You are on page 1of 41

SERVICE MANUAL

LCD191SD
LCD221SD
LCD-DTV

DEC07 SERVLCD191.221
LH19S83T/LH22S83T SERVICE MANUAL

INDEX:

PART 1Brief Introduction Of The LH19S83T/LH22S83T


Schematic Diagram Block
Printed Circuit

PART 2: Exploded view

PART 3 IC Introduction

PART 4: Detailed Circuit

PART 5: Components List

PART6: Debug Instruction


Part1:

Schematic Diagram

5V IR GND K0 RED GREEN


MP1411 TDA1517
LVDS 1.8V
1117 3.3V 3.3V
U2 2.5V U3
5V
1.87V
1.8V
128M DDR

DC to DC U9
SPDC210C
FLASH
U20 u7
SPHE1002
MOS
U21 u12
FLASH
SPV7100

64M SDRAM
U8
U10

U16

TV-CVBS/TV-audio

YPBPR Lin/Rin/AV1 TUNER


HDMI VGA USB HPin out
12V AV2/Lin/Rin Svideo
Printed Circuit

TV Main Board (Top View)

TV Main BoardBottom view


Part3:
IC Introduction

Wide Range Input Voltage Simple Synchronous DC/DC


Converter RT8110
General Description Features
The RT8110 is a single power supply PWM DC-DC z Wide Input Operation Voltage 5V to 23V
controller designed to drive N-MOSFET in a synchronous z 0.8V Internal Reference
buck topology. The IC integrates the control, output z Drive Two N-MOSFETs
adjustment, monitor and protection functions in a small z High DC gain Voltage Mode PWM Control
8-pin package. z Fast Transient Response
z Fixed 400kHz Oscillator Frequency
The RT8110 uses an internal compensation high DC gain
z Fully Dynamic 0 to 80% Duty Cycle
voltage mode PWM control for simple application design.
z Internal Soft Start
An internal 0.8V reference allows the output voltage to be
z Adaptive Non-Overlapping Gate Driver
precisely regulated for low voltage requirement. A fixed
z Over-Current Protection Under Voltage Lockout
400kHz oscillator reduces the component size for saving
z RoHS Compliant and 100% Lead (Pb)-Free
board space.
The RT8110 features over current protection, and under Applications
voltage lock-out. The output current is monitored by
z Motherboard Power Regulation for Computers
sensing the voltage drop across the Low side MOSFET's
z Subsystems Power Supplies
RDS(ON), which eliminates the need for a current sensing
z Cable Modems, Set Top Boxes, and DSL Modems
resistor.
z DSP and Core Communication processor Supplies
z Memory Power Supplies
Ordering Information z Personal Computer Peripherals
RT8110 -
z Industrial Power Supplies
Package Type
V8 : SOT-23-8 z 5V-Input DC-DC Regulators
Operating Temperature Range z Low Voltage Distributed Power Supplies
P : Pb Free with Commercial Standard
G : Green (Halogen Free with Commer-
cial Standard) Pin Configurations
Note : (TOP VIEW)
UGATE
PHASE

LGATE

RichTek Pb-free and Green products are :


GND

`RoHS compliant and compatible with the current require-


ments of IPC/JEDEC J-STD-020. 8 7 6 5
`Suitable for use in SnPb or Pb-free soldering processes.
1 2 3 4
`100% matte tin (Sn) plating.
BOOT

DRIVE

FB

VCC

Marking Information
SOT-23-8
For marking information, contact our sales representative
directly or through a RichTek distributor located in your Note : There is no pin1 indicator on top mark for SOT-23-8
area, otherwise visit our website for detail. type, and pin 1 will be lower left pin when reading top mark
from left to right.
AP4228GM
Pb Free Plating Product
Advanced Power N-CHANNEL ENHANCEMENT MODE
Electronics Corp. POWER MOSFET

Low On-Resistance D2 BVDSS 30V


D2
Simple Drive Requirement D1
D1 RDS(ON) 26m
Dual N MOSFET Package ID 6.8A
G2
S2
G1
SO-8 S1

Description D2
D1

The Advanced Power MOSFETs from APEC provide the


designer with the best combination of fast switching, G1 G2
ruggedized device design, lower on-resistance and
cost-effectiveness. S1 S2

Absolute Maximum Ratings


Symbol Parameter Rating Units
VDS Drain-Source Voltage 30 V
VGS Gate-Source Voltage 20 V
3
ID@TA=25 Continuous Drain Current 6.8 A
3
ID@TA=70 Continuous Drain Current 5.5 A
1
IDM Pulsed Drain Current 40 A
PD@TA=25 Total Power Dissipation 2 W
Linear Derating Factor 0.016 W/
TSTG Storage Temperature Range -55 to 150
TJ Operating Junction Temperature Range -55 to 150

Thermal Data
Symbol Parameter Value Unit
3
Rthj-amb Thermal Resistance Junction-ambient Max. 62.5 /W

Data and specifications subject to change without notice 201016031


TM

MP1411
2A, 18V, 380KHz
Step-Down Converter
The Future of Analog IC Technology TM

DESCRIPTION FEATURES
The MP1411 is a monolithic step-down switch 2A Output Current
mode converter with a built in internal power 0.2 Internal Power MOSFET Switch
MOSFET. It achieves 2A continuous output Stable with Low ESR Output Ceramic
current over a wide input supply range with Capacitors
excellent load and line regulation. Up to 95% Efficiency
Current mode operation provides fast transient 23A Shutdown Mode
response and eases loop stabilization. Fixed 380KHz Frequency
Thermal Shutdown
Fault condition protection includes cycle-by-cycle
Cycle-by-Cycle Over Current Protection
current limiting and thermal shutdown. In
shutdown mode the regulator draws 23A of Wide 4.75V to 18V Operating Input Range
supply current. Programmable soft-start Output Adjustable from 0.92V to 16V
minimizes the inrush supply current and the Programmable Under Voltage Lockout
output overshoot at initial startup. Available in an MSOP10 with Exposed Pad
Package
The MP1411 requires a minimum number of
readily available standard external components. APPLICATIONS
Distributed Power Systems
Battery Charger
DSL Modems
Pre-Regulator for Linear Regulators
MPS and The Future of Analog IC Technology are Trademarks of Monolithic
Power Systems, Inc.

TYPICAL APPLICATION
INPUT
Efficiency vs
4.75V - 18V C5
Output Current
10nF 95
4 2
90
IN BS 5.0V
OPEN = AUTOMATIC 9 5 VOUT
EFFICIENCY (%)

EN SW 85 3.3V
STARTUP D1 3.3V/2A
MP1411 B220A 80
2.5V
10 7
SS FB
GND COMP 75
6 8
70
C3
C6 3.9nF 65
OPEN
60
0 0.5 1.0 1.5 2.0 2.5
MP1411_TAC_S01
OUTPUT CURRENT (A)
MP1411_EC01
AP1084

5A Low Dropout Positive Adjustable or Fixed-Mode Regulator

Features General Description


1.4V maximum dropout at full load current AP1084 is a low dropout positive adjustable or fixed-
Built-in thermal shutdown mode regulator with minimum of 5.0A output current
Output current limiting capability. The product is specifically designed to
Adjustable output voltage or fixed 1.5V, 1.8V, 2.5V, provide well-regulated supply for low voltage IC
3.3V, 5.0V applications such as high-speed bus termination and
Fast transient response low current 3.3V logic supply. AP1084 is also well
Good noise rejection suited for other applications such as VGA cards.
Package : TO252, TO263, TO220 AP1084 is guaranteed to have lower than 1.4V
dropout at full load current making it ideal to provide
well-regulated outputs of 1.25 to 3.3V with 4.7 to
12V input supply.

Ordering Information
AP1084 X X X X

Low Dropout Regulator Package Vout Lead Free Packing


D : TO252-3L Blank : Adj Blank : Normal Blank : Tube
K : TO263-3L 15 = 1.5V L : Lead Free Package A : Taping
T : TO220-3L 18 = 1.8V
25 = 2.5V
33 = 3.3V
50 = 5.0V

Typical Circuit

5.0V to 3.3V Fixed Mode Regulator Adjustable Regulator


5V
5V C1
C1 100uF
100uF

Vin Vin

Vout 3.3V/5A Vout 2.5V/5A


R1 121 C2
GND C2 Adj
100uF
100uF R2 121
Tab is Vout Tab is Vout

R2
Note: Vo = VREF (1+ )
R1
AP1117
1A Low Dropout Positive Adjustable or Fixed-Mode Regulator

Features General Description


- 1.4V maximum dropout at full load current AP1117 is a low dropout positive adjustable or
- Fast transient response fixed-mode regulator with minimum of 1A output
- Output current limiting current capability. The product is specifically
- Built-in thermal shutdown designed to provide well-regulated supply for low
- Packages: SOT223, TO263, TO252, TO220, voltage IC applications such as high-speed bus
SOT89 termination and low current 3.3V logic supply.
- Good noise rejection AP1117 is also well suited for other applications
- 3-Terminal Adjustable or Fixed 1.5V, 1.8V, 1.9V, such as VGA cards. AP1117 is guaranteed to have
2.5V, 3.3V, 5.0V lower than 1.4V dropout at full load current making
it ideal to provide well-regulated outputs of 1.25 to
Applications 5.0 with 6.4V to 12V input supply.

- PC peripheral
- Communication

Ordering Information

AP 1117 X XX X X

Low Dropout Regulator Package Vout Lead Free Packing


E : SOT223-3L Blank : ADJ Blank : Normal Blank : Tube
K : TO263-3L 15 : 1.5V L : Lead Free Package A : Taping
D : TO252-3L 18 : 1.8V
T : TO220-3L 19: 1.9V
Y : SOT89-3L 25 : 2.5V
33 : 3.3V
50 : 5.0V

Typical Circuit
5V
5V C1
C1 100uF
100uF

Vin Vin

Vo
Vout 3.3V/1A Vout 2.5V/1A
R1
C2 121 C2
GND Adj
100uF R2 100uF
121
Tab is Vout Tab is Vout

( 5V/3.3V fixed output ) ( 5V/2.5V ADJ output )

R2
Note: Vo = VREF (1+ )
R1
AP9435M

Advanced Power P-CHANNEL ENHANCEMENT MODE


Electronics Corp. POWER MOSFET

Simple Drive Requirement D BVDSS -30V


D
Low On-resistance D RDS(ON) 50m
D
Fast Switching ID -5.3A
G
S
S
SO-8 S

Description D

The Advanced Power MOSFETs from APEC provide the


designer with the best combination of fast switching,
ruggedized device design, low on-resistance and cost-effectiveness. G
S
The SO-8 package is universally preferred for all commercial-industrial
surface mount applications and suited for low voltage applications
such as DC/DC converters.

Absolute Maximum Ratings


Symbol Parameter Rating Units
VDS Drain-Source Voltage -30 V
VGS Gate-Source Voltage 20 V
3
ID@TA=25 Continuous Drain Current -5.3 A
3
ID@TA=70 Continuous Drain Current -4.7 A
1
IDM Pulsed Drain Current -20 A
PD@TA=25 Total Power Dissipation 2.5 W
Linear Derating Factor 0.02 W/
TSTG Storage Temperature Range -55 to 150
TJ Operating Junction Temperature Range -55 to 150

Thermal Data
Symbol Parameter Value Unit
3
Rthj-amb Thermal Resistance Junction-ambient Max. 50 /W
November 1995

2N7000 / 2N7002 / NDS7002A


N-Channel Enhancement Mode Field Effect Transistor

General Description Features

These N-Channel enhancement mode field effect transistors High density cell design for low RDS(ON).
are produced using Fairchild's proprietary, high cell density, Voltage controlled small signal switch.
DMOS technology. These products have been designed to
minimize on-state resistance while provide rugged, reliable, Rugged and reliable.
and fast switching performance. They can be used in most
High saturation current capability.
applications requiring up to 400mA DC and can deliver
pulsed currents up to 2A. These products are particularly
suited for low voltage, low current applications such as small
servo motor control, power MOSFET gate drivers, and other
switching applications.

___________________________________________________________________________________________

G
D
G
S
TO-92 S
2N7000
(TO-236AB)
2N7002/NDS7002A

Absolute Maximum Ratings TA = 25C unless otherwise noted


Symbol Parameter 2N7000 2N7002 NDS7002A Units
VDSS Drain-Source Voltage 60 V
VDGR Drain-Gate Voltage (RGS < 1 M) 60 V

VGSS Gate-Source Voltage - Continuous 20 V

- Non Repetitive (tp < 50s) 40


ID Maximum Drain Current - Continuous 200 115 280 mA
- Pulsed 500 800 1500
PD Maximum Power Dissipation 400 200 300 mW
o
Derated above 25 C 3.2 1.6 2.4 mW/C
TJ,TSTG Operating and Storage Temperature Range -55 to 150 -65 to 150 C
TL Maximum Lead Temperature for Soldering 300 C
Purposes, 1/16" from Case for 10 Seconds
THERMAL CHARACTERISTICS

RJA Thermal Resistance, Junction-to-Ambient 312.5 625 417 C/W


Philips Semiconductors Product specification

2 6 W stereo power amplifier TDA1517; TDA1517P

FEATURES GENERAL DESCRIPTION


Requires very few external components The TDA1517 is an integrated class-B dual output
High output power amplifier in a plastic single in-line medium power package
with fin (SIL9MPF) and a plastic heat-dissipating dual
Fixed gain
in-line package (HDIP18). The device is primarily
Good ripple rejection developed for multi-media applications.
Mute/standby switch
AC and DC short-circuit safe to ground and VP
Thermally protected
Reverse polarity safe
Capability to handle high energy on outputs (VP = 0 V)
No switch-on/switch-off plop
Electrostatic discharge protection.

QUICK REFERENCE DATA

SYMBOL PARAMETER CONDITIONS MIN. TYP. MAX. UNIT


VP supply voltage 6.0 14.4 18.0 V
IORM repetitive peak output current 2.5 A
Iq(tot) total quiescent current 40 80 mA
Isb standby current 0.1 100 A
Isw switch-on current 40 A
|ZI| input impedance 50 k
Po output power RL = 4 ; THD = 0.5% 5 W
RL = 4 ; THD = 10% 6 W
SVRR supply voltage ripple rejection fi = 100 Hz to 10 kHz 48 dB
cs channel separation 40 dB
Gv closed loop voltage gain 19 20 21 dB
Vno(rms) noise output voltage (RMS value) 50 V
Tc crystal temperature 150 C

ORDERING INFORMATION

TYPE PACKAGE
NUMBER NAME DESCRIPTION VERSION
TDA1517 SIL9MPF plastic single in-line medium power package with fin; 9 leads SOT110-1
TDA1517P HDIP18 plastic heat-dissipating dual in-line package; 18 leads SOT398-1
Philips Semiconductors Product specification

2 6 W stereo power amplifier TDA1517; TDA1517P

PINNING

SYMBOL PIN DESCRIPTION


INV1 1 non-inverting input 1
SGND 2 signal ground
SVRR 3 supply voltage ripple rejection output
OUT1 4 output 1
PGND 5 power ground
OUT2 6 output 2
VP 7 supply voltage
M/SS 8 mute/standby switch input
INV2 9 non-inverting input 2

ndbook, halfpage ndbook, halfpage


INV1 1 INV1 1 18

SGND 2 SGND 2 17

SVRR 3 SVRR 3 16

OUT1 4 OUT1 4 15

PGND 5 TDA1517 PGND 5 TDA1517P 14

OUT2 6 OUT2 6 13

VP 7 VP 7 12

M/SS 8 M/SS 8 11

INV2 9 INV2 9 10

MLC352 MLC353

Pins 10 to 18 should be connected to GND or floating.

Fig.2 Pin configuration for SOT110-1. Fig.3 Pin configuration for SOT398-1.

FUNCTIONAL DESCRIPTION
The TDA1517 contains two identical amplifiers with
differential input stages. The gain of each amplifier is fixed
at 20 dB. A special feature of the device is the
mute/standby switch which has the following features:
Low standby current (<100 A)
Low mute/standby switching current
(low cost supply switch)
Mute condition.
2-wire Serial EEPROM 32K/64K
AF24BC32/64
FEATURES:
Internally organized as 4096 x 8 (32K),
8192 x 8 (64K) Self-timed write cycle (5ms max)
Low-voltage and standard-voltage Bi-directional data transfer protocol
operation : 1.8 to 5.5 V Write protect pin for hardware data
2-wire serial interface bus protection
Data retention: 100 years 32-byte page write modes
High endurance: 1,000,000 Write Allows for partial page writes
Cycles 8-lead PDIP, 8-lead JEDEC SOIC, and
100 kHz (1.8V) & 400kHz (2.7V, 5V) 8-lead TSSOP, 8-lead MSOP
compatibility (AF24BC32) Packages

DESCRIPTION

Aplus Flash Technologys AF24BC32/64 provides 32K/64K of serial electrically erasable and
programmable read-only memory (EEPROM). The wide Vdd range allows for low-voltage
operation down to 1.8V. The device, fabricated using traditional CMOS EEPROM technology, is
optimized for many industrial and commercial applications where low-voltage and low-power
operation is essential. The AF24BC32/64 is available in 8-pin PDIP, 8-lead JEDEC SOIC, 8-
lead TSSOP and 8-lead MSOP (AF24BC32) packages and is accessed via a 2-wire serial
interface.

Figure 1. Pin Configurations

8-pin PDIP/TSSOP/SOIC/MSOP

A0 1 8 Vcc Pin Name Function


A0 A2 Address inputs
A1 2 7 WP SDA Serial Data
SCL Serial Clock Input
A2 3 6 SCL WP Write Protect
GND Ground
GND 4 5 SDA Vcc Power Supply

.
LG Innotek Preliminary specification

Multi Media Tuner


Digital Half-NIM Tuner with Analog Demodulator TDTG-S122D/S172D

CHANNEL COVERAGE
Low band: 48.25 to 144.00MHz.
Mid band: 145.00 to 424.00MHz.
High band: 425.00 to 863.25MHz.

PIN DESCRIPTION
SYMBOL PIN DESCRIPTION
B1 1 Supply voltage +5V , for ANT . Do Not Connect.
B2 2 Supply voltage +5V , for Booster
B3 (VCC) 3 Supply voltage +5 V , for Tuner & IF Section
AGC 4 RF AGC output
N.C 5 Not connected
VTU 6 Tuning voltage
GND 7 Ground
N.C 8 Not connected
SCL 9 I2C bus serial clock
SDA 10 I2C bus serial data
IF 11 Tuner IF output
GND 12 Ground
N.C 13 Not connected.
2nd SIF 14 Second IF sound output
CVBS 15 Composite video base band signal output
Audio 16 AF sound output
N.C 17 Not connected
IF AGC 18 IF AGC input
DIF1 19 Digital IF output1
DIF2 20 Digital IF output2
Philips Semiconductors Product specification

Dual 4-channel analog multiplexer,


74HC4052; 74HCT4052
demultiplexer

FEATURES DESCRIPTION
Wide analog input voltage range from 5 V to +5 V The 74HC4052 and 74HCT4052 are high-speed Si-gate
Low ON-resistance: CMOS devices and are pin compatible with the
HEF4052B. They are specified in compliance with JEDEC
80 (typical) at VCC VEE = 4.5 V
standard no. 7A.
70 (typical) at VCC VEE = 6.0 V
The 74HC4052 and 74HCT4052 are dual 4-channel
60 (typical) at VCC VEE = 9.0 V analog multiplexers or demultiplexers with common select
Logic level translation: to enable 5 V logic to logic. Each multiplexer has four independent
communicate with 5 V analog signals inputs/outputs (pins nY0 to nY3) and a common
Typical break before make built in input/output (pin nZ). The common channel select logics
include two digital select inputs (pins S0 and S1) and an
Complies with JEDEC standard no. 7A
active LOW enable input (pin E). When pin E = LOW, one
ESD protection: of the four switches is selected (low-impedance ON-state)
HBM EIA/JESD22-A114-B exceeds 2000 V with pins S0 and S1. When pin E = HIGH, all switches are
in the high-impedance OFF-state, independent of pins S0
MM EIA/JESD22-A115-A exceeds 200 V.
and S1.
Specified from 40 C to +85 C and 40 C to +125 C.
VCC and GND are the supply voltage pins for the digital
control inputs (pins S0, S1, and E). The VCC to GND
APPLICATIONS ranges are 2.0 V to 10.0 V for 74HC4052 and
Analog multiplexing and demultiplexing 4.5 V to 5.5 V for 74HCT4052. The analog inputs/outputs
(pins nY0 to nY3 and nZ) can swing between VCC as a
Digital multiplexing and demultiplexing positive limit and VEE as a negative limit. VCC VEE may
Signal gating. not exceed 10.0 V.
For operation as a digital multiplexer/demultiplexer, VEE is
connected to GND (typically ground).

FUNCTION TABLE

INPUT(1)
CHANNEL BETWEEN
E S1 S0
L L L nY0 and nZ
L L H nY1 and nZ
L H L nY2 and nZ
L H H nY3 and nZ
H X X none

Note
1. H = HIGH voltage level
L = LOW voltage level
X = dont care.
Preliminary
SPV7100A

HIGHLY INTEGRATED LCD TV PROCESSOR

1.GENERAL DESCRIPTION
The SPV7100A is a highly integrated solution for the mainstream 2.3. 3D Video Decoder
LCD TV applications. The SPV7100A provides on-chip functions NTSC/PAL/SECAM video decoder
TM
including a high-speed triple-ADC and PLL, HDMI PanelLink 3D comb filter for NTSC, PAL I (B,G,H,D,N), PAL-M, PAL-N
Cinema receiver, TV decoder with 3-D comb filter, 4-pair Audio Enhanced NTSC/PAL/SECAM auto detection
Line-In, 2-pair Audio Line-Out, one SIF demodulator and audio 4 analog inputs and one analog video output
decoder, 3D motion adaptive de-interlacing, 2:2/3:2 film mode Cross-color reduction for NTSC by 3-line comb filtering
detection, video on graphic PIP/POP, SDRAM/DDR controller, Cross-color reduction for PAL by 5-line comb filtering
color management control, sRGB color management, Motion adaptive 3D Y/C separation comb filter for NTSC/PAL
bitmap-based and font-based OSD engine, embedded CPU and a system
dual channels LVDS transmitter. The chip could support LCD TV Multi-standard VBI data decoder, Teletext 2.5, WSS, VPS,
up to 1080P input resolution and 1080p output resolution. Closed-caption and V-chip
Macrovision detection
Note: PanelLink is the Trade Mark of Silicon Image Inc.
VBI data (C.C, TTX2.5, V-chip) overlay display

2. FEATURES
2.4. High Quality Video Processing
2.1. Graphics and Video Input Port
Enhanced Pixel-based 3D motion adaptive de-interlacing
Integrate 150MHz 10-bit ADC/PLL (SDTV/HDTV)
Dual CCIR656 digital video ports to support 2 input or 1 input/1 Enhanced 2:2/3:2 film mode detection
output Support Graphics mode frame rate conversion
Support SDTV at 480i/576i and 480p/576p Support Video mode frame rate conversion
Support HDTV at 720p and 1080i and1080p 2D Edge enhancement
Support PC graphics VGA, SVGA, XGA, WXGA, SXGA@75Hz Dynamic Peaking Filter
(135MHz) Enhanced Digital Luminance Transient Improvement (DLTI)
Build-in sync. processor for separate, composite or sync on Digital Color Transient Improvement (DCTI)
Y/G Black/White Level Expansion and Dynamic Contrast
Support Video/Graphics PIP/DW RGBYMC color adjustment
Channel swap for any source input Dark and Gray area UV Suppression
Image Format Detection/Auto Image Positioning/Auto Phase Enhanced 3D motion adaptive noise reduction
Detection De-blocking and de-mosquito filters
Full SCART support including RGB fast blank Color management/Color temperature adjustment
Brightness/Contrast/hue/Saturation adjustment
2.2. HDMI Support sRGB color correction
HDMI 1.2 compliant and DVI 1.0 compliant receiver Build-in three 256-point gamma tables with 10 bits resolution
HDCP 1.1 compliant receiver Color space conversion, both YCbCr to RGB and RGB to
Support DTV resolutions YCbCr
(480i/576i/480p/576p/720p/1080i/1080p) Build-in temporal/spatial color dithering
S/PDIF output supports PCM, Dolby Digital, DTS digital audio 10-bit video/image processing
with bypass mode
Four I2S audio outputs to SSD(Stereo Sound Decoder) with 2.5. High Quality Video Scaling Engine
bypass mode Advanced third-generation scaling engine
Auto audio error detection with programmable soft mute Support 4:3 / 16:9 with non-linear scaling
Build-in OTP for HDCP key Support Moir Canceling
Preliminary
SPV7100A

2.6. Multi-standard TV Sound Decoder MIPS-I instruction with DSP instruction set extension

Field proven TV sound decoder 2K bytes 2-way instruction cache

Support BTSC, A2/Zweiton, NICAM, EIAJ, SECAM, FM stereo 4K bytes direct-mapped data cache

Automatic TV-standard detection (ASD) 8K bytes data memory for DMA operation

Non-standard carrier compatible EJTAG interface

SAP decoding where applicable One UART up to 115200 baud rate

Auto fallback from NICAM where applicable Four 24-bit up/down timers
3K Bytes IMem for power saving mode

2.7. Embedded OSD and VBI Controller


2.11. Audio Processor
Build-in programmable OSD engine for two OSD windows (bit
map OSD) Support SPDIF input

1,2,4 and 8-bit per pixel (bit-map OSD) Support SPDIF output (signal could come from SPDIF input or

Support hardware cursor SSD)

Support programmable 512 font-based OSD and Support up to 8 channels I2S I/O

graphics-based OSD 4 channels audio DAC output

Support VBI decoder (CC,V-Chip and Teletext) 4 channels audio ADC input

Support VBI CC/TTX/Menu with more than 1000 char-fonts Channel: L, R, C, S, Sub, Aux1, 2 and 3 @ 32 kHz
5- band Equalizer

2.8. Embedded DDR/SDRAM Controller 3-D surround sound


Bass management
Integrated DDR/SDRAM controller with DLL (DDR)
Volume control
Support 32-bit DRAM bus with memory size from 16Mb (limited
Support sub-woofer output
functions) to 256Mb
Sample rate conversion
SSD could output up to 3 sources
2.9. Programmable Digital Output for LCD
Virtual Dolby Surround (VDSII 422 and 423) (support by
Support output sequence mapping for TI and Thine
SPV7100AxD)
Build-in dual channels 8-bit LVDS Tx or single channel 10-bit
SRS TruSurround (XT, WOW, 3D Sound) (support by SPV7100
LVDS Tx
AxS)
Support display output up to 1920x1200 @60Hz (165Mhz
WUXGA reduced blanking)
2.12. Misc
Support Power Down Sequence
Build-in TV remote control 1 infra-red receiver interface
4-ch PWM backlight intensity control
2-channels 6-bits ADC for key scan function
Build-in pattern generator for auto testing
2.10. CPU
256-pin LQFP for LCD application
Powerful 32-bit RISC CPU
Simple memory management stub (SMMU)

Sunplus Technology Co., Ltd. 5 MAR. 23, 2007


Proprietary & Confidential Preliminary Version: 0.1
SPV7100A

4.3. List of Packages and Pins


4.3.1. 256- LQFP Package

Figure 4-1 SPV7100A Pin Configuration


Part4: 5 4 3 2 1

Detailed Circuit +5VSB

V D D5_IN D 40

R 301
N C/ 1N5822 10k

L15 + 5V _DC S TB _CON

3
+ 5V _DC D 41 +5VSB 10uH/ 3A / DIP R 302 4. 7k
1 2 Q25
2 S TB _A C_ON

C 233
OFF

1
1N5822/ DIP 1 uF 2N3904
D D
S OT-23

5
U 20 R304 ON

D1

D1

D2

D2
DUA LMOS 3.3k GND GND
CN9 + 12V _IN L16 C 234
P OW E R/ CONNE CTOR 10uH/ 3A / DIP R303 E C46 0. 1uF R 308

G1

G2
3 1 1 2 C 235 0. 1uF 2 200uF/ 16v C 251

S1

S2
1 0R 68k
C N10 10nF

4
8 R 305 U 21 power_fb
7
8. 2K 1 8

3
6 BOOT PHASE
5 V D D5_IN E C47 E C48 Q26 C236 R 306
2 2 7
4 4 70uF/ 16v 4 7 0uF/ 16v DRIVE UGATE
3 4. 7nF 560
2N3904 power_fb 3 6

1
2 S TB _CON S OT-23 FB GND

2
1
4 5
NC 1N4148/ 1206 D 42 VCC LGATE
D-1206 DS 8110
R 307
10

1
C 252 S TB _A C_ON
1 uF S TB _A C_ON

P OW E R_ON
P OW E R_ON

+ 12V _IN + 12V _IN


+ 12V _IN < 6, 11,13>
+5V_SW
+5V_SW +5V_SW < 3, 4, 5, 6, 11,12,13>
+5VSB
+5VSB +5VSB <9,10>
C C

FOR SPV7100 ONLY 3.3V 1.8V 2.5V +3V3


+3V3
+3V3 < 3, 5, 7,8,9,10>

+1V8 +1V8
+2V5 +1V8 <9>
+5VSB
G N D < 3, 4, 5, 6, 8, 9, 10,11,12,13>
+5VSB
L1
UP2 1 0uH D2 C 10
3 + E C12 L-0805 1N4148/ 1206
D-1206 10nF +1V8
IN
1 2 1 2
C4 4 1 00uF/ 16v
0. 1uF
OUT 2
1 L3 22uH/ 3A / DIP
ADJ/GND

1
A P 1117-25/SOT-223 + C 13 G NDV GND_TMDS G N D_P W R
S OT-223 EC2 0. 1uF U1

BS
SW

IN

NC2

NC1
1 0 0uF/ 16v MP1411 R 50
CA P 100 11 10K
GND

COMP
GND

EN

SS
FB
+5VSB +3V3
+ D5 +
6

10
E C11 S K 34/SOP E C26 C 55
1 0 0uF/ 16v D-5819-1 4 7 0uF/ 16v 0. 1uF
C 54 3 UP4 CA P 100
IN A P 1084-3V3 + E C32 R 16
0. 1uF 4 TOP -263 5.1K
OUT 2 + 3. 3V Regulator 1 00uF/ 16v R 42
1 C 11 C6 C5 10K
A DJ 180pF 4700pF 0. 1uF

B B

+3V3 + 1V 8_A DCA

3 UP3
IN 1117-1.8 + E C30
4 2 TOP -263
OUT 1 0 0uF/ 16v
1
A DJ
C 42
0. 1uF

A A

WORLDPLUS
Title
System Power
Size Doc ument Number Rev
C
SZ04B_V1 1.0
Dat e: Tuesday, October 16, 2007 S heet 2 of 15
5 4 3 2 1
5 4 3 2 1

RXP 0 R XP 0 S CL_VGA S CL_VGA


RXM0 S DA _VGA
RXM0 S DA _VGA
RXP 1 VS_VGA
R XP 1 VS_VGA
RXM1 RXM1 HS _V GA HS _V GA
RXP 2
R XP 2
Layout Note EDID Defult: NOT write protect RXP 2 RXM2 RXP 1 RXM1 A S CL RXM2 H P D_P C
RXM2 H P D_P C
differential impedance 100ohm R XCP
R XCP
R XCM /WP
R XCM /WP
DM10 DM6 DM9 DM5
CN4
5 v_hdmi
INPUT1 E S D/ 0603 E S D/ 0603 E S D/ 0603 E S D/ 0603 DM11
20 E S D/ 0603 + 5V _DC + 5V _DC
SHELL1 + 5V _DC < 2, 4, 5, 6, 11,12,13>
21 1 RXP 2
SHELL2 D2+ B A T54/ SOT23 S OG_IN +3V3
2 D 13 S OG_IN +3V3 +3V3 < 2, 5, 7,8,9,10>
D2 Shield RXM2 GND_TMDS GND_TMDS GND_TMDS GND_TMDS
3
D2- 4 RXP 1 GND_TMDS B _IN
2 + 5V _DC B _ IN G N D < 2, 4, 5, 6, 8, 9, 10,11,12,13>
D1+ RXP 0 RXM0 R XCP R XCM ASDA G _ IN
5 3 G _ IN
D1 Shield 6 RXM1 1
D1- + 5V _HDMI_A
7 RXP 0 R_IN
D D0+ R_IN D
8 R 139 DM8 DM4 DM7 DM3 DM12
D0 Shield 9 RXM0 R 150 R151 N C/ 10K E S D/ 0603 E S D/ 0603 E S D/ 0603 E S D/ 0603 E S D/ 0603
D0- R XCP 47K 47K NC
10
CK+ 11 R 148
CK Shield 12 R XCM 1K U 14 24C02
CK- R163 NC C E C_HDMI GND_TMDS GND_TMDS GND_TMDS GND_TMDS +3V3
13 8 1
CE Remote 14 /WP 7 VCC A0 2 GND_TMDS
NC 15 A S CL 6 WP A1 3
DDC CLK ASDA SCK A2
16 5 4
DDC DATA + 5V _HDMI_A SDA VSS C E C_HDMI R 128
17 C E C_HDMI
GND
18 10K
+5V C104 0. 1uF
22 19
SHELL3 HPD R 149
23

GND_CA S E
SHELL4
HDMI CON-S MT GND_TMDS R 230
10K HDMI Input HOLD_FLA S H
HOLD_FLA S H

3
1K R 124 47K
IS P _TRAP 2 Q15
A H P D_IN 2N3904

1
GND_TMDS

1
Q20 JP2
R229
H P D_HDMI R228 100 1 JP 2/ 2. 54mm
7 H P D_HDMI GS O T 3 A H P D_IN H P D_HDMI R 123
H P D_HDMI

2
H D M I Plug C ontrol 2 23 D 100K
S
GND_TMDS 2N7002/ S OT-23 NC

GND_CA S E GND_TMDS GND_CA S E G N D _A DC GND_TMDS


ISP FROM VGA
G N D _A DC G N D_A DC

IS P _TRAP P C-B IN R 190 1 00R C115 B _IN

C
VGA Analog Input 0. 01uF
C

P C-GIN R 191 1 00R C116 G _ IN


0. 01uF

R 165 NC/ 47KH P D_P C

+5V_VGA G N D _A DC P C -RIN R 192 1 00R C117 R_IN

2
G N D_A
+ 5V _DC DC
+ 5V G N D _A
_DC DC
+ 5V _DC 0. 01uF
CN6 D 29
V GA / CON R238 R239 R240

1
G N D_A DC R 183 R 182 5. 6V / 1206 7 5R 7 5R 7 5R
10K 10K

1
S CL_V GA2 15 5
TP14 10 D 36 D 37 D 38
VS_VGA R166 3 3R 14 4 B A V 99L BAV99L B A V 99L G N D_A DC G N D_A DC
3

3
TP15 9
HS _V GA R181 3 3R 13 3 V GA _B IN P C-B IN
8
S DA _VGA2 12 2 V GA _GIN P C-GIN
7
2

C 130 C111 11 1 V GA _RIN P C -RIN


D 31 D 30 D 32 D 33 6
47pF 100pF V GA Con. PC DDC
5. 6V / 1206 5. 6V / 1206 5. 6V / 1206 5. 6V / 1206 DS UB 15P in-3/ Female + 5V _DC
D 17
G N D_A DC G N D _A DC 2 + 5V _DDC
1

3 +5V_VGA
16

17

1
G N D_A DC
B A T54/SOT23 + 5V _DDC
G N D_A DC G N D_A DC G N D_A DC R 207 R 227
2 2R G N D_A DC 10K 10K
R 222 + 5V _DDC
TXD
R 210 2 2R R XD U 18
2

1 8
2

D 35 C 139 A0 VCC
2 7
D 34 A1 WP S CL_V GA2 R208 3 3R S CL_VGA
B 3 6 B
5. 6V / 1206 1 uF A2 SCL S DA _VGA2 R209 3 3R S DA _VGA
4 5
5. 6V / 1206 GND SDA
1

G N D _A DC G N D_A DC 24C02
1

G N D _A DC D D C E DID Dat a
G N D_A DC S OP 8Pin

+3V3

R 310 R311
4. 7k 4.7k
R-0603 R-0603
Q27
A S CL 3 1 S CL_HDMI
2N7002
+3V3 S OT-23
2

A A
Q28
ASDA 3 1 S DA _HDMI
2N7002
S OT-23
2

+3V3

WORLDPLUS
Title

HDMI Switch
Size Doc ument Number Rev
C
SZ04B_V1 1.0
Dat e: Monday,August 20, 2007 S heet 3 of 15
5 4 3 2 1
5 4 3 2 1

C 138
R 216 P R 1 _IN
P R 1 _IN
1 00R 2 .2uF

C 120
R 194 P B 1 _IN
D
P B 1_IN D
1 00R 2 .2uF

C 118
R 193 Y 1 _ IN
Y 1 _ IN
1 00R 2 .2uF

R 225 R 215 R 214


7 5R 7 5R 7 5R

G ND V A OUT0L
S O G _IN S O G_IN
A OUT0R
S O Y2 _ IN S O Y2 _ IN
R 175 R 169
47K 4 7K
R 247 R 224
7 5R 2 .4K
C C

G ND V G ND V

Y Pr Pr CVBS
TP31
PCB EDGE PCB EDGE
10
11
12
7
8
9

C O N2 R CA-6P
AV_ VIN C VB S 2_IN C VB S 2_IN
L 11
7 8 9 10 11 12 C 161 1 . 8uH/0603 C 148 R 184

2
13 14 2 20pF 2 20pF 75 +5V_SW +5V_SW
<2,3,5,6,11,12,13> +5V_SW
D 28
1 2 3 4 5 6
5 .6V/1206 <2,3,5,6,8,9,10,11,12,13> G ND
G ND V
PCB Bottom View

1
G ND V
G ND V
1

G ND V

B D T V_ Y_ IN R 217 C 121 Y 2 _ IN B
Y 2 _ IN
AV_ VIN TP32 1 00R 0 .01uF

D T V_ Y_ IN TP33 R 218 C 119 S O Y1 _ IN


S O Y1 _ IN
0 1000PF

S C 2 _ A U_LIN TP34 D T V _Pb_IN R 195 C 122 P B 2 _IN


P B 2 _IN
1 00R 0 .01uF

D T V _Pb_IN TP35

S C 2 _ AU _RIN TP36
D T V_Pr_IN R 196 C 123 P R 2 _IN
P R 2 _IN
1 00R 0 .01uF
D T V_Pr_IN TP37
R 226 R 219 R 220 C 137
7 5R 7 5R 7 5R
NC / 10pF
G ND V
C-0603
3

B AV99L B AV99L B AV99L GND _ ADC


A OUT0L D 21 D 20 D 19 GND _ ADC
AOUT0L
AO UT0R A OUT0R
2

S C 2 _ A U_LIN R 245 10K AU_ AIN 2L AU_ AIN 2L AU_ AIN2L


+ 5V_DCGND _ ADC GND _ ADC S C 2 _ AU _RIN R 246 10K AU_ AIN 2R AU_ AIN 2R AU_ AIN2R
GND _ ADC + 5V_DC + 5V_DC

A R 235 A
R 234
6.8K
6 .8K

WORLDPLUS
Title

Input-2 Video
Size D oc um ent Num ber R ev
C us tom 1.0
SZ04B_V1
D ate: Sunday,August 19, 2007 Sheet 4 of 15
5 4 3 2 1
5 4 3 2 1

4053_5sw

4052 ch0:SC/SV/AV1
R203 R176 R385
47K 47K 47K 4052 ch1:YPrPr,AV2
PC Audio Input
D
CN7 AU_AIN1L C147 2.2uF 4052 ch2:PC 4052-->SPV7100 :CH2 D

5 R236 10K AIN0L


4
3 AIN0L C275 2.2uF 4052 ch3:TV MONO DVB-->SPV7100 :CH3
2 R237 10K A IN0R
1
AU_AIN1R C152 2.2uF
PHONE R231
Stereo Audio In R232 6.8K 4053_5sw
6.8K R386
R212 R170 47K
47K 47K (to SPV7100
& SCART-2)
R177 R202 R387 R389
47K 47K 47K 47K U17 4053_5sw
5 2
1 3 4 VCC
16
C C
R-Pho L-Pho 12
L-Out R-Out AU_AIN2L C159 2.2uF 1Y0 AIN2L
14 13
1Y1 1Z
Stereo Audio Connector 15
1Y2
MONO_IN C277 2.2uF 11
Top Diagram 1Y3
1
AU_AIN2R C160 2.2uF 2Y0 A IN2R
5 3
2Y1 2Z
2
2Y2
4
A IN0R C276 2.2uF 2Y3
AU_SW0 10
AU_SW1 S0
9 7
R110 10K AIN3L S1 VEE
DVB_AL_OUT 4052_EN 6 8
IE GND

DVB_AR_OUT R94 10K A IN3R R171 R185 R388 R390 74HC4052


47K 47K 47K 47K
B B

R107 R109
6.8K 6.8K

GNDV

+5V_SW +5V_SW
<2,3,4,6,11,12,13> +5V_SW
AIN2L AIN2L
CVBS1_IN CVBS1_IN CVBS_TV CVBS_TV A IN2R AIN2R +3V3 +3V3
<2,3,7,8,9,10> +3V3

AU_SW0 AIN3L
AU_SW0 AIN3L <2,3,4,6,8,9,10,11,12,13> GND
C 2_IN C2_IN AU_SW1 AU_SW1 A IN3R AIN3R

AIN0L AIN0L
A A IN0R AIN0R
AU_AIN1L AU_AIN1L
WORLDPLUS A

AU_AIN1R AU_AIN1R Title


AU_AIN2L
AU_AIN2R
AU_AIN2L
AU_AIN2R
Input-3 Audio and DTV
Size Document Number R ev
Custom 1.0
SZ04B_V1
Date: Sunday, August 19, 2007 Sheet 5 of 15
5 4 3 2 1
5 4 3 2 1

S C1_AU_LIN R242 10K AU_AIN1L


SC1 _AU_RIN R243 10K AU_AIN1R
J7
7
8 6 CVBS
D
9 D
SVIDEO+RCA

2
10 5 R244 R233
D23 D24 6.8K 6.8K

4
3

2
1
GNDV 5.6V/1206 5.6V/1206

1
CVBS1_IN CVBS1_IN
CVBS1_IN
C2_ IN C2_ IN C2_IN
GNDV GNDV

R200

75R R201
75R
+5V_SW +5V_SW
<2,3,4,5,11,12,13> +5V_SW
C C
C155

<2,3,4,5,8,9,10,11,12,13> G ND
GNDV GNDV
10pF
CVBS0_IN CVBS0_IN
2

L10
D22 C156 1.8uH/0603 C154 R197
100pF 100pF 75R

5.6V/1206
1

GNDV

GNDV
B B

A
WORLDPLUS A

Title
Input-2 Video
Size Document Number R ev
A
SZ04B_V1 1.0
Date: Sunday, August 19, 2007 Sheet 6 of 15
5 4 3 2 1
5 4 3 2 1

U2

7 MD[0..15]
MD[0..15] SDRAM Data Bus +2V5_MC
MD8
1
2
VDD VSS
66
65 MD0
DQ0 DQ15
+2V5 3 64
MD9 VDDQ VSSQ MD1
4 63
MA[0..11] MD10 DQ1 DQ14 MD2
7 MA[0..11] 5 62
DQ2 DQ13
6 61 +2V5
BA0 MD11 VSSQ VDDQ MD3
7 BA0 7 60
D
BA1 MD12 DQ3 DQ12 MD4 D
7 BA1 8 59
DQ4 DQ11 +2V5
+2V5 9 58
MD13 VDDQ VSSQ MD5
10 57
W EN MD14 DQ5 DQ10 MD6

These components close to DDR


7 W EN 11 56
CA SN DQ6 DQ9
7 CASN 12 55 +2V5
RA SN MD15 VSSQ VDDQ MD7
7 RASN 13 54
DQ7 DQ8 R250 C169
14 53
NC NC 0.1uF
+2V5 15 52
CKE DQ S0H VDDQ VSSQ DQS0L r efre 4.7K NC
7 CKE 16 51
S DCLKP LDQS UDQS
7 SDCLKP 17 50
SDCLKN NC NC
7 SDCLKN +2V5_MC 18 49
VDD VREF
19 48
DQS0L DQM0H NC VSS DQM0L
7 DQS0L 20 47
DQ S0H W EN LDM UDM MCLKN R252 C171
7 DQS0H 21 46
CA SN WE CK MCLKP 0.1uF
22 45
DQM0L RA SN CAS CK CK ER 4.7K
7 DQM0L 23 44
DQM0H R256 C SN RAS CKE
7 DQM0H 24
CS NC
43 *add
C 0 25 42 R261 NC C
BA0 NC NC/A12 MA11
26 41
GNDM BA1 BA0 A11 MA9 GNDM
27 40
R257 22K MA10 BA1 A9 MA8 GNDM
+2V5_MC 28 39
MA0 AP/A10 A8 MA7
29 38
MA1 A0 A7 MA6
30 37
CKE R38 10R CK ER MA2 A1 A6 MA5
31 36
MA3 A2 A5 MA4
32 35
A3 A4
+2V5_MC 33 34
R76 47 VDD VSS
r efre
HY5DU281622FTP-5(8Mx16 DDR)
GNDM GNDM
S DCLKP R70 10R MCLKP
All traces must have the same length
HY5DU281622ETP(128Mb/2Mx16x4B)
B B

R75 47 r efre GNDM

SDCLKN R68 10R MCLKN

*Short these ground planes on PCB


GNDM

+2V5 +2V5_MC

A
C166 C168 C165 C167 C26 C22 C170 C164 WORLDPLUS A

Title
0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 10uF/10v1000pF 0.1uF
DDR PART
Size Document Number R ev

GNDM GNDM
A
SZ04B_V1 1.0
Date: Sunday, August 19, 2007 Sheet 7 of 15
5 4 3 2 1
5 4 3 2 1

S1 S2 SPREAD DIRECTION SPREAD PERCENTAGE TX0M0


Crystal Circuit 0 0 CENTER +/-1.4 IO Trap TX0P0
TX0M0
TX0P0
0 M CENTER +/-1.1 TX0M1 TX0M1
0 1 CENTER +/-0.6 TX0P1
M 0 CENTER +/-0.5 TX0P1
TX0M2
TX0M2
C L K IN M M NO SPREAD - <Trap0> S CK _FLA SH TP9 TX0P2
TX0P2
M 1 DOWN -1.6 (Pin-201) TXCLK0M
X1 1 0 DOWN -2.0 + 3V 3_LVDS + CV DD TXCLK0M
TXCLK 0P
R 135 2 2R C LK OUT 1
1
M
1
DOWN
DOWN
-0.7
-3.0
Memory I/O <Trap1> CE N_FLA S H
(Pin-200)
TP 10 TX0M3
TX0P3
TXCLK0P
TX0M3
TX0P3

DQS0H
DQM0H
27MHz / DIP HOLD_FLA S H TP 11 TX1M0
<Trap2>
X'TAL
+ 5V _DDC
+ 3V 3_LVDS
LVDS Output + CV DD
(Pin-202) TX1P0
TX1M1
TX1M0
TX1P0
TX1M1

R251
R 267 1M <Trap3> H P D_HDMI TP 12 TX1P1
TX1P1

TXCLK0M

TXCLK1M
TXCLK0P

TXCLK1P

SDCLKN
(Pin-214) TX1M2
TX1M2

DQM0L
DQS0L

R254
TX0P0

TX0P1

TX0P2

TX0P3

TX1P0

TX1P1

TX1P2

TX1P3
TX0M0

TX0M1

TX0M2

TX0M3

TX1M0

TX1M1

TX1M2

TX1M3
C190 C191 R 164 10K IS P _DET 1 0R TX1P2

SDCLKP

CASN
RASN
MD10
MD11
MD12
MD13
MD14
MD15
TX1P2

WEN
D D

MD0
MD1
MD2
MD3
MD4
MD5
MD6
MD7

MD8
MD9
G NDP +1V25 + MV DD S P DIFO TP 13 TXCLK1M
<Trap4> TXCLK1M

CKE
15pF 15pF H P D_P C 2 Q1 (Pin-205) TXCLK 1P
TXCLK1P
N C/ 2N3904 1 0R TX1M3 TX1M3
TX1P3
TX1P3

1
U10A <Trap5> CKE R 37 4.7K
These components close to SPV7100 G NDM (Pin-164) HOLD_FLA S H

192
191
190
189
188
187
186
185
184
183
182
181
180
179
178
177
176
175
174
173
172
171
170
169
168
167
166
165
164
163
162
161
160
159
158
157
156
155
154
153
152
151
150
149
148
147
146
145
144
143
142
141
140
139
138
137
136
135
134
133
132
131
130
129
H OLD_FLA S H
G NDM
C 241 C242 CKE
CKE <7>
RE S E TN C-0603 C-0603 S DCLK P

TXCLK0M

TXCLK1M
UART_RX
AVSS33_LVDS
AVDD33_LVDS

TXCLK0P

AVSS33_LVDS
AVDD33_LVDS

TXCLK1P

PVSS33_LVDS
PVDD33_LVDS

CKE
CLKP
CLKN

DQS0H
DQM0H
WEN
CASN
RASN
TX0M[0]
TX0P[0]
TX0M[1]
TX0P[1]
TX0M[2]
TX0P[2]

TX0M[3]
TX0P[3]

TX1M[0]
TX1P[0]
TX1M[1]
TX1P[1]
TX1M[2]
TX1P[2]

TX1M[3]
TX1P[3]

MD[0]
MD[1]
MD[2]
MD[3]
MD[4]
MD[5]
MD[6]
MD[7]

MD[8]
MD[9]
MD[10]
MD[11]
MD[12]
MD[13]
MD[14]
MD[15]
DVDD18

DQM0L
DQS0L
SVDD25
SVSS25

SVDD25
SVSS25

SVDD25
SVSS25

DVDD18
DVSS18
VSSR_0
VREF_0
RE S E TN S DCLKP <7>
C E C_HDMI
C E C_HDMI 56pF 56pF Pin 87 98 11 6126139149159DDR2.5V

MPU & SPI


R XD R XD MD[ 0. . 15]
R XD MD[ 0. . 15] <7>
T XD C 63 T XD 193 128 BA0
TXD
C-0603 RE S E TN 194
UART_TX BA0
127 BA1 DDR VREF W EN

Memory I/O
RESETN BA1 WEN <7>
I R_DA T 22pF C E C_HDMI 195 126 C ASN
I R_DA T PWM3/EXINT1 SVDD25 +1V25 + MV DD C A S N <7>
B L_A DJ 196 125 R ASN R A S N <7>
S D1_FLA SH I R_DA T PWM2/WP_FLASH SVSS25 MA10
S D1_FLA SH 197 124
S D0_FLA SH S D1_FLA SH R 93 3 3R IR_DAT MA[10] MA0 MA [ 0..11]
S D0_FLA SH 198 123 MA [ 0. .11] <7>
CE N_FLA S H S D0_FLA SH R 98 3 3R SD1_FLASH MA[0] MA1 FB 30
CE N_FLA S H 199 122
S CK _FLA SH CE N_FLA S H SD0_FLASH MA[1] MA2 BA0
S CK _FLASH 200 121 BA0 <7>
S TB _A C_ON S CK _FLA SH R 113 3 3R CEN_FLASH MA[2] MA3 R 260 BA1
S TB _A C_ON 201 120 BA1 <7>
HOLD_FLA S H SCK_FLASH MA[3] MA4
202 119
HOLD_FLASH MA[4] MA5 120/ 100M 4. 7K
203 118
TESTMODE MA[5] MA6
204 117
S P DIFO DVSS33 MA[6]
205 116
P A NE L_ON I2SDA3/SPDIFO SVDD25
206 115
I2SDA2/SPDIFI SVSS25 MA7 DQM0H
207 114
EJTAG I/F

I2SMCLKA/JCLK MA[7] DQM0H <7>


208 113 MA8 R 259 C172 D QS 0H
+ DV DD L E D_C I2SDA1/JTMS MA[8] + 1V 8_DLLVDD D QS 0H <7>
/WP 209 112 MA9 DQM0L
I2SDA0/JTDO MA[9] DQM0L <7>
210 111 MA11 4. 7K 0. 1uF DQS 0L
DVDD33 MA[11] + 3V 3_MPLL DQS 0L <7>
211 110 NC
+ CV DD S TB _A C_ON I2SCLKA/JTDI DLLVSS18 S DCLK N
212 109 S DCLK N<7>
I2SWSA/JRSTN DLLVDD18
213 108
H P D_HDMI DVDD18 MPLLVDD33
214 107
S DA _VGA HPD_HDMI MPLLVSS33 G NDM
215 106
C243 C244 S CL_VGA SDA_VGA VSSR_1
216 105
C-0603 C-0603 S DA _HDMI SCL_VGA VREF_1
217 104
C S DA _VGA 56pF 56pF S CL_HDMI SDA_HDMI GPIO/DQM1L R265 C
218 103
S DA _VGA
S CL_V GA
S CL_VGA 219
SCL_HDMI GPIO/DQS1L
102
Default Pull Setting
S DA _HDMI PWM1//EXINT2 I2SWSB/MD[16] 4.7K
S DA _HDMI 220 101
S CL_HDMI PWM0 I2SCKB/MD[17] +3V3 +3V3
S CL_HDMI 221 100
DPLLVSS33 I2SDB0/MD[18] + S V DD
222 99
+ 3V 3_XTAL DPLLVDD33 I2SDB1/MD[19] +3V3
223 S P V 7100-LQFP256 98
AVDD33_REG SVDD
224 97
C L K IN 225 AVDD33_XTL SVSS 96 R100 R 129
C LK OUT XTALI I2SMCLKB/MD[20] 10K NC
226 95
+ 1V 8_A UD 227 XTALO I2SDB2/MD[21] 94 R 324
R XCM
R XCP
R XCM
R XCP
+ 3V 3_TMDS 228
229
PVSS18_AUD
PVDD18_AUD CAFE I2SDB3/MD[22]
PWM2/MD[23]
93
92
+ CV DD 10K
B L_ON MUTE_AMP
RXM0 PVSS33_TMDS DVDD18
RXM0 230 91 R 339 I2C_S W
PVDD33_TMDS VDO[0]/MD[24]
HDMI Input

RXP 0 231 90 B L_ON


RXP 0 AVDD33_TMDS VDO[1]/MD[25] R 338
RXM1 R XCM 232 89 1K 1K P OW E R_ON
RXM1 RXCM VDO[2]/MD[26]
RXP 1 RXP 1 R XCP 233 88 MUTE_AMP C 73
RXM2 RXCP VDO[3]/MD[27] C-0603
RXM2 234 87
RXP 2 235 AVSS33_TMDS SVDD 86 22pF
RXP 2 AVDD33_TMDS SVSS
RXM0 236 85
RXP 0 RXM[0] VDO[4]/MD[28]
237 84
238 RXP[0] VDO[5]/MD[29] 83
AVSS33_TMDS VDO[6]/MD[30]
239 82
AVDD33_TMDS VDO[7]/MD[31] R 354
HS _V GA RXM1 240 81 1K
HS _VGA RXM[1] VCLKO/DQS1H + DV DD
+ CV DD
VS_VGA RXP 1 241 80 4052_EN
VS_VGA RXP[1] GPIO/DQM1H 4052_EN
242 79 /WP
AVSS33_TMDS DVDD18 /WP
B _IN B _IN 243 78
G _ IN RXM2 AVDD33_TMDS DVSS
G _ IN 244 77
S OG_IN RXP 2 RXM[2] DVDD33 RN5 C C I R656-D0 P A NE L_ON
S OG_IN *change value 245
RXP[2] VD[0]
76 8 7 P A NE L_ON
R_IN R_IN 246 75 6 5 150/P C C I R656-D1 P OW E R_ON P OW E R_ON
+ 3V 3_ADCP + CV DD AVSS33_TMDS VD[1] RA -S MD-Y C16B C C I R656-D2 B L_A DJ
247 74 4 3 B L_A DJ
Y 1 _IN 248 DVSS18_TMDS VD[2] 73 C C I R656-D3 B L_ON
Y 1 _IN 2 1 B L_ON
S OY 1_IN DVDD18_TMDS VD[3] RN7 C C I R656-D4
S OY 1_IN 249 72 8 7
P B 1_IN C 106 390pF F ILT PVDD33_ADC VD[4] 150/P C C I R656-D5 MUTE_AMP
P B 1_IN 250 71 6 5 MUTE_AMP
P R1_IN FILT VD[5] RA -S MD-Y C16B C C I R656-D6
P R1_IN 251 70 4 3
PVSS33_ADC VD[6] C C I R656-D7
252 69 2 1
Y 2 _IN IS P _DET HSYNC1 VD[7] C C IR656-CLK
Y 2 _IN 253 68
S OY 2_IN C 108 R 153 HS _V GA VSYNC1 VCLK S CL_M
254 67

CLK24N/EXINT0
S OY 2_IN HSYNC0 SCL_M
P B 2_IN 0. 082uF 5.6K VS_VGA 255 66 SDA_M

AVDD33_AUO
AVDD18_ADC

AVDD18_ADC

AVDD18_ADC

BVDD33_ADC
AVDD18_ADC

AVDD33_SAR

AVSS33_AUO
AVSS33_AUO
P B 2_IN
AVSS18_ADC

AVSS18_ADC

AVSS18_ADC
BVSS33_ADC

AVSS18_ADC

AVSS33_SAR
B VSYNC0 SDA_M B

AVDD33_AUI

AVDD33_SIF
AVSS33_AUI
AVSS33_SIF
P R2_IN P R2_IN MIDS CV 256 65 C 107
MIDSCV DVDD18

VCM_AUO
CVBSOUT
These components close to SPV7100 C 248

VCM_AUI

VCM_SIF
VRN_SIF
VRP_SIF

AOUT0R

AOUT1R
DVDD18

AOUT0L

AOUT1L
DVSS18

CLK24P
SIFAIN0
SIFAIN1
SARIN0
SARIN1
N C/ 10pF
CVBS0

CVBS1

CVBS2
CVBS3

AIN0R

AIN1R

AIN2R

AIN3R
AIN0L

AIN1L

AIN2L

AIN3L
SOY1

SOY2

CV B S 0_IN 5P C-0603 H P D_HDMI


SOG

VCM

CV B S 0_IN H P D_HDMI
PR1

PR2
PB1

PB2
GIN

RIN
BIN

CV B S 1_IN GND_TMDS C-0603


C1

C2
Y1

Y2

CV B S 1_IN
CV B S 2_IN H P D_P C
CV B S 2_IN H P D_P C
CV B S 3_IN
CV B S 3_IN
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
G N D _A DC S CL_M
+ 1V 8_ADCA SCL_M
SDA_M
SDA_M
C 2 _IN

VCM_AUO
C 2 _IN

V R N _SIF
VCM_AUI

V R P _SIF
VCM_SIF

AUO_0R

AUO_1R
A U_S W0

AUO_0L

AUO_1L
A U_S W0
G ND_A UO A U_S W1
A U_S W1
SOY2_IN
SOY1_IN

2.2uF

2.2uF
2.2uF
2.2uF
2.2uF

S A RIN0 MIDS CV VCM


Y1_IN
SOG_IN

PR1_IN

PR2_IN

S A RIN0
PB1_IN

PB2_IN

C140 2.2uF
2.2uF
C133 2.2uF
2.2uF
C134 2.2uF
2.2uF
C 112 C 212
Y2_IN
G_IN

R_IN
B_IN

VCM

180R
180R

180R
180R
0.1uF
0.1uF
0.1uF
A OUT0L
A OUT0L

1K
1 uF 1uF A OUT0R A OUT0R
C124

C125

C131

C-0603 A OUT1L
A OUT1L

56pF
C217

C219

R279
R174
R168

R160
R161
G N D _A DC G N D_A DC A OUT1R A OUT1R
C141

C127

C128
C126

CVBS3_IN C132

C CIR656-D[ 0. . 7]
SARIN0

C CIR656-D[ 0. . 7]
C218

C136
A IN2L V CM_A UI V CM_A UO
A IN2L
A I N2R C C IR656-CLK
CVBS0_IN

CVBS1_IN

CVBS2_IN

A I N2R C C IR656-CLK

AU_SW0
AU_SW1
AIN2R

AIN3R

AOUT0R

AOUT1R
C 227 + E C40 C 109 + E C41 * change C200-203 nets

AOUT1L
AIN2L

AIN3L

AOUT0L
A IN3L
C2_IN

A IN3L
A I N3R A I N3R 0. 1uF 1 0 u F/ 16v 0. 1uF 1 0 uF/ 16v
S I FAIN0

C-0603 CA P 10 C-0603 CA P 10
S IFA IN0 S IFA IN0 + 3V 3_ADCB + CV DD + 3V 3_AUO + 3V 3_AUO + 3V 3_AUO + 3V 3_AUO
G N D_A UO
G ND_A UO G N D_A DCGND_TMDS G N DP G ND_A UO G NDM

VGA/YUV Input Video Input Audio Input Audio Output *Short these ground planes on PCB

A A

WORLDPLUS
Title
SPV7100 Part-1
Size Doc ument Number Rev
C
SZ04B_V1 1.0
Dat e: Tuesday,October16,2007 S heet 8 of 15
5 4 3 2 1
5 4 3 2 1

+3V3 +3V3
PLL POWER/GND (3.3V/1.8V)
<2,3,5,7,8,10> +3V3 +3V3 +3V3_MPLL

<2> +1V8
+1V8 +1V8 TMDS AUD PLL POWER/GND (1.8V) XTAL POWER/GND (3.3V) FB16

120/100M
+1V8 +1V8_AUD
<2,3,4,5,6,8,10,11,12,13> G ND
+ EC31 C80
FB18
+3V3 +3V3_XTAL 10uF /16v 0.1uF
120/100M FB14
CAP10
D C197 C87 120/100M D
C84 C85
1uF 0.1uF + EC27
1uF 0.1uF
10uF /16v

CAP10

Ferrite Beed Spec:


ADC POWER/GND (1.8V/3.3V) FB : Rdc=0.2 , Z=300/100MHz , Idc=500mA ~ MCB2012S301H Power Plane : +5V, +5VSB, +3V3, +3V3_SPV
FB_L : Rdc=0.015 , Z=120/100MHz , Idc=6000mA ~ MHC3216S121W ,+3V3_MC, +2V5,+1V8, +VCC_PNL,+AVDD_ADC +1V8 +1V8_DLLVDD
+1V8_ADCA FB_S : Rdc=0.35 , Z=75/100MHz , Idc=300mA ~ MCB1608U750F FB17
Power Line : +12V, +3V3_ADCP , +3V3_ADCB,
P in1 P in7 P in14 P in22 120/100M
+3V3_MPLL , +3V3_DPLL , +1V8_DLLVDD,
+1V8_TMDSP, +1V8_TMDS, +1V8_AUD + EC28 C81
+ EC37 C211 C213 C82 C215
10uF /16v 0.1uF
10uF /16v 56pF 56pF 0.1uF 56pF Ground Plane: GND, GND_ADC, GND_TMDS,
G ND _ADC G ND _AUO G ND M G NDP GND_T MDS CAP10
CAP10 GNDV, GNDM, GNDP, ND_LVDS,
*Short these ground planes on PCB GND_AUO, GND_AMP
G ND _ADC

+3V3_ADCP
+3V3 FB24
C C
120/100M
+ EC39 C105 TMDS POWER/GND (1.8V/3.3V) LVDS POWER/GND (3.3V)
10uF /16v 0.1uF

CAP10 +3V3 +3V3_LVDS


P in231 P in235 P in239 P in243 FB9
G ND_ADC
120/100M
+3V3 +3V3_TMDS C33 C173 C41
FB21
+3V3_ADCB 10uF /10V 0.1uF 0.1uF
FB25 120/100M
+ EC33 C201 C204 C206
120/100M G NDP
+ EC38 C214 10uF /16v 0.1uF 0.1uF 0.1uF

10uF /16v 56pF CAP10

CAP10
GND_T MDS
G ND_ADC

SPV7100 E-Pad
U10B
257 298
B EPad EPad B
258 299
EPad EPad
259 300
SOURCE POWER/GND (1.8V/2.5V/3.3V) SARADC/SIF/AUDIO POWER/GND (3.3V) 260
261
EPad
EPad
EPad
EPad
301
302
EPad EPad
262 303
EPad EPad
263 304
+1V8 + CVDD EPad EPad
264 305
FB19 EPad EPad
P in32 P in65 P in79 P in92 P in132 P in165 P in213 265
EPad EPad
306
266 307
120/100M EPad EPad
267 308
C89 C174 C198 C216 C207 C178 C184 C209 C208 EPad EPad
268 309
EPad EPad
269 310
10uF /10V 0.1uF 0.1uF 56pF 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF EPad EPad
270 311
EPad EPad
+3V3
271 312
EPad EPad
272 313
+3V3_AUO EPad EPad
273 314
FB26 EPad EPad
274 315
EPad EPad
275 316
120/100M EPad EPad
276 317
+2V5 + MVDD EPad EPad
+ EC42 C110 C224 277
EPad EPad
318
FB10 P in116 P in126 P in139 P in149 P in159 278 319
10uF /16v 0.1uF 0.1uF EPad EPad
279 320
120/100M EPad EPad
280 321
EPad EPad
+ EC29 C175 C179 C177 C176 C180 CAP10 281 322
Epad EPad
282 323
10uF /16v 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF EPad EPad
283 324
G ND _AUO EPad EPad
284 325
CAP10 EPad EPad
285 326
G NDM + S VDD EPad EPad
286 327
EPad EPad
+3V3
287 328
EPad EPad
+ DVDD
288 329
FB22 EPad EPad
P in77 289
EPad EPad
330
A +3V3 C86 290 331 A
120/100M FB15 EPad EPad
291 332
EPad EPad
+ EC34 C182 C102 0.1uF 292 333
120/100M EPad EPad
293 334
10uF /16v 0.1uF 0.1uF EPad EPad
*add 294
EPad EPad
335
295 336
CAP10 EPad EPad
296 337
297
EPad
EPad E-Pad
EPad
WORLDPLUS
SPV7100A-LQFP256 T itle

SPV7100 Part-2
Size Document Number Rev
C u stom
SZ04B_V1 1 .0
Date: Sunday, August 19, 2007 Sheet 9 of 15
5 4 3 2 1

PDF "pdfFactory Pro" www.fineprint.cn


5 4 3 2 1

Hardware Reset
+3V3
+3V3
D D
R344
10K

1
SARIN0 KPD0

2
J9 R253
C249 R345 1 10K D9
0.1uF 1 CH + R-0603
1.2K 2 1N4148/1206
2 CH -
3

2
KPD1 3 SEL D-1206
4

1
4 MENU
5
R346 5 V + RESETN
6
6 V -
2K 7
KPD2 7 MUTE
8
8

1
9 GND
9 GREEN + EC21
10
R347 10 RED 10uF/16V
11
2.4K 11 POWER CAP10
12

2
12 GND
13
KPD3 13 REMOTE
14
14 5V
R348 CON14-2.0
3.6K
C
+5VSB Flash Interface C

R343 47 FB12
KPD4 120/100M
R49 +3V3L-0603
R349 10K 1 2 +3V3_FLASH
6.2K EEPROM +3V3
1

KPD5 IR IR_DAT
+ EC53 C53 +3V3
R350 10uF/16V R101 R97 R102 R255
11K CAP10 10K 10K 10K 0.1uF 10K R158 R154
2

R92 U15 4.7K 4.7K


U7 10K 1 8
CEN_FLASH C90 A0 VCC
1 8 2 7
R351 SD0_FLASH CE# VDD HOLD# A1 WP SCL_M
2 7 3 6
WP# 3 SO HOLD# SCK_FLASH 0.1uF A2 SCL SDA_M
NC 6 4 5
WP# SCK SD1_FLASH GND SDA
4 5
+5VSB GND SI 24C32
NC/EN25T80/SOP <Assembly> SOP8
SOP8\300mil

R341
1K R392
RS-232 Interface +5V_DC
B 1K +3V3_FLASH B

1
U6 R58 R57
RED-LED CEN_FLASH 1 8 10K 10K
R342 4.7K SD0_FLASH CE# VDD HOLD# R-0603 R-0603
2 7
Q36 WP# SO HOLD# SCK_FLASH
3 6

2
LED_C WP# WP# SCK 1
2N3904 4 5 SD1_FLASH TXD
GND SI 2 TXD
Q8 GREEN-LED RXD
3 RXD
R391 4.7K 2N3906 EN25T80/DIP <Assembly>
4
1

DIP8
2 J6
C ON4/2.0mm
GPROBE
3

SARIN0
SARIN0
RESETN
RESETN
+5VSB +5VSB
<2,9> +5VSB

<2,3,4,5,6,8,9,11,12,13> G ND
A A
SCL_M SCL_M
SDA_M SDA_M
SD0_FLASH SD0_FLASH
SD1_FLASH
WORLDPLUS
SD1_FLASH
Title
SCK_FLASH
SCK_FLASH
CEN_FLASH CEN_FLASH MCU Interface
Size Document Number R ev
IR_DAT B 1.0
IR_DAT SZ04B_V1
D ate: Sunday, August 19, 2007 Sheet 10 of 15
5 4 3 2 1
5 4 3 2 1

+5V_DC +VCC_PNL R44


NC/10K

+12V_IN

1 2
D
R7 1 2 D
J1 3 4
10K R10 3 4
GNDP 5 6 GNDP
TX0M0 5 6 TX0P0
1K 6
+12V TX0M0 7
7 8
8 TX0P0 ODD
TX0M1 9 10 TX0P1 (1st pixel)
TX0M1 9 10 TX0P1
R5 5 TX0M2 11 12 TX0P2
+12V TX0M2 11 12 TX0P2
3

4.7K GNDP 13 14 GNDP


BL_ADJ Q2 C3 TXCLK0M
R33 33R 13 14 R34 33R TXCLK0P
2 4 TXCLK0M 15 16 TXCLK0P
2N3904 BL_ON TX0M3 15 16 TX0P3
TX0M3 17 18 TX0P3
TX1M0 17 18 TX1P0
2.2uF 3 TX1M0 19 20 TX1P0 EVEN
1

ADJ TX1M1 19 20 TX1P1


TX1M1 21
21 22
22 TX1P1 (2nd pixel)
C-0603 2 TX1M2 23 24 TX1P2
GND TX1M2 23 24 TX1P2
GNDP 25 26 GNDP
R6 TXCLK1M
R35 33R 25 26 R36 33R TXCLK1P
C151 = 1uF ~ 10uF 1 TXCLK1M 27 28 TXCLK1P
NC R325 +5V_DC GND TX1M3 27 28 TX1P3
TX1M3 29 30 TX1P3
10K 29 30
HEADER6-2.0 J5
15x2PIN/2.0mm
C C
R60
10K

R326 +5V_DC JP1 +3V3

1
2
3
10K SIP3/2.54

R320
3

R321 2 Q9 +12V_IN
10K 2N3904 L2
3

10K +3V3 EC50 NC


1

BL_ON 2 Q31 R61


2N3904
10K Q11
1

R46 100uF/16V NDS9435A/SO


2

4.7K

4
3
2
1
3

B B
R80
PANEL_ON 1 2 2 Q13
2N3904
4.7K +VCC_PNL
1

+12V_IN
+12V_IN
5
6
7
8

<2,6,13> +12V_IN
R69
+5V_SW +5V_SW 75R C16
<2,3,4,5,6,12,13> +5V_SW
0.1uF
EC17
100uF/16V
<2,3,4,5,6,8,9,10,12,13> GND
GNDP

G1 G2 GNDP
9
8

9
8

3_5mm_8via 3_5mm_8via
1 7 1 7 G3
WORLDPLUS
9
8

A 2 6 2 6 3_5mm_8via A
3 3 1 7
2 6 Title
3
Panel Output
4
5

4
5

BL_ADJ Size Document Number Rev


BL_ADJ
4
5

GND_PWR BL_ON 1.0


GND_TMDS
BL_ON Custom
SZ04B_V1
Date: Sunday, August 19, 2007 Sheet 11 of 15
5 4 3 2 1
5 4 3 2 1

+ 12V _IN
< 2, 6,11> + 12V _IN + 12V _IN

< 2, 3, 4, 5, 6, 8, 9,10,11,12> G N D
SPEAKER OUT
A OUT1R
A OUT1R
A OUT1L
A OUT1L

MUTE_AMP
D MUTE_AMP D

J4

GND_A MP 1
S P E A K E R_ROUT 2
P V CC12 P V CC6 GND_A MP 3
+ 12V _IN R 62 33R S P E A K E R_LOUT 4
R 65 20K
+ R 66 DIP / P IN4/ 2.0
E C22 + E C14
47uF/ 16V 20K
47uF/ 16V

G ND_P HONE GND_A MP


G N D_P HONE

0. 047uF
R 380 C253
NC
C2 U3
G ND_P HONE GND_A MP EAR_OUT R 381
0 1uF
A OUT1L LIN 1 20
H:EAR PHONE OUT -INV1 GND

G ND 2 19
SGND GND
L:SPEAKER OUT EC8 3 18
GND SVRR GND
100uF/ 16V
S P E A K E R_LOUT EC7 L OUT 4 17
220uF/ 16V OUT1 GND
5 16
G ND PGND GND
+ 12V _IN S P E A K E R_ROUT EC6 R O UT 6 15
220uF/ 16V OUT2 GND
A _P OWER 7 14
G ND_P HONE VP GND
C E C5 MUTE _C 8 13 C
R 382 M/SS GND
47uF/ 16V 0
R 79 A OUT1R R IN 9 12
39K -INV2 GND
C 36 C 17 10 11
100pF 1K 1K R 383 1uF GND GND
G N D_P HONE CN8 GND_AMP NC C254 GND_A MP
R 67 R294 R 298 P HONE 0. 047uF GND_A MP TP A 1517
C 27

4
18K E C24 1
A OUT1L R 73 10K 2 - 10uF/ 16V R299 2
1 1 0R 3

+
C 32 3 + P HONE _OUTR 4 GND_A MP
1uF 820pF U5A
NJM4558
P HONE _OUTL 5
PHONE OUT
8
G ND_P HONE P V CC6

P V CC12 P V CC6

R 78
39K 10K
C 35 EAR_OUT
100pF R 53
G N D_P HONE H P D_P HONE
R 71
C 34
4

18K E C23 + 12V _IN


A OUT1R R 72 10K 6 - 10uF/ 16V R300
1 0R
+

7 H:EAR PHONE OUT


5 +
1uF U5B
L:SPEAKER OUT

2
C 31 NJM4558
8

1
R377 R364
820pF
P V CC6 R 366 47k 10K
G ND_P HONE 10k
P V CC12

1
2
B B

MUTE _C
R 372
47k +
1 2 Q39 E C54
2N3904 4 7 u F/ 16v
R 378 R 373 CA P 220U
1k 100K
MUTE_AMP 1 2 Q41 H P D_P HONE Q40

2
2N3904 2N3904
C274 R384

2
1uF 6.8K
R 379 C 255
NC 1 uF GND_A MP

1
1
MUTE _C
GND_A MP GND_A MP GND_A MP
GND_AMP

R369
8.2K
+ 12V _IN
3

R 363 R360
470K 470
D 48 Q37
BAV99 2N3904
3

R368
2

470K 1 Q38 R 365


2N3906 22K
2

A high:normal A

R367 + E C55 + E C56


low:mute
100K 47uF 2. 2uF

GND_A MP
WORLDPLUS
Title
TDA1517 Audio Amp
Size Doc ument Number Rev
C
SZ04B_V1 1.0
Dat e: Sunday,August 19, 2007 S heet 12 of 15
5 4 3 2 1
5 4 3 2 1

+5V_SW L5 TUN_5V L12


Tuner TO SPV7100
U19 10uH 10uH T5V_BOOSTER
LG-TDTG-S1XXD L0.2AX L0.2AX
1 2 1 2 (to SPV7100)

1
C162 C163 CVBS_TV CVBS3_IN
EC45 0.1uF 10nF L9 L8
D C135 470uF/16v C-0603 C-0603 1 uH 1 uH R211 D
1

2
B1 EC36 EC43 0.1uF 75R
2 T5V_BOOSTER 10uF/16V 2200uF/16v C146 C144 C142
B2(BST) 10pF 330pF 10pF
3 TP8 T5V_IF TAGND
B3(VCC) T5V_IF
G NDV G NDV G NDV G NDV
LG 4 C232 TAGND L6 1 2
RF AGC OUT TAGND
1uF These components close to SPV7100
10uH

1
5 C153 C151
NC
TUNER EC44 0.1uF
2200uF/25v C-0603
10nF
6 TP7 C-0603

2
VTU T3V3 CVBS3_IN
CVBS3_IN
7 TAGND
GND
8 R291 TAGND
AS 0
9 TUNER_SCL
SCL R136
21 10 TUNER_SDA 4.7K R137
GND SDL R-0603 4.7K
22 11 210_SCL_RF R-0603
GND IF
23 12 TAGND 210_SDA_RF
GND GND
C C
24 13
GND NC
14 C230 C226 SIFAIN0
2nd SIF 100pF 100nF TUN_5V
TAGND 15 L14
CVBS 1 0UH R285
16 MONO_IN L-0805 220R R292 (to SPV7100
AUDIO 1K R288
75R
& SCART-2)
17 CVBS_TV

1
NC R282 4053_5sw
18 TAGND 1K 2 D44
IF AGC Q23 U22 D-1206 1N4148 +5V_SW
R357
19 R327 2N3906 R-0603 33 R361 16 2 1

3
DIF1 IFP VCC
NC/75 33R-0603 12
210_SCL_RF X0
20 SCL_M 13 14 TUNER_SCL
DIF2 IFN X1 X
R359 33
TAGND TAGND R-0603 2
210_SDA_RF Y0
9.1K R95 SDA_M 1 15 TUNER_SDA
R362 33 Y1 Y
IFAGC
R-0603 5
DTV_CVBS Z0
R91 3 4
C62 R96 1K Z1 Z
0.1uF 39k 1 2 TUN_5V
B FB23 A,B,C=L ===> DTV B
C57 120/100M +5V_SW A,B,C=H ===> ATV 11 6
0.1uF L-0603 A IE
10 7
B VEE
9 8
C GND
R322 74HC4053
T DGND 10K

G4
delete c67,c68 R323
9
8

3
3_5mm_8via Q32
1 7 2 2N3904
I2C_SW
2 6
3

1
1K
4
5

TAGND

A A

WORLDPLUS
Title

TUNER PART
Size Document Number R ev
B
SZ04B_V1 1.0
D ate: Tuesday, October 16, 2007 Sheet 13 of 15
5 4 3 2 1
5 4 3 2 1

U16
DVBDRAM_A0 RN1 7 8 23 2 7 8 RN9 DVBDRAM_D0
DVBDRAM_A1 100/P A0 D0 33/P DVBDRAM_D1
5 6 24 4 5 6 UART_boot Strap
DVBDRAM_A2 RA-SMD-Y C16B 3 4 25 A1 D1 5 3 4 RA-SMD-Y C16B DVBDRAM_D2 USB ISP MODE
DVBDRAM_A3 1 2 26 A2 D2 7 1 2 DVBDRAM_D3
DVBDRAM_A3 DVBDRAM_A4 RN2 8 7 29 A3 D3 8 7 8 RN10 DVBDRAM_D4 P3.3V P3.3V P3.3V
DVBDRAM_A2 DVBDRAM_A5 100/P 6 5 30 A4 D4 10 5 6 33/P DVBDRAM_D5
DVBDRAM_A1 DVBDRAM_A6 RA-SMD-Y C16B A5 D5 RA-SMD-Y C16B DVBDRAM_D6
4 3 31 11 3 4 H/W CONFIG

1
TS_D7 R131 47R R-0603 TS_IN DVBDRAM_A7 2 1 32 A6 D6 13 1 2 DVBDRAM_D7
TS_D7 TS_CLK DVBDRAM_A0 DVBDRAM_A8 A7 D7 DVBDRAM_D8
RN4 8 7 33 42 7 8 RN6 R206 R189 R188
TS_CLK
TS_VAL
TS_VAL R122 47R R-0603 DVBDRAM_A10 DVBDRAM_A9 100/P 6 5 34 A8
A9
D8
D9
44 5 6 33/P DVBDRAM_D9 SDRAM SETTING 10K 10K 10K
TS_SY NC R121 47R R-0603 DVB/BA1 DVBDRAM_A10 RA-SMD-Y C16B 4 3 22 45 3 4 RA-SMD-Y C16B DVBDRAM_D10 VCCO3 R-0603 R-0603 R-0603
TS_SY NC A10/AP D10
TS_FAIL R120 47R R-0603 DVB/BA0 DVBDRAM_A11/BA0 2 1 35 47 1 2 DVBDRAM_D11

2
TS_FAIL A11 D11 DVBDRAM_D12 DVBISP2 DVBISP1 DVBbootstrap
36 48 7 8 RN8
R119 2 110K R-0603 DVB/DQM0 15 A12 D12 50 5 6 33/P DVBDRAM_D13
DVB/DQM0 DVB/DQM1 39 LDQM D13 51 3 4 RA-SMD-Y C16B DVBDRAM_D14

2
4
6
8

1
RESET_N DVB/DQM1 DVB/M_WE 16 UDQM D14 53 1 2 DVBDRAM_D15
RESET_N WE D15

1
DVBDRAM_A4 DVB/CAS 17 RN11 R159 R180 R173
DVBDRAM_A5 DVB/RAS 18 CAS 40 10K(8P4R) 10K NC NC R172
19 RAS NC/RFU RA-SMD-Y C16B R-0603 R-0603 R-0603 NC
D R277 CS 28 R-0603 D
SDRAM_3V3

1
3
5
7

2
DVBDRAM_A6 R152 4.7K R-0603 37 VSS 41

2
DVBDRAM_A7 DVBM_CLK 1 82 CKE VSS
2 38 54
R146 33 DVBDRAM_A8 R-0603 DVB/BA0 20 CLK VSS 1

2
2 R-0603 1 DVBDRAM_A9 DVB/BA1 21 BA0 VDD 14
SDA_M
R156 BA1 VDD 27 DVBROM_A0 UART_BOOTSTRAP
VDD DVBROM_A1
2
R143 33
1 DVBDRAM_D8
NC
R-0603
C259
NC/10pF
6
12
VSSq VDDq
3
9 DVBROM_A2
0: bootstrap enable
SCL_M VSSq VDDq
VCCO3 R-0603 DVBDRAM_D9 46 43 DVBROM_A3 1: bootstrap disable

1
DVBDRAM_D10 52 VSSq VDDq 49 DVBROM_A4

VCCK1.8
VSSq VDDq

DVBM_CLK
DVBDRAM_D11

VCCO3
2

2
4S641632H-UC60(4MX16 SDRAM)

1
C44 R111 R116 TSOP54
10pF 4.7K 4.7K DVBDRAM_D12 SDRAM_3V3 CCIR656-D[0..7]
CCIR656-D[0..7]
C-0603 R-0603 R-0603 DVBDRAM_D13

2
DVBDRAM_D14

1
DVB_SDA R115 47R R-0603 DVBDRAM_D15 CCIR656-CLK
DVB_SDA CCIR656-CLK
FB28

102
101
100
120/100M

99
98
97
96
95
94
93
92
91
90
89
88
87
86
85
84
83
82
81
80
79
78
77
76
75
74
73
72
71
70
69
68
67
66
65
DVB_SCL R82 47R R-0603 L-0603
DVB_SCL
1 2

I2C_SDA
GPIO3
GPIO2
GPIO1
GPIO0

TS_STA
TS_VAL
TS_CLK
TS_D7
VDD_K
M_A3
VDD__O2
M_A2
M_A1
M_A0
M_A10
M_BA1
M_BA0
M_DQM0
M_DQM1
VSS_K
M_A4
M_A5
M_A6
M_A7
M_A8
M_A9
M_CLK
VSS_O2
M_D8
M_D9
M_D10
M_D11
M_D12
MD_13
M_D14
M_D15
TS_ERR
p3_3_f lash

1
C43
+5V_SW 10pF

1
C-0603 C103

2
R275 NC/0.1uF
103 64 DVBDRAM_A11/BA0 10K R268 C-0603

2
104 I2C_SCL M_A11 63 DVB/RAS R274 10K R269
1 DVB_SPDIF VSS_K3/O3 M_RAS_B DVB/CAS 4.7K 10K STB_AL C60 2.2uF
105 62 DVB_AL_OUT
2 106 UA_TX/SPDIF M_CAS_B 61 DVB/M_WE R-0603
3 107 UA_RX/MUTE U8 M_WE_B 60 U12
4 AGND VSS_ADDC VDD_O1 VCCO3
108 SHPE1002_128 59 DVBDRAM_D0 DVBSPI_CE0 1 8 R108
VCCO3 VDD_ADAC M_D0 CE_B VDD
J3 STB_AR 109 QFP128-0.5 58 DVBDRAM_D1 DVBSPI_D0 2 7 HOLD_F C61
CON4/2.0mm STB_AL A_OUTR M_D1 DVBDRAM_D2 WP_F DQ0 DQ3 DVBSPI_CLK 270K
110 57 3 6
GPROBE DVBA_REF 111 A_OUTL M_D2 56 DVBDRAM_D3 4 DQ2 SCK 5 DVBSPI_D1 47pF
DVBV_COMP 112 A_REF M_D3 55 DVBDRAM_D4 GND DQ1
DVBV_BIAS 113 TV_COMP
TV_BIAS
SPHE1002_128_USB2.0 M_D4
M_D5
54 DVBDRAM_D5 NC/EN25T80/SOP
DVBV_FSADJ 114 53 DVBDRAM_D6 DIP8-SOP2
DVBV_REF TV_FSADJ M_D6 AGND
115 52
STB_CVBS TV_REFOUT VDD_K1 VCCK1.8 DVBDRAM_D7
116 51
117 TV_DAC0 M_D7 50
VCCO3 VDD_TV0 VSS_O1 DVBISP2
118 49 U13
119 TV_DAC1 VFD_CLK 48 DVBISP1 DVBSPI_CE0 1 8 +5V_SW
AGND VSS_TV0 VFD_STB CE# VDD
120 47 DVBbootstrap DVBSPI_D0 2 7 HOLD_F STB_AR C58 2.2uF DVB_AR_OUT
121 TV_DAC2 VFD_DATA 46 WP_F 3 SO HOLD# 6 DVBSPI_CLK
VCCO3

2
122 VDD_TV1 IR_IN 45 4 WP# SCK 5 DVBSPI_D1
123 TV_DAC3 VSS_K1 44 RESET_DVB R179 GND SI R106
AGND DVBUSB_REXT VSS_TV1 RESET_B
124 43 TP6 4.7K EN25T80/DIP <Assembly > C59
USB_REXT R_WE TP5 R-0603 DIP8 270K D10
125 42
VCCO3 USB_AVDDRXC R_OE DVBROM_A0 CCIR656-CLK 47pF
USB_GND 126 41 R162 1K R-0603 IN4004(DIP)

1
DVBDM USB_AVSSRXC R_A0 DVBROM_A1 CCIR656-D7

R_D2(SPI_CSB0)
R_D1(SPI_CSB1)
127 40 change the net

R_D3(SPI_CLK)
USB_DM R_A1

R_D4(_SPI_D0)
C DVBDP 128 39 DVBROM_A2 CCIR656-D6 C
USB_AVDDTX

R_D7(SPI_D3)
R_D6(SPI_D2)
R_D5(SPI_D1)
USB_DP USB_AVSSTX R_A2

R_A20(GPIO)
R_A19(GPIO)
CCIR656-D5 Vout=1.85V
VSS_PLLSA
VDD_PLLS

VDD_PLLA
CCIR656-D4 AGND U4
CLK_OUT

VDD_O0
VDD_K0
VSS_O0

VSS_K0
CLK_IN
+5V_SW 1117A_ADJ P1.8V

R_A18
R_A17
R_A16
R_A15

R_A14
R_A13
R_A12
R_A11
R_A10
R_D0

R_A9
R_A8
R_A7
R_A6
R_A5
R_A4
R_A3
PWM
SOT-223
75ohm D7

add pull up resistance SPDIF Output load 3


IN OUT
2

2
AVPLLGND USB_GND TDGND 4
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
Place near SPHE1002 output OUT R63

ADJ
DVBROM_A3 IN4004(DIP) 1.2K
0.4~0.6V

1
NC/47KR-0603
C64 2 1 10uF/10V C-0805 DVBROM_A4 R-0603
AGND

R276 2

1
CCIR656-D3 + EC16 C28

1
AGND C70 2 1 0.1uF C-0603 DVBA_REF CCIR656-D2 C18 220uF/16V 0.1uF
XTALO
VCCO3

VPLLVCC1.8

AVPLLVCC3

VCCO3
CCIR656-D1
XTALI

0.1uF CAP220U C-0603

2
1
CCIR656-D0 SDRAM_3V3

1
C29 R64

1
USB_GND R114 1 212K R-0603 DVBUSB_REXT 0.1uF 560
USB_GND

AVPLLGND

C-0603 R-0603

2
VCCK1.8

2
1

1
C228 C221 C231 C229 C97 C225
USB_trap
NC/47KR-0603

C69 1 2 0.1uF C-0603 DVBV_BIAS 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF
R144 2

VGND C-0603 C-0603 C-0603 C-0603 C-0603 C-0603

2
C187 1 2 0.1uF C-0603 DVBV_COMP
VCCO3
C68 1 2 0.1uF C-0603 DVBV_REF
2

VGND
1

R99 1 2 R-0603 DVBV_FSADJ R130


VGND 390R 22R
R-0603
R266
1

2
4
6
8

4.7K
STB_CVBS TP4 RN3
Y1 10K/P
1

47R

27MHz RA-SMD-Y C16B Q3


R-0603

R90 +5V_DC AP2301 +5V_SW


1
3
5
7

75R +3V3 SOT-23


R147

R-0603 P3.3V 1 3 P3.3V


C185 C186 VCCO3
2

27pF 27pF DVBSPI_CE0 10K


usb trap: high ,support usb function

NC R-0603
DVBSPI_CLK +5V_SW 10K R3 C1

2
R270 2
DVBSPI_D0 R126 1uF
VGND DVBSPI_D1 C238
VIDEO C-0603 3
usb trap: low , don't support usb function IN

1
10pF OUTPUT C21
R335 C-0603 R55 4 2 + 10nF
OUT

3
100R 2 1 47K EC1 C-0603

2
2

USB_trap R-0603 2 470uF/16v 1


POWER_ON ADJ

47KR-0603
L13

2
R273 2
BEAD DTV_CVBS DTV_CVBS Q12 UP1

1
R-0603 L17 2N3904 1117-3.3V EC9

1
1uH SOT-23 TOP-263 470uF/16v
1

1
B STB_CVBS 2 R336 B
L-0603

1
Q35 C239 C240 R337 NC_RV1

1
AVPLLGND 2N3906 100pF 100pF NC/75R R-0603

3
C-0603 C-0603 R-0603

2
2
GND

GND

KERNEL
1.8V POWER
P3.3V
FB13
120/100M VCCO3 P1.8V FB7 FB20
L-0603 120/100M VCCK1.8 120/100M VPLLVCC1.8 Video PLL
1 2 SPHE1002 3.3V L-0603 L-0603 +5V_SW +5V_SW +5V_SW
1 2 1 2 +1.8V POWER

2
POWER
1

1
EC25 C56 C65 C91 VCCO3 R328
Place near SPHE1002

1
100uF/16V + 10UF/10V 0.1UF EC18 C24 C92 R329 10
CAP220U C-0805 C-0603 10uF/16V + 0.1uF 10UF/10V 0.1uF Q33 10K R-0603
2

2
CAP100 C-0603 C-0805 C-0603 SOT-23 R-0603 R330
2

3 1
AP1701 100R

2
1

1
C205 C192 C195 C223 R-0603 p3_3_f lash
0.1uF 0.1uF 0.1uF 0.1uF 1 RESET 2 1 2 Q34
FB29 AVPLLGND C-0603 C-0603 C-0603 C-0603 RESET 2N3904

1
120/100M SDRAM_3V3 SDRAM 3.3V C237 SOT-23

1
L-0603 3 0.1uF

2
VCC
1 2 POWER C-0603
TP83

2
R331 D46 R332 R333 TP_RST R30
2 NC 3V9 1K 1K
1

J2 C113 C220 VCCO3 GND D-1206 R-0603 R-0603


R-0603
6

F1 10UF/10V 0.1uF 2 1 RESET_DVB

1
120/100M C-0805 C-0603 FB8
6

1
L-0603 +5V_SW 120/100M T1V8 TUNER 1.8V

1
1 1 2 L-0603 EC52

1
5V POWER C193 C210 4.7uF/16V +

1
2 DVBDM C194 0.1uF 0.1uF D47 R334 CAP10
D-(DM) FB6 0.1uF C-0603 C-0603 IN4148/IN5819 22

2
1

3 DVBDP 120/100M T3V3 C45 C-0603 D-1206 R-0603

2
D+(DP) L-0603 + EC20 0.1uF 2 1 2 1
4 1 2 220uF/16V C-0603
2

GND CAP220U
2

A A
TUNER 3.3V
1
5

C47
1

DM1 DM2 + EC15 0.1uF POWER


5

USB_CON NC/0603ESDA C7 47uF/16V C-0603 TDGND


2

NC/0603ESDA 10uF/10v VCCK1.8


2

C-0805

TDGND

1
FB31 C200 C202 C222
USB_GND 120/100M AVPLLVCC3 0.1uF 0.1uF 0.1uF
L-0603 C-0603 C-0603 C-0603

2
1 2

WORLDPLUS
1

C203 C199 1002 PLL


10UF/10V 0.1uF +3.3V POWER
C-0805 C-0603 Title
2

SPHE1002
Size D ocument Number Rev

AVPLLGND
D
SZ04B_V1 1.0
Date: Sunday, August 19, 2007 Sheet 14 of 15

5 4 3 2 1
HK-V7100-V3.2
No. Name Spec Rem Quantity

Socket
HEADER 2 2Pspace between2.54mm no hamuluserect JP2 1
HEADER 3 3Pspace between2.54mm no hamuluserect JP1 1
CON4/2.0mm 4Pspace between2.0mmno hamuluserect J4 1
CON6/2.0mm 6Pspace between2.0mmno hamuluserect J1 1
CON14/2.0mm 14Pspace between2.0mmno hamulus erect J9 1
DB15 DZ11A31-B8 (15P-Dsub,30X15mm horizontal) CN6 1
BNC DC+12V power socket (2.0MM CN9 1
PHONE JACK phone input jack CN7,CN8 2
15x2PIN30pin) 15X2Pspace between 2.0 J5 1
HDMI_J HDMI jack CN4 1
USB-JACK USB jack J2 1
component AV jack with 6 holes CON2 1
SVIDEO+RCA AV jack + SVIDEO jack J7 1
Crystal
Oscillator
20.48MHZ 20.48MHZ Quartz Crysta Oscillator(49S) XT1 1
27MHZ 27MHZ Quartz Crysta Oscillator(49S) X1,Y1 2
Diode
SSM5822/SK34 commutate diode60V/3A,DII D5 1
1N5822(DIP) commutate diode,dip D41 1
1N4148 Diode(SMT)4148,DII D2,D9,D42,D44,D47 5
1N4004(DIP) commutate diode1N4004 D7,D10 2
Diode3.9V Diode3.9V D46 1
D22,D23,D24,D28,D29,D30,D31,D3
Diode5.6V Diode5.6V 11
2,D33,D34,D35
Audion
BAV99 ESD D48,D19,D20,D21,D36,D37,D38 7
2N3906 SOT23,PNP TR,VCEO=40V/IC=200mA,DII/AUK Q8,Q23,Q35,Q38 4
Q2,Q9,Q12,Q13,Q15,Q25,Q26,Q31,
2N3904 SOT23,NPN TR,VCEO=40V/IC=200mA,DII/AUK 15
Q32,Q34,Q36,Q37,Q39,Q40,Q41
2N7002 SOT23,MOS Q20,Q27,Q28 3
BAT54 SOT23 D13,D17 2
AP2301 SOT23,MOS Q3 1
AP1701B SOT23 Q33 1
Electrolytic Capacitor
4.7uF/16V DIP,(4X7) 16V 20% EC52 1
EC18,EC21,EC23,EC24,EC27,EC28,
10uF/16V DIP,(4X7) 16V 20% EC29,EC31,EC33,EC34,EC36,EC37, 18
EC38,EC39,EC40,EC41,EC42,EC53
PDF "pdfFactory Pro" www.fineprint.cn
47uF/16V DIP,(4X7) 16V 20% EC5,EC14,EC15,EC22,EC54,EC55 6
220uF/16V DIP,(8X9) 16V 20% EC6,EC7,EC16,EC20 4
470uF/16V DIP,(8X9) 16V 20% EC1,EC9,EC26,EC47,EC48,EC46 6
EC2,EC11,EC12,EC30,EC50,EC8,EC
100uF/16V DIP,(6X7) 16V 20% 8
17,EC25
2200uF/16V DIP,(8X13) 16V 20% EC43,EC44,EC45 3
Inductor
33uH/4A ringed & erect33H20% L3,L15,L16 3
560nH Inductor,0603 L18 1
1uH Inductor,0603 L8,L9,L17 3
1.8uH Inductor,0603 L10,L11 2
10uH Inductor,DIP L5,L6,L12 3
10uH Inductor,0805 L14 1
Fuse
FUSE/5A 12V/A L4 1
Bead
F1,FB6,FB7,FB11,FB12,FB13,FB20
120/100M 0603,120R/100M 11
,FB23,FB28,FB29,FB31,L13
FB9,FB10,FB14,FB15,FB16,FB17,F
120/100M 0805,120R/100M B18,FB19,FB21,FB22,FB24,FB25,F 15
B26,FB30,L1
Resistor
33R4 KX0603 1/16W 5% RN6,RN8,RN9,RN10 4
100R4 KX0603 1/16W 5% RN1,RN2,RN4 3
150K4 KX0603 1/16W 5% RN5,RN7 2
10K4 KX0603 1/16W 5% RN3,RN11 2
Resistor(SMT)
R83,R84,R218,R256,R291,R381,R3
0R KX0603 1/16W 5% 7
82
R262,R263,R271,R272,R278,R280,
0R/0805 KX0805 1/16W 5% 12
R283,R286,R289,R290,R293,R297
R38,R68,R70,R118,R132,R251,R25
10R KX0603 1/16W 5% 12
4,R299,R300,R307,R328,R303
R33,R34,R35,R36,R62,R93,R98,R1
33R KX0603 1/16W 5% 13,R127,R143,R146,R166,R181,R2 19
08,R209,R357,R359,R361,R362
R75,R76,R82,R115,R120,R121,R12
47R KX0603 1/16W 5% 10
2,R131,R147,R343
R69,R90,R184,R197,R200,R201,R2
75R KX0603 1/16W 5% 11,R214,R215,R219,R220,R225,R2 18
26,R238,R239,R240,R247,R288
82R KX0603 1/16W 5% R152 1
R190,R191,R192,R193,R194,R195,
100R KX0603 1/16W 1% 12
R196,R216,R217,R228,R330,R335
180R KX0603 1/16W 5% R160,R161,R168,R174 4
PDF "pdfFactory Pro" www.fineprint.cn
220R KX0603 1/16W 5% R285 1
390R KX0603 1/16W 5% R99 1
470R KX0603 1/16W 5% R360 1
560R KX0603 1/16W 5% R64,R306 2
R10,R91,R148,R162,R230,R279,R2
82,R292,R294,R298,R323,R332,R3
1K KX0603 1/16W 5% 19
33,R338,R339,R341,R354,R378,R3
92
1.2K KX0603 1/16W 5% R63,R345 2
2K KX0603 1/16W 5% R346 1
2.4K KX0603 1/16W 5% R347,R224 2
3.3K KX0603 1/16W 5% R304 1
3.6K KX0603 1/16W 5% R348 1
R5,R37,R46,R80,R111,R116,R117,
R136,R137,R154,R158,R179,R250,
4.7K KX0603 1/16W 5% 25
R252,R259,R260,R265,R266,R274,
R277,R302,R310,R311,R342,R391
5.1K KX0603 1/16W 5% R16 1
5.6K KX0603 1/16W 5% R153 1
6.2K KX0603 1/16W 5% R349 1
R107,R109,R231,R232,R233,R234,
6.8K KX0603 1/16W 5% 9
R235,R244,R384
R3,R7,R42,R49,R50,R53,R57,R58,
R60,R61,R72,R73,R92,R94,R97,R1
00,R101,R102,R110,R119,R126,R1
28,R129,R149,R159,R164,R182,R1
10K KX0603 1/16W 5% 83,R188,R189,R206,R207,R227,R2 54
36,R237,R242,R243,R245,R246,R2
53,R255,R268,R269,R275,R301,R3
20,R321,R322,R324,R325,R326,R3
29,R344,R364
11K KX0603 1/16W 5% R350 1
12K KX0603 1/16W 5% R114 1
18K KX0603 1/16W 5% R67,R71 2
20K KX0603 1/16W 5% R66,R65 2
22K KX0603 1/16W 5% R365,R257 2
39K KX0603 1/16W 5% R78,R79,R96 3
R55,R124,R150,R151,R169,R170,R
171,R175,R176,R177,R185,R202,R
47K KX0603 1/16W 5% 23
203,R212,R273,R372,R377,R385,R
386,R387,R388,R389,R390
68K KX0603 1/16W 5% R308 1
100K KX0603 1/16W 5% R123,R367,R373 3
270K KX0603 1/16W 5% R108,R106 2
470K KX0603 1/16W 5% R368,R363 2
1M KX0603 1/16W 5% R267 1
Capacitor(SMT)
PDF "pdfFactory Pro" www.fineprint.cn
5pF CC41-0603 50V20% C248 1
10pF CC41-0603 50V20% C43,C44,C83,C88,C142,C146,C155 8
15pF CC41-0603 50V20% C190,C191 2
22pF CC41-0603 50V20% C63,C73 2
27pF CC41-0603 50V20% C185,C186 2
33pF CC41-0603 50V20% C72,C189,C196 3
47pF CC41-0603 50V20% C59,C61,C130 3
C136,C211,C213,C214,C215,C216,
56pF CC41-0603 50V20% 10
C241,C242,C243,C244
C35,C36,C111,C154,C156,C230,C2
100pF CC41-0603 50V20% 7
39
220pF CC41-0603 50V20% C148,C161 2
330pF CC41-0603 50V20% C144 1
390pF CC41-0603 50V20% C106 1
820pF CC41-0603 50V20% C31,C32 2
4.7nF CC41-0603 50V20% C6 1
C10,C21,C115,C116,C117,C121,C1
10nF CC41-0603 50V20% 11
22,C123,C151,C163,C251
47nF CC41-0603 50V20% C253,C254 2
82nF CC41-0603 50V20% C108 1
C4,C5,C13,C16,C18,C24,C26,C28,
C29,C41,C42,C45,C46,C47,C48,C4
9,C50,C51,C52,C53,C54,C55,C57,
C62,C65,C66,C68,C69,C70,C71,C7
6,C77,C78,C79,C80,C81,C82,C86,
C87,C90,C92,C93,C94,C97,C102,C
104,C105,C109,C110,C135,C153,C
162,C164,C165,C166,C167,C168,C
0.1uF CC41-0603 50V20% 169,C171,C172,C173,C174,C175,C 108
176,C177,C178,C179,C180,C182,C
183,C184,C187,C188,C192,C193,C
194,C195,C198,C199,C200,C201,C
202,C204,C205,C206,C207,C208,C
209,C210,C217,C218,C219,C220,C
221,C222,C223,C224,C225,C226,C
227,C228,C229,C231,C234,C235,C
237,C249
C1,C2,C17,C27,C38,C39,C40,C67,
1uF CC41-0603 50V20% C84,C112,C139,C181,C197,C212,C 18
232,C233,C252,C255,C274
C3,EC56,C58,C60,C118,C120,C124
,C125,C126,C127,C128,C131,C132
2.2uF CC41-0603 50V20% 25
,C133,C134,C138,C140,C141,C147
,C152,C159,C160,C275,C276,C277
C7,C22,C33,C56,C64,C89,C91,C11
10uF/10V 0805 10V20% 9
3,C203
PCB
PDF "pdfFactory Pro" www.fineprint.cn
PCB HK-V7100-V3.2 1
Short circuit block 5V 1
Radiation Fin U10 1
IC
MP1411 U1 1
HY5DU281622FTP-6 8Mx16 DDR U2 1
HY57V641620FTP-6 4MX16 SDRAM U16 1
NJM4558 IC,SO8 U5 1
SHPE1002_128 IC,QFP128-0.5 U8 1
SPDC210 IC,QFP64-0.5 U9 1
SPV7100-LQFP256 IC,QFP256-0.4-PADB U10 1
74HC4052 IC U17 1
74HC4053 IC U22 1
FT24C02 semiconductor memorizer SO8(2K ROM) U18,U14 2
FT24C32
semiconductor memorizer SO8(32K ROM) U15 1
EN25T80 Flash U6 1
EN25T80 Flash U13 1
AP4920 DIP8-SOP U20 1
RT8110 IC U21 1
1117A-ADJ 5 SOT223 U4 1
AP1084K-33LA 3.3V/5 TO-252,Anachip /Gamma /ADD UP4 1
LM1117MPX-1.8V IC,SOT223 UP3 1
AP1117-2.5V IC,SOT223 UP2 1
LM1117MPX-3.3V IC,SOT223 UP1 1
TDA1517 DIP20 U3 1
APM9435A SO8P compartment SW Q11 1
TUNER TDTG-S122D U19 1

PDF "pdfFactory Pro" www.fineprint.cn


Part6: Debug Instruction

HK-7100-V3.2 Debugging Procedures

1.Check
Check Pins of SDRAM , RESET IC and FB23 .
Check the HDMI jack.

2.No Logo appears.


(1) Is current less than 0.1A?
Check the dual mos(U20AP4228of power.
Check the U21RT8110of power.

(2) Is current more than 0.3A?


Check Pins of DDR and SDRAM.
Is FLASH works ok?

(3) Check power connection.


Check the bottom.

3.No DTV
FLASH accessed?
Check RESET IC. ( Q33)
Check the cable of SDRAMRN9
Check the Crystal Oscillator. Y127M
Is I2C ok?

4.DVT no signal
Check the Crystal Oscillator. XT120.48M
Is FB23 connection ok?

5.AV/SV abnormal color


Check the Crystal Oscillator X127Mand capacitor.

6.DTV
DTV color is abnormally.Check RN11RN5RN7 etc..

7.Check HMDI

In HDMI mode:

(1)No picture appears. Check HDMI connection.

(2)Sounds with no picture. Is EDIDok?In TV mode,enter factory menu and then EDID RESET

8.Check the HDMI, is Jack connection ok?


9.No DVB Check

Connect N Is connection ok? Is resistor of


again. SDRAM cable ok? Connect
N again.

Y Power on
Y

Check if the Connect


Make sure the Pin 1002IC is ok? again.
LDO and N
power switch N Is DVB power ok?
are
ok.(Q3,Q12)
Y Y

Is IC of Reset N Check if Check


ok?And Check if the Reset ok. CODE of FLASH N and
connection is ok? update.
ok?
Y
Y
Make sure
Crystal Oscillator
N Is Crystal Oscillator 1002system
and and load cap (27MHZ) ) works ok? works ok.
are ok.

Checkifthe N Is SDRAM_CLK End


PLL power (108MHZ)ok? debugging.
is ok?
Y
Make sure
1002 N Check HW,Config set is correct.
(pin47,48,49)
is ok.
Check
10DTV No Signal
Y
Make sure
component of
Connect N Is connection ok? Check communication I2C and
again. 210 and TUNER(I2C) 4053 are ok.
is correct.
Y
Y
Y Check the
Power on
TS
connecation
Make sure the Check TS . N and 1002
connection of pin210 are
BEAD of
N Is current ok? ok.
TUNER POWER
Y

Y
Make sure DTV ok.
(20.48MHZ
crystal)and N Is frequency of Crystal
load cap are ok? (20.48MHZ) ok?

Y
End
Make sure debugging.
component of N Check communications
bewteen 1002 and 210I2C
I2C and
pin1002 ok.
are ok. Y

Is
210ADC ok?
Check if the N VCM=1.6V,
component VRB=1.1V, VRT
of ADC and =2.0V)
Pin210are ok.
Y

Check if N
BEAD of Is AGCok?1.9V~3.8V
TUN_5V and
pin210 are ok.

You might also like