Professional Documents
Culture Documents
Model 6250
The 10A Micro-Ohmmeter Model 6250 Resistive materials (i.e. ground The large, easy-to-read display shows
is a rugged, low resistance tester bonding, coatings, contact resistances) the resistance measurement, ambient
designed for plant maintenance, are tested with an instantaneous test. and reference temperatures, metal
quality control in manufacturing and Simply press the test button the type and test method, as well as alarm
field use. Utilizing a four-lead Kelvin reading is taken and the test is conditions and memory utilization, all
method of testing, the Model 6250 concluded. in real time. Previously stored test
is one of the more accurate Micro- results can easily be called up for
Ohmmeters available, with results Inductive materials (i.e. coils, trans- review on the display or sent directly
within 0.05% accuracy. formers, motor windings) are tested to a printer or remote terminal.
with a continuous test. The test is
Resistance measurements are started and stopped by the operator Two programmable alarm set points
automatically calculated and at the push of a button. are available. Each can be either
displayed, taking into account the active high or low and will sound an
measurement value, ambient Auto test mode is designed for alarm when tripped, further adding to
temperature, reference temperature multiple test points on resistive and/or the ease of use by permitting quick
and metal temperature coefficient. low inductance material. The test is Pass/Fail measurements.
Sample temperature can be manually started at the press of a button. As the
entered by the operator or directly operator moves the probe from one External trigger operation is available
measured by the Model 6250 with point to another, the test is stopped, through the communication port
an external RTD temperature probe. the results are displayed and a new allowing the test to be conducted
test is started when the test probes from a remote location.
The Model 6250 is uniquely designed again make contact no need to
to conduct tests on both resistive and The list of features and functions goes
press the test button! Residual voltage
inductive material, with operator on and on. The Model 6250 will be a
is measured between tests to ensure
selection directly from the front panel. valuable asset for your bond testing,
proper results. This test mode
Three test modes are available and coil and contact testing as well as
continues until the operator presses
automatically employed based on coatings and connector or any other
the button to conclude the testing.
this selection: low resistance testing application.
Direct printout
AC line Communication/
recharging receptacle remote operation port
RTD temperature input
Kelvin
terminals Large multi-line backlit
liquid crystal display
Start/Stop button
Functional Display
Temperature correction active
Resistance measurement
Measurement units
Kelvin probes, set of two, Kelvin clips, set of two, Kelvin clips, set of two, RTD Temperature Probe
spring loaded (1A) 10 ft Catalog #1017.83 (10A) 10 ft Catalog #1017.84 with 7 ft extension cable
(10A) 10 ft Catalog #1017.82 Catalog #2129.96
(1A) 20 ft Catalog #2118.52
Repair and Calibration Service for information on repair & calibration, obtaining a user manual:
repair@aemc.com
Technical and Product Application Support for technical and application support:
techinfo@aemc.com
South America, Central America, Mexico, Caribbean, Australia & New Zealand: