You are on page 1of 3

Points discussed of frequent problem faced in voltronic 1-3 kva & comments by Jim.

Points
sl no problem faced
discussed
Not Supporting in normal window range
Realy chattering
3kva input ovcd Pcb burnt
1 pcb failure ( Emi
pcb )
MOV burst

1kva main pcb inv igbt frequently failed.


2 inverter output
coil failure

Inverter not getting on


Fault 03 ( Bus Pfc igbt failed
3 Under Low ) in Input fuse open
1 & 3kva Control pcb problem

Booster mosfet
4 Booster mosfet & Smd ic burnt
failure in 1-3kva

Inverter igbt
5 failure in 3kva Inverter igbt got short

Output relay
6 contact Not getting output voltage.
problem in 3kva

battery voltage Display shows low battery even the battery


7 detection voltage is good.
problem

Remaining
backup time
information in
8 Need some customer
display not
match with
original
voltronic 1-3 kva & comments by Jim.

Comments by Jim Remarks

His conclusion is indian MES not supporting


the original window design. All happened Noted the feedback by Jim.
due to input high voltage.

Previously MOV placed input phase &


neutral to Earth.Now it was replaced Implemented in last despatch.
between input phase to neutral.

Told to be discussed with Voltronic R & D


team

New Firmware will be implemented in our


next shipment to minimise this issue.

To be sent components list to voltronic.


Asked to use only recommanded mosfet by Promised to sent in free of cost. Told that
them. Due to equilent it may create 1kva booster mosfet rating is increased in
problem our next shipment.

Asked to use only recommanded mosfet by To be sent components list to voltronic.


them. Due to equilent it may create Promised to sent in free of cost.
problem.

During coating appling on the pcb it may be


chance to go inside the realy thro some Told that to be discuss with their team.
small hole which create the contact issue.

May be the control pcb problem Difficult to service the control pcb

Current firmware not matched. New firm


ware will be implemented in our next Need to check with next shipment
shipment.

You might also like