answer:
This is a sailing vessel underway, seen head-on. It is my responsibility to keep clear
under rule 18 and I will take appropriate avoiding action.
Question asked (706):
What is SITREP an abbreviation for?
Selected answer:
Ship Transit Emergency Radio.
Correct answer:
Situation Report.
Question asked (791):
A partially loaded VLCC is drifting with the main engine stopped and undergoing
repairs. The ship is observed to be drifting, due to wind and current towards a danger
area, although there is no immediate concern. What actions would be most suitable in
these circumstances?
Selected answer:
Continue to plot the position and wait for the engines to be repaired. Ask the Engine
Room for an estimate of the time required.
Correct answer:
Use the Bow Thrusters to change the ships head and monitor any changes in the drift
Question asked (822):
When a conventional rudder is put hard over it creates a lift force and a drag force.
When the ship has started to turn, how much lift force do you think remains if the
rudder-angle is decreased to 20 degrees from hard over position (35 degrees)?
Selected answer:
About 30 %
Correct answer:
About 80 %
Question asked (932):
Who will have the authority to take charge and make appropriate decisions in the event
of a vessel emergency when transiting the Panama Canal?
Selected answer:
The Master and Pilot will agree the best course of action to be taken to resolve the
emergency situation.
Correct answer:
The Panama Canal Authority
Question asked (1071):
Which of the following would be considered pollution, when discharged overboard,
under the US water pollution laws?
Selected answer:
Garbage
Correct answer:
All of the mentioned
Question asked (1116):
How frequent should reports from protection and environmental work be send to shore
based management?
Selected answer:
Not mandatory to send reports.
Correct answer:
Annually.
Question asked (1917):
You are proceeding along a narrow channel and approaching a bend, on the inside
shore of which is a large hill, which obsures your view further up channel. What sound
signal will you make to indicate your presence to any vessel that is behind the
obstructing hill?
Selected answer:
Don't know
Correct answer:
One prolonged blast.
Question asked (1930):
ISGOTT requires that hoses used for tank-cleaning are tested for electrical continuity in
a dry condition prior to use. What is the reading that they must display?
Selected answer:
Not more than 10 ohms per metre length.
Correct answer:
Not greater than 6 ohms per metre length.
Question asked (1930):
Testing of tank cleaning hoses. All hoses supplied for tank washing machines should be
tested for electrical continuity in a dry condition prior to use. What are the maximum
ohms per metre length?
Selected answer:
10 ohms per metre length.
Correct answer:
6 ohms per metre length.
Question asked (2000):
What is the result of a "high metacentric height"?
Selected answer:
The vessel's tweendeck heights is too high?
Correct answer:
The vessel will roll violently?
Question asked (2147):
According to the OCIMF Ship to Ship Transfer Guide (Petroleum), which of the following
is the required state of readiness on oil tankers engaged in a cargo transfer?
Selected answer:
The main engine must be ready for immediate use only on the receiving vessel.
Correct answer:
The main engines of both vessels should be ready for immediate use.
Question asked (2154):
Which water can be discharged into the sea without using the ODME?
Selected answer:
Dirty ballast from cargo tanks.
Correct answer:
Ballast from segregated ballast tanks (SBT)
Question asked (2252):
Which of the following requirements to ships stability for normal operation corresponds
At present the MF/HF transmitter often has an automatic aerial turning unit. Should this
The ship is involved in a collision, what is the immediate action by the Officer of the
The best way to prevent stowaways from boarding your ship is to: Selected answer:
Search the ship when you arrive at port and again just after leaving.
Correct answer:
"Seal spaces that are not in use while in port, and perform a search of the ship before
leaving."
Question asked (32217):
Hydrocarbons belongs to a chemical group named:?
Selected answer:
Carbohydrates.
Correct answer:
Organic substances.
Question asked (32220):
In discussing the effeciency of a cargo pump, such as may be used on an oil tanker,
what term is usually used to describe the absolute pressure of a liquid at the inlet to a
pump minus the vapour pressure of the liquid?
Selected answer:
Effective Suction Head Pressure.
Correct answer:
Net Positive Suction Head Available.
Question asked (32250):
Every oil tanker of 5,000 tonnes deadweight and above delivered on or after 1 February
2002 shall comply with intact stability. What is the minimum GM (metacentric height)
when the vessel is in port?
Selected answer:
Not less than 0.25 m
Correct answer:
Not less than 0.15 m
Question asked (32252):
When conducting a risk assessment for a shipboard work activity, what are the two
To maintain good relationship among the crew on board a vessel, one must be:
Selected answer:
Polite and diplomatic while talking to crew members
Correct answer:
Understanding, Co-operative, and have respect from both sides
Question asked (34333):
According to the ISGOTT definition, what is "volatility"?
Selected answer:
The tendency of a crude oil or petroleum product to ignite.
Correct answer:
The tendency of a crude oil or petroleum product to produce gas.
Question asked (34494):
To allow efficient pumping of aromatic Crude Oil cargoes, they are usually heated to
reduce their viscosity. What is the ideal maximum viscosity that is normally achieved for
this purpose?
Selected answer:
1,250 cSt (1,250 mm2/s)
Correct answer:
250 cSt (250 mm2/s)
Installation: Name: User ID: Date of birth: Nationality: Academy: Batch:
SCF Unicom ARTUR MARTIROSYAN 2312569 26.05.1966 Russian Federation
Show only wrong answers with negative score: No
CES 5.0.3847
24.08.2010
STCW
Management
CES version: Test date: Test type: Level:
Department/Function area: Deck Vessel type/Propulsion: Oil Tanker
Question asked (420):
You are in an area of restricted visibility and hear this signal. It is repeated at two minute
intervals. What does it indicate? Selected answer:
That there is another vessel nearby, but that she is at anchor. Correct answer:
That there is another vessel nearby, that she is underway, but stopped and making no
The tug made fast on a line through the centre lead astern, (figure 4). Question asked
(840):
A ship has turned a complete circle (360 degrees) in deep water at full ahead
throughout the turn. The same ship, in the same conditions, is now to make a complete
turn (360 degrees) at half ahead throughout the turn. Would there be any difference in
the size (diameter) of the turning circle?
Selected answer:
Yes, there would be a change of shape of the turning circle; it would have an increase in
the transfer, but not the advance. Correct answer:
No, the diameter of the turning circle would be almost the same.
Question asked (932):
Who will have the authority to take charge and make appropriate decisions in the event
of a vessel emergency when transiting the Panama Canal?
Selected answer:
The ship's Master Correct answer:
The Panama Canal Authority
Question asked (2029):
A conventional tanker has most of its tanks slack during the discharging of oil cargo, it is
not of any great consequence; however, if an OBO has most of its holds slack during
discharging (or loading) of oil cargo this will:
Selected answer:
Cause extreme strain to the hull on the listed side if a list develops? Correct answer:
Likely cause a sudden or violent list due to the very large free surface in the broad
beamed holds?
Question asked (2251):
Which of the following requirements regarding on board stability data corresponds to
present regulations? (NSCL
4/12.1)
Selected answer:
Drawings and caculations documenting the stability of the ship, both in intact and all
possible damage condition. Correct answer:
A calculation example showing the use of "KG" limitation curves. Question asked
(2308):
Any ship of 10.000 tons gross tonnage and above shall be fitted with oily-water
separating equipment for the control of machinery space bilges.What kind of equipment
is required in this connection?
Selected answer:
Oily-water separating equipment only. Correct answer:
The vapour pressure of the liquid at 37.8 degrees C. Question asked (3690):
How often shall crew members participate in fire drills? Selected answer: Once every
week Correct answer:
Once every month
Question asked (5536):
The log-in of an Inmarsat-C installation is important: Selected answer:
To keep watch on Sat-C for safety messages Correct answer:
To inform the NCS that one is available for messages offered Question asked
(5552):
To guarantee optimal reception of VHF-DSC-calls, every:
Selected answer:
DSC-calls are repeated untill received
Correct answer:
DSC-symbol is sent twice and checked extra by Error Check Character Question
asked (5638):
If one requires medical advice by means of an Inmarsat-C terminal one should use the
following address: Selected answer: Radiomedical Correct answer:
Question asked (6049):
" On area A3 the function "" Transmission and reception of on scene communications""
is mainly based on:"
Selected answer:
The use of MF and/or HF R/T
Correct answer:
The use of MF and/or VHF R/T
Question asked (6114):
Operator connected R/T calls are charged Selected answer:
On the basis of a six second minimum charge with one second incremental steps
Correct answer:
On the basis of a three minute minimum charge with one minute incremental steps
Equally spaced and not less than 300 mm or more than 380 mm Question asked
(31373):
Which one of the listed requirements regarding service and maintenance of life-saving
appliances correspond to present regulations? Selected answer:
Maintenance and repair of all the life-saving equipments will be carried out ashore in
work shop only Correct answer:
(32843):
What action should be taken by the Officer of the Watch when the GPS fails? Selected
answer: Call the Master Correct answer:
Inform the technical officer responsible for the electronic navigational equipment and
continue on passage using alternative navigational methods
Question asked (33650):
It has been shown that the controlled release of oil is effective in reducing the effects of
the sea, making it possible for a rescue craft to approach survivors in the water. How
many square metres does the IAMSAR Manual suggest may be calmed by releasing
200 litres of lubricating oil slowly through a rubber hose with the outlet maintained just
above the surface while the ship proceeds at slow speed?
Selected answer:
Approx 50 square metres. Correct answer:
Approx 5,000 square metres.
Question asked (33651):
The recommended distance between parallel tracks (track spacing) in a search for a
casualty by a surface vessel varies (amongst other factors) according to visibility and
the nature of the target in the IAMSAR Manual. These distances are then normally
adjusted for prevailing weather conditions. If visibility was 5 nautical miles and you were
looking for a six-person liferaft, what would the recommended uncorrected track spacing
be?
Selected answer:
5.0 nautical miles. Correct answer:
3.6 nautical miles.
Question asked (33773):
Onboard training should be organised in such a way that: Selected answer:
It does not contravene with the rest hours of the crew Correct answer:
Show only wrong answers with negative score: No Question asked (681):
What can be used to reduce the effect of the state of sea-waves?
Selected answer:
Foam
Correct answer:
Vegetable / Fish Oil
Question asked (1930):
ISGOTT requires that hoses used for tank-cleaning are tested for electrical continuity in
a dry condition prior to use. What is the reading that they must display?
Selected answer:
At least 8 ohms per metre length.
Correct answer:
Not greater than 6 ohms per metre length.
Question asked (1996):
If all indications are that a cargo has been received without damages, irregularities or
short shipment and the phrase "apparent good order and condition" is entered on the
Bill of Lading, what type of Bill is this said to be?
Selected answer:
A Bill of Lading completed for shipment.
Correct answer:
A clean Bill of Lading.
Question asked (3364):
Ship's personnel who assume overall charge of Crude Oil Washing operations must be
trained to the satisfaction of the Flag State administration. Which of the following is a
summary of the conditions that must be met before such persons can assume these
responsibilities?
Selected answer:
They must have at least 12 months equivalent experience on a tanker of any type,
provided at least three washing operations have been witnessed in a supernumary
capacity and be able to demonstrate full knowledge of Annex I of MARPOL 73/78.
Correct answer:
They must have at least one years appropriate experience on oil tankers, have
participated in at least two COW programmes and be fully knowledgeable of the
contents of the Operations and Equipment Manual.
Question asked (5370):
The type-indication of the radio set is mentioned in:
Selected answer:
The survey of equipment
Correct answer:
The safety certificate
Question asked (5501):
During a telex-connection with a subscriber it is:
Selected answer:
Obligatory to send the indication 'msg' at the beginning of the message
Correct answer:
Recommended at the beginning and at the end of the message-transport to exchanges
'answer back's'
Question asked (5559):
On board a DSC-call is to be made in case of an OBS. Choose the category:
Selected answer:
Safety
Correct answer:
Routine
Question asked (5723):
The "clarifier" has only effect during:
Selected answer:
Transmitting in mode H3E
Correct answer:
Receiving in mode J3E
Question asked (5724):
During the 5-yearly overhaul and operational test of a lifeboat on-load release gear, to
Which of the below structures of bulk carriers are considered critical? Selected
answer:
Longitudinal deck plating outside hatches
Correct answer:
Upper and lower connection of main side frames
Question asked (33937):
What type of dynamic forces may cause indent in plating on forecastle deck and main
Display NUC lights and investigate the tidal flow over the next 24 hours and the
Show only wrong answers with negative score: No Question asked (1930):
Testing of tank cleaning hoses. All hoses supplied for tank washing machines should be
tested for electrical continuity in a dry condition prior to use. What are the maximum
ohms per metre length?
Selected answer:
8 ohms per metre length.
Correct answer:
6 ohms per metre length.
Question asked (2999):
The Reid Vapour Pressure (RVP) test is a simple and generally used method for
answer:
The ITU List of Callsigns and Numerical Identities of Stations used by the Maritime
Mobile and Maritime Mobile-Satellite Services
Correct answer:
The ITU List of Ship Stations
Question asked (10325):
*When should a crew member joining a ship for the first time be given some training and
instructions in the use of the ship's fire-fighting appliances ?
Selected answer:
As soon as possible but not later than 24 hours after he joins the ship
Correct answer:
As soon as possible but not later than 2 weeks after he joins the ship
Question asked (31373):
Which one of the listed requirements regarding service and maintenance of life-saving
appliances correspond to present regulations?
Selected answer:
At least one member of the crew shall hold a repairman certificate for life-saving
equipment
Correct answer:
Instructions for onboard maintenance of life-saving appliances in accordance with the
regulations shall be provided
Question asked (31589):
The Training Manual shall contain instructions and information on the life-saving
appliances and the best method of survival. The training manual shall contain detailed
explanations of crew duties in relation to emergency situations. Which of the following
tasks or duties shall be included in the manual according to present regulations?
Selected answer:
The use of escape routes and other escape methodes.
Correct answer:
The use of the ship's line throwing apparatus.
Question asked (32114):
Eavesdropping and phone taps are examples of which threat to information security?
Selected answer:
Terrorism
Correct answer:
Espionage
Question asked (32253):
4/12.1)
Selected answer:
Drawings and caculations documenting the stability of the ship, both in intact and all
possible damage condition.
Correct answer:
A calculation example showing the use of "KG" limitation curves.
Question asked (2312):
MARPOL 73/78 - Annex V. Disposal of garbage outside "Special Areas". After
unpacking spares, you are left with a limited amount of packing materials. What will be
the nearest distance to land for disposal into the sea of this materials?
Selected answer:
12 miles
Correct answer:
25 miles
Question asked (2753):
Shipboard Emergency Drills must be carried out at least (OPA-9C))
Selected answer:
Once every six months
Correct answer:
Once a month
Question asked (2797):
What does MARPOL 73/78 require in respect of the contents of lines and pumps on an
When initially setting up the GPS to provide positions for use with a paper chart, what
The operating mode of a pyrotechnic signal depends essentially on: Selected answer:
The fact that the user is on board a liferaft, a lifeboat or ship
Correct answer:
Instructions or diagrams printed on its casing by the manufacturer
Question asked (31303):
With respect to the ISM, what training in additional to lifeboat and fire drills must be
carried out?
Selected answer:
The boat drill and fire drill should be adequate to meet your needs
Correct answer:
Familiarization, and other drills identified as necessary by the ship
Question asked (31406):
The training manual shall contain instructions and information in easily understood
terms and illustrated wherever possible. Which of the following objects have to be
explained in detail in the manual according to present regulations?
Selected answer:
Donning of fire protection clothing
Correct answer:
Donning of lifejackets and immersion suits
Question asked (31486):
HEL-H is the abbreviation of a heavy helicopter radius of action for rescue purposes.
What do you think the radius and evacuating capacity of the helicopter is?
Selected answer:
100 nm and capacity for evacuating more than 10 persons.
Correct answer:
200 nm and capacity for evacuating more then 15 persons.
Question asked (31605):
Your vessel is involved in a collision with another vessel. What should you as Master tell
What do the shapes that this vessel is displaying tell us about here? Selected answer:
That she is not under command, but is still making way through the water. She is seen
head-on, but we do not know her length, although it is probably over 50 metres.
Correct answer:
That she is not under command and not making way through the water. She is seen
head-on, but we do not know her length.
Question asked (33645):
What does regulation 33 of chapter V of SOLAS require?
Selected answer:
A Rescue Coordination Centre, under the license and control of a contracting
government shall, after due consultation with the owner or operator, have the right to
requistion any vessel it deems appropriate to a search and rescue operation.
Correct answer:
The master of a ship at sea which is in a position to be able to provide assistance on
receiving information from any source that persons are in distress at sea, is bound to
proceed with all speed to their assistance, if possible informing them or the search and
rescue service that the ship is doing so.
Question asked (33647):
If a master initially responds to a distress but then, in special circumstances, decides
By which method is the Vapour Pressure of Crude Oil determined? Selected answer:
The True Vapour Pressure value is always used.
Correct answer:
The Reid Closed Test method.
Question asked (34502):
Fluid-driven eductors (as commonly found on crude oil tankers), operate on a principle
known as Bernoulli's principle. What does that state?
Selected answer:
The discharge rate is inversely proportional to the pressure applied in the drive inlet.
Correct answer:
The speed of a moving fluid increases as the pressure in the fluid decreases.
Installation: SCF Unicom
Name:
User ID: 2311749
Date of birth: 24.03.1974
IGOR VALERYEVICH KARPOV
Nationality:Russian Federation Academy:
CES 5.0.3847
CES version:
Test date: Test type: Level:
19.08.2010
STCW
Management
Department/Function area: Deck Vessel type/Propulsion: Oil Tanker
Batch:
Show only wrong answers with negative score: No Question asked (1017):
According to 33 CFR 156, oil tankers trading in US waters are required to test and
document the testing of cargo transfer hoses and transfer pipe system. What is the
minimum requirement when testing these components?
Selected answer:
That no leakage occurs under dynamic fluid pressure of less than 1.5 times the
maximum allowable working pressure. Correct answer:
That no leakage occurs under static liquid pressure of at least 1.5 times the maximum
The collision regulations are based on ship courses through the water. Question
asked (2753):
Shipboard Emergency Drills must be carried out at least (OPA-9C)) Selected answer:
Once every six months Correct answer:
Once a month
Question asked (2948):
In respect of washings from the cargo area of an oil tanker, what is the maximum
instantaneous rate of oil that can be discharged into the sea when a vessel is outside a
special area, proceeding en route, has in operation a monitoring and control system for
the discharge of oil and is located more than 50 nautical miles from the nearest land?
Selected answer:
300 litres per nautical mile. Correct answer:
30 litres per nautical mile.
Question asked (3005):
Some centrifugal cargo pumps on oil tankers are designed with an automatic stripping
system, which allows the cargo tank to fully discharge its contents. By what principle
does such a stripping system operate?
Selected answer:
On the principle that if the suction is fitted low enough in the cargo oil tank and a
specified minimum trim is maintained, suction will be available until the tank is
completely discharged.
Correct answer:
On the basis that, if cargo vapour can be stopped from entering the cargo pump suction
inlet, the flow will continue without cavitation. Question asked (3006):
According to the Oil Pollution Act of 1990 (OPA-90), oil carrying vessels trading in U.S.
waters are required to carry oil spill clean up equipment for the containment and
removal of on-deck spills. For a vessel of over 400 feet (121.9 metres) in length, what
volume of oil must they be able to handle?
Selected answer:
1 barrel (0.16 cubic metre). Correct answer:
12 barrels (1.91 cubic metres).
Question asked (3233):
How many annexes do we find in MARPOL 73/78 and what is the content of annex 1 ?
Selected answer:
We find 5 annexes in MARPOL 73/78 and annex 1 is the regulations for the prevention
of pollution by sewage Correct answer:
We find 6 annexes in MARPOL 73/78 and annex 1 is the regulations for the prevention
A traffic list with the call-sign of the ships involved in alphabetical numerical sequence
Only send a positive delivery notification (PDN) to the sender if the sender requested,
At sea, outside territorial waters, and in port or harbour Question asked (5883):
What is understood by the term "Balanced Rudder"? Selected answer:
A rudder with equal rudder area forward and aft of the turning axis, the turning axis
Correct answer:
proper way:
it can be automatically compared and corrected
being at the geometrical centre of the rudder area the load on the steering motor.
A rudder with part of the rudder area forward of the turning axis, therefore reducing
Question asked (31029):
What does ISM stand for? Selected answer: Internal Ship Safety Management
Correct answer:
The International Management Code for the Safe Operation of Ships and for Pollution
"Seal spaces that are not in use while in port, and perform a search of the ship before
A report giving the result of the Conformance Test, issued by the Classification Society
asked (33936):
When does a bulk carrier experience extreme tension in bottom structure during fast
rate loading? Selected answer:
During correct loading pattern but with heavy cargo Correct answer:
If the whip-antenna is replaced by an antenna of about the same length as the original
Show only wrong answers with negative score: No Question asked (370):
What will have a major effect on the performance of a tug when used to assist in the
manoeuvring of a large vessel?
Selected answer:
The experience of the tug crew.
Correct answer:
The position of the tug relative to the ship's pivot point
Question asked (1026):
Before starting a transfer of oil, the person in charge on the vessel and the person in
charge on the facility must hold a pre transfer conference. Who must decide to start the
transfer?
Selected answer:
The person in charge who is handling the pumping
Correct answer:
Both persons in charge
Question asked (1181):
Who is responsible for keeping the required official publications onboard?
Selected answer:
The owner.
Correct answer:
The master.
Question asked (1657):
ISGOTT draws attention to the risk of electrostatic potential in a mist produced by using
oil and water mixture in Crude Oil Washing operations. How does the Guide
recommend this is avoided?
Selected answer:
Crude Oil Washing, where the oil source is stored in a slop tank or other tank that has
previously contained slops, should be avoided.
Correct answer:
Before washing begins, any tank that is to be used as a source of oil for Crude Oil
Washing should be partly discharged to remove any water that has settled out during
the voyage. The discharge of a layer of at least 1 metreis necessary for this purpose.
Question asked (1721):
The emergency fire pump is in accordance with good seamanship and precautionary
routines run and tested weekly. Routine checks and maintenance are normally carried
out by dedicated personnel. To ensure safe and appropriate operation of the pump,
would you consider it beneficial that the same dedicated personnel operate the pump in
emergencies?
Selected answer:
Only senior engineers should operate the emergency pump.
Correct answer:
In case of accidents, it is important that a wide range of personnel must be permitted
and trained to operate the pump.
Question asked (1910):
Non distress calls on 2182 kHz and VHF channel 16 should not exceed:
Selected answer:
Two minutes.
Correct answer:
One minute.
Question asked (1936):
What medium is used to calibrate the ODME?
Selected answer:
Sea water.
Correct answer:
Fresh water.
Question asked (1996):
If all indications are that a cargo has been received without damages, irregularities or
short shipment and the phrase "apparent good order and condition" is entered on the
Bill of Lading, what type of Bill is this said to be?
Selected answer:
An endorsed Bill of Lading.
Correct answer:
A clean Bill of Lading.
Question asked (2455):
How can an ARPA assist the ship to steer a suitable course to make good the entrance
Correct answer:
6
Question asked (5614):
The relay of a distress-call by an RCC for coast-station begins with:
Selected answer:
MAYDAY (3x)
Correct answer:
MAYDAY RELAY (3x)
Question asked (5634):
To receive distress alerting and MSI via an Inmarsat-C set vessels must have:
Selected answer:
A radio officer on board
Correct answer:
SES or an EGC receiver
Question asked (5650):
Via a coast-station radio medical advice is asked using NBDP. What command has to
be given after ga +?
Selected answer:
medical
Correct answer:
med +
Question asked (5803):
With an EPIRB:
Selected answer:
You must check the manufacturer of the battery
Correct answer:
You must check the date the battery must be replaced
Question asked (5809):
A battery of 24 Volt supplies during 10 hours a current of 6 ampere. What is the
capacity supplied:
Selected answer:
240 Ah
Correct answer:
60 Ah
Question asked (5864):
What is the main purpose of VTS?
Selected answer:
Increase safety for ships participating in VTS
Correct answer:
Increase the safety of all ships and the protection of the environment in the vicinity.
Question asked (31303):
With respect to the ISM, what training in additional to lifeboat and fire drills must be
Your vessel is involved in a collision with another vessel. What should you as Master tell
Which of the following is a definition of the "Proper Shipping Name", as found in the
During the 5-yearly overhaul and operational test of a lifeboat on-load release gear, to
Evaluation of the situation, rescue and life-saving, confinement of fire, extinction, then
length = 480 mm, breadth = 115 mm, depth = 25 mm Question asked (20388):
*When reasonable and practicable, how often shall rescue boats be launched with their
assigned crew aboard and manoeuvred in the water?
Selected answer:
Every six months Correct answer:
Every month
Question asked (20428):
If a distress signal is received on board your ship, what should be the first action that
should be taken? Selected answer:
Contact SAR Authorities via nearest coastal Radio station Correct answer:
Attempt to establish contact with the distressed vessel
Question asked (32249):
According to MARPOL there are requirements regarding minimum amidships draught
for crude oil tankers in ballast condition. What is the formula for calculating minimum
draught amidships?
Selected answer:
2.0 + 0.02L Correct answer:
2.0 + 0.02L
Question asked (33628):
You are in an area of restricted visibility. You hear this sound signal. What does it
mean? Selected answer:
That there is a vessel at anchor in the vicinity. Correct answer:
Pressure: 1 psi (0.069 bar) Vacuum: 0.5 psi (0.034 bar) Question asked (34495):
What kind of Crude Oils are required by MARPOL to be specifically listed in a tanker's
Crude Oil Washing manual as unsuitable for cleaning by that method?
Selected answer:
Those on the IMO Oil Tanker Technical Committee COW banned list. Correct answer:
Those with high pour point or viscosity.
Installation: SCF Unicom
Name:
User ID: 2318927
Date of birth: 08.02.1985
AN DREY IGOREVICH BELYAKOV
Nationality: Russian Federation Academy:
CES 5.0.3838 10.08.2010 STCW
CES version: Test date: Test type: Level:
Operational
Department/Function area: Deck Vessel type/Propulsion: Oil Tanker
Batch:
Show only wrong answers with negative score: No Question asked (412):
Rule 12 of the International Collision Regulations prescribes the action to be taken by a
sailing vessel when meeting another sailing vessel. This depends on the direction of the
wind relative to each vessel. In the situation shown here, which sailing vessel (A or B)
must keep out of the way of the other?
Selected answer:
Sailing vessel B must keep out of the way of sailing vessel A.
Correct answer:
Sailing vessel A must keep out of the way of sailing vessel B.
Question asked (441):
When navigating along a coastline what should be considered the most accurate
method of navigating?
Selected answer:
Use of radar ranges and bearings
Correct answer:
Use of Differential GPS
Question asked (442):
When taking a position using the Radio Directional Finder, a correction must be applied
to the bearings. What is the purpose of this correction (Half Convergency?)
Selected answer:
To correct for the refraction of the atmosphere
Correct answer:
To convert between great circle and rhumb line bearings
Question asked (561):
How can a new officer, just boarding a ship, ensure that he knows the location and
operation of all navigational and safety equipment and take account of the operating
limitations of such equipment?
Selected answer:
By using the equipment on regular watchkeeping duties
Correct answer:
By asking other officers and practicing with the use of the equipment
Question asked (681):
What can be used to reduce the effect of the state of sea-waves?
Selected answer:
Fuel Oil
Correct answer:
Vegetable / Fish Oil
Question asked (713):
What is the purpose of a sea anchor?
Selected answer:
To adjust the drifting speed of the lifeboat
Correct answer:
To keep the lifeboat steady against the sea/wind
Question asked (723):
The Urgency Message from a ship is used to notify other traffic of a situation where the
ship is not in imminent danger, but where the development of the situation is uncertain
and may need assistance in the near future. What is the telephony urgency message
like?
Selected answer:
MAYDAY
Correct answer:
PAN-PAN
Question asked (794):
A ship normally turns (swings) around a point which is not the centre of gravity. What is
this point normally called?
Selected answer:
Centre of Turn
Correct answer:
Pivot Point
Question asked (808):
The ship is required to be stopped in the water as quickly as possible, but without major
changes to the ship's heading. What is the most effective method to achieve this?
Selected answer:
Make a zig zag manoeuvre while reducing the engine power.
Correct answer:
The use of the rudder hard over both sides combined with reducing engine power, a
method known as "high frequency rudder cycling"
Question asked (1012):
SOLAS requires that an Inert Gas system on an oil tanker is capable of delivering inert
gas with a maximum level of oxygen at any required rate of flow. What is that level?
Selected answer:
Not less than 8% by volume.
Correct answer:
Not more than 5% by volume.
Question asked (1015):
You are the officer in charge of discharging an oil tanker of 15000 DWT in Corpus
Christi, USA. Where shall the Oil Transfer Procedure be located?
Selected answer:
Available in the Chief Officers office, or Captains office
Correct answer:
Posted or available where it can be easily seen and used by crew-members engaged in
the discharge operation.
Question asked (1088):
What is the purpose of the decanting line between two slop tanks on an oil tanker that is
using water for the washing of the cargo tanks? Selected answer:
To avoid a build-up of static electricity during water washing, caused by air being drawn
in as the primary slop tank empties.
Correct answer:
To enable most of the recovered oil to be retained in the primary slop tank, while the
cleaner part of the water will flow into the secondary slop tank, where it can be re-used
as wash-water.
Question asked (1498):
What will you serve seafarers who has been exposed to cold?
Selected answer:
Brandy, whiskey or other strong drinks.
Correct answer:
Warm nutritious drinks.
Question asked (1637):
"A" Class divisions in ships are constructed so that they are capable of preventing the
passage of smoke and flame to the end of a standard fire test held for how many
minutes?
Selected answer:
15 minutes.
Correct answer:
60 minutes
Question asked (1931):
Measurement of oil cargoes is often achieved with a "UTI" device. What do the letters
"UTI" stand for?
Selected answer:
Ullage Topping Instrument.
Correct answer:
Ullage Temperature Interface.
Question asked (2154):
Which type of water can be discharged into the sea without using the ODME?
Selected answer:
Water from slop tanks.
Correct answer:
Ballast from segregated ballast tanks (SBT)
Question asked (2446):
What is the correct setting of the "Anti sea clutter" control on the radar?
Selected answer:
All of the suggested answers
Correct answer:
A few sea returns remaining on the screen.
Question asked (2929):
What can a quick change of liquid flow in a pipe line lead to? Selected answer:
The terminal gives the order of what to do.
Correct answer:
Pressure surge and liquid pressure.
Question asked (2936):
Before commencing loading an oil cargo, the cargo tanks are surveyed. How do we
refer to any small amount of liquid, sludge and sediment found in the cargo tanks and
assessed for the purposes of including in the calculation of cargo quantity loaded?
Selected answer:
TSV (Total Surveyed Volume).
Correct answer:
OBQ (On Board Quantity).
Question asked (2940):
To discharge the last amount of cargo ashore, the stripping pump through the small
diameter line is used. Where does this small diameter line come from in the pump room
and where is the line ending at the manifold?
Selected answer:
From the stripping pump's delivery side to a particular shore line.
Correct answer:
From the stripping pump's delivery side directly to the manifold's presentation flange.
Question asked (3016):
The successive stages of all cargo and ballast handling operations on an oil tanker must
be recorded on board. What is the name of the book where these details are listed?
Selected answer:
The Deck Operations Logbook.
Correct answer:
The Oil Record Book.
Question asked (3191):
The Master arrives on the bridge obviously under the influence of alcohol and states he
is taking over the "con" of the ship. What actions should the Officer of the Watch (OOW)
take in this situation?
Selected answer:
Tell the Master you do not think this is a good idea and retain control of the watch.
Correct answer:
Attempt to diplomatically avoid taking any actions that would put the ship or crew into
danger and call the Chief Officer for assistance.
Question asked (3204):
answer:
Watertight doors can be closed locally and also a remote control station within the
accommodation
Correct answer:
Watertight doors can be closed adjacent to the door and remotely from bridge and also
one emergency remote control station
Question asked (3702):
An alarm signal consisting of seven short blast followed by one prolonged blast is
sounded by the ship's whistle and alarm bells. What are you to do?
Selected answer:
Go to (or remain in) your cabin and await further orders
Correct answer:
Go to your lifeboat station
Question asked (3703):
What is the meaning of this symbol ?
Selected answer:
Secure hatches
Correct answer:
Fasten seat belts
Question asked (5406):
A vessel is equipped for all sea areas. In the middle of the Indian Ocean the EGC-
receiver appears out of order. Is it still possible to receive MSI-messages?
Selected answer:
Yes with VHF DSC
Correct answer:
Yes, with the MF/HF-radio telex
Question asked (5559):
On board a DSC-call is to be made in case of an OBS. Choose the category:
Selected answer:
Safety
Correct answer:
Routine
Question asked (5756):
What mode must be used on the MF/HF transmission when making a radiotelephone
call:
Selected answer:
H3E
Correct answer:
J3E
Question asked (5794):
answer:
On the basis of a six second minimum charge with one second incremental steps
Correct answer:
On the bases of a six second minimum charge with six second incremental steps
Question asked (6116):
Messages sent via INMARSAT C are charged:
Selected answer:
On the basis of a six second minimum charge with six second incremental steps
Correct answer:
On the number of kilobits of information transmitted per block of 256 bits
Question asked (10089):
The halogenated hydrocarbons (halon), are hydrocarbons in which the molecules have
one (or more) atom(s) of hydrogen replaced by another atom (or atoms) of
Selected answer:
Nitrogen and/or fluorine
Correct answer:
Fluorine and/or bromine
Question asked (20353):
Buoyant smoke signals shall be so designed as to burn or emit smoke:
Selected answer:
Only when not in the water
Correct answer:
Continuously after having been immersed for a period of 10 seconds under 100 mm of
water when underwater
Question asked (31307):
What is the main theme of modern safety practice?
Selected answer:
Health & Safety at Work Act
Correct answer:
Making use of Risk Assessment as a means to improving safety
Question asked (31439):
What is an oxygen analyzer used for?
Selected answer:
Check if there is explosive atmosphere in the oxygen.
Correct answer:
Measure oxygen contents in the atmosphere.
Question asked (32267):
What new stability problems would be caused by having deep double bottom tanks on
What is the purpose of having corrugations in the bulkheads in the cargo tanks of an oil
What could be the reason for the magnetic compass to swing through large angles
What are the ideal conditions required to satisfactorily conduct an Inclining Experiment?
Selected answer:
All derricks lowered and no moving items on deck and in store rooms
Correct answer:
All of the suggested answers
Question asked (33612):
What are we seeing here?
Selected answer:
A sailing vessel, seen from astern, where the edges of her sidelights are both visible.
Correct answer:
A sailing vessel less than 20 metres in length, displaying the optional combined lantern
in lieu of standard sailing lights, seen head-on.
Question asked (33686):
What is this?
Selected answer:
The United Nations stamp used for endorsing international shipping certificates.
Correct answer:
The United Nations Packaging symbol used for Dangerous Goods.
Question asked (33688):
What is the name given to the special list of cargo loaded on board a ship that needs to
be prepared for reporting and other administrative purposes?
Selected answer:
Stowage Plan.
Correct answer:
Manifest.
Question asked (33736):
What does the word "pyrotechnics" mean?
Selected answer:
Pyrotechnics is a group word to cover all the required activities in the event of a man
overboard
Correct answer:
Pyrotechnics are the items which are capable of self-contained chemical reactions for
the production heat, light, smoke and/or sound
Question asked (33741):
What would be the correct method to report to other ships in the vicinity that a person
has fallen overboard from your vessel?
Selected answer:
"Man overboard"
Correct answer:
"Vessel "name" has lost a person overboard in "position
Question asked (33989):
In describing an oil cargo, what is its "pour point"?
Selected answer:
The temperature necessary for a cargo to load from shore by gravity alone
Correct answer:
The lowest temperature at which it will remain fluid
Installation: Name: User ID: Date of birth: Nationality: Academy: Batch:
SCF Unicom ARTUR MARTIROSYAN 2312569 26.05.1966 Russian Federation
Show only wrong answers with negative score: No
CES 5.0.3847
23.08.2010
STCW
Management
CES version: Test date: Test type: Level:
Department/Function area: Deck Vessel type/Propulsion: Oil Tanker
Question asked (386):
You are on a tug and are towing an unmanned barge. You are restricted in your ability
to manoeuvre. The total length of the tow is 219 metres. What daylight signals are
required by the International Regulations for Preventing Collisions at Sea?
Selected answer:
A diamond shape, where it can best be seen, on the tug only. Three shapes shall also
be displayed, being three balls in a vertical line. Correct answer:
A diamond shape, where it can best be seen shall be displayed on the tug and the tow.
Three shapes shall also be displayed in a vertical line, the upper and lower being balls
and the middle one a diamond. Diamond shape
Question asked (688):
The bridge wheelman has not reported for duty and there is a suspected "Man
Overboard" situation on your vessel. The ship has been searched and there is one
seaman missing? The vessel turns round and retraces the course back, calling for
assistance from other vessels in the vicinity. What should be the focal point for any
search pattern to be established? Selected answer:
The focus of the search should be from the present position as he probably went
overboard when proceeding to the bridge for his watch. Correct answer:
Determine when the seaman was last sighted and concentrate the search round the
course line between the last sighting and present position, taking into account any
prevailing current.
Question asked (2181):
What is the name of the reference manual, jointly produced by the International
Maritime Organization and the International Civil Aviation Authority, which currently
outlines the organization and management of search and rescue activities at sea?
Selected answer:
The Merchant Ship Search and Rescue (MERSAR) Manual. Correct answer:
The International Aeronautical and Maritime Search and Rescue (IAMSAR) Manual.
Question asked (2887):
Subject to allowance by the Port State Authority a tanker with defect oil discharge
monitoring and control system (ODME) may undertake?
Selected answer:
The vessel must proceed to repair port.
Correct answer:
One ballast voyage before proceeding to a repair port.
Question asked (2943):
What is the minimum height of vent outlets of a controlled venting system from cargo
tanks? Selected answer: A height of not less than 3 m.
Correct answer:
A height of not less than 6 m.
Question asked (3005):
Some centrifugal cargo pumps on oil tankers are designed with an automatic stripping
system, which allows the cargo tank to fully discharge its contents. By what principle
does such a stripping system operate?
Selected answer:
By automatically reducing the rate at which oil cargo enters the cargo pump, such that
any vapour lifted along with the liquid does not cause a loss of suction.
Correct answer:
On the basis that, if cargo vapour can be stopped from entering the cargo pump suction
inlet, the flow will continue without cavitation. Question asked (5775):
The accuracy of an Inmarsat-E positioning-system is: Selected answer: 20 meters
Correct answer:
200 meters
Question asked (6035):
Which of the following is a coast station MMSI ? Selected answer: 22753000 Correct
answer:
2275300
Question asked (20348):
A rocket parachute flare reaches an altitude of Selected answer: not less than 40m
Correct answer:
not less than 300m
Question asked (31358):
Which one of the listed requirements regarding life-saving appliances corresponds to
present regulations? Selected answer:
All prescribed life-saving appliances shall be of such a colour that they are in contrast to
the surrounding colour Correct answer:
Sound the General Alarm and stop engines. Question asked (32142):
Which of these statements about drug smuggling is true? Selected answer:
"The preventative measures you incorporate into your ship's security plan should be
exhaustive, regardless of the level of threat identified by your ship's security
assessment."
Correct answer:
The risks to ships are not restricted to specific areas or trading routes. Question asked
(32256):
One or more pressure/vacuum-breaking devices shall be provided on the vent mains to
prevent the cargo tanks from being subject to a positive and negative pressure. What is
the normal pre-set point for negative pressure?
Selected answer:
Depending on the test pressure of the cargo tank. Correct answer: