Professional Documents
Culture Documents
Two coats are needed for optimum performance. A third coat may be
Pot Life 1 Hour at 75F (24C), 2 Hours at 60F (15C); less at
applied for additional thickness and/or service life. higher temperatures. Pot life ends when coating loses
body and begins to sag.
Solids Content By Volume 84% +/- 2%
Theoretical 2 2
1347 ft at 1.0 mils (33.1 m /l at 25 microns) Application Equipment Guidelines
Coverage Rate 2 2
337 ft at 4.0 mils (8.3 m /l at 100 microns) Listed below are general equipment guidelines for the application of this product. Job site conditions
2 2 may require modifications to these guidelines to achieve the desired results.
225 ft at 6.0 mils (5.5 m /l at 150 microns)
Conventional Pressure pot equipped with dual regulators, 3/8
Allow for loss in mixing and application. Spray I.D. minimum material hose, .070 I.D. fluid tip
VOC Values Thinner 2 20% by volume 2.00 lbs./gal (240 g/l) and appropriate air cap. Adjust air pressure to
As Supplied 1.00 lbs/gal (119 g/l) approximately 50 psi at the gun and provide 10-20 lbs.
These are nominal values and may vary slightly with color. of pot pressure.
Airless Spray Pump Ratio: 30:1 (min.)
Under Insulation Continuous: 400 F (204 C) GPM Output: 2.5 (min.)
Resistance Non-Continuous: 450 F (232 C) Material Hose: 3/8 I.D. (min.)
Temperature Immersion temperature resistance depends upon Tip Size: .017-.021
Resistance exposure. Consult Carboline Technical Service for Output PSI: 1500-2300
(Immersion) specific information. Filter Size: 60 mesh
PTFE packings are recommended
Substrates & Surface Preparation Apply a mist bonding pass. Allow to dry approximately one minute but
not long enough to allow film to completely dry. Apply crisscross multi-
passes, moving gun at fairly rapid rate, maintaining a wet appearing film.
General Remove any oil or grease from surface to be coated in Fast multi-passes may be applied until you have a wet film thickness of
accordance with SSPC-SP1. approximately 6-8 mil (150-200 ). Repeat this procedure for the second
coat to obtain an 8-12 mil (200-300 ) DFT. Call Tech. Service for Q&A
Steel SSPC-SP10; Surface Profile should be dense angular
2.0-3.0 mils (50-75 ) Brush Use medium bristle brush. Not recommended for tank
Stainless Steel Profile should be dense angular 2.0-3.0 mils (50-75 ). lining applications except when striping welds. Avoid
Remove all surface contaminants that would interfere excessive re-brushing for best results.
with the performance of stainless steel for the intended Roller Not recommended for tank lining applications except
service such as, but not limited to, imbedded iron or when striping welds. Use a short-nap synthetic roller
chlorides. with phenolic core.