Professional Documents
Culture Documents
(zf)Man lock means any lock other than a medical lock used for
the compression or decomp ression of persons entering or
leaving a working chamber.
(zg)Material hoist means a power or manually operated and
suspended platform or bucket operating in guide rails and
used for raising or lowering material exclusively and
operated and controlled from a point outside conveyance.
(zh)Materials lock means a chamber through which materials
and equipments pass from one air pressure environment into
another.
(zi)Medical lock means a double compartment lock used for
the therapeutic recompression and decompression of person
suffering from the ill effects of decompression.
(zj)National standards means standards as approved by Bureau
of Indian Standard and in the absence of such standards of
Bureau of Indian Standard, the standards approved by the
State Government for a specific purp ose.
(zk)Outrigger means a structure projecting beyond the facade
of a building with the inner and being anchored and
includes a cantilever of other support;
(zl)Plant or equipment includes any plant equipment, gear,
machinery, apparatus or appliance, or any part thereof;
(zm)Pressure means air pressure in bard above atmospheric
pressure;
(zn)Pressure Plant means the pressure vessel along with its
piping and other fittings operated at a pressure greater than
the atmospheric pressure;
(zo)Putlog means a horizontal member on which the board,
plank, or decking of a working platform are laid;
(zp)Responsible person means a person appointed by the
employer to be responsible for the performance of sp ecific
duty or duties and who has sufficient knowledge and
experience and the requisite authority for the p roper
performance of such duty or duties;
(zq)Reveal tie means the assembly of a tie tube and fittings
used for tightening a tube between two opposite surfaces;
(zr)Right angle coupler means a coupler, other than a swivel or
putlog coupler, used for connecting tubes at right angles;
(zs)Rock bolt means a mechanical expansion bolt or a bolt
used with cementitious or resin anchoring system which is
5
PART I I
CHAPTER-I
State Advisory Committee, Registration of Establishments
3. Num ber of members under section 4 of the State
Advisory Committee: The number of persons to be appointed as
members under clause (e) of sub-section (2) of section 4 shall be
ten out of whom.-
(i) four persons out of whom at least one shall be woman to
be nominated by the State Government rep resenting the
building workers;
(ii) four persons to be nominated by the State Government
for rep resenting the employers connected with the building
and other construction work;
(iii) two persons to be nominated by the State Government
representing one from the State level association of
architects or engineers and one from an accident insurance
institution.
4. Term of office of Chairperson and certain members.- (1)
The Term of Chairperson of the State Advisory Committee shall
be three years from the date on which his appointment is notified
in the official gazette, by the State Government.
(2) A member referred to in clause (b) of sub-section (2) of
section 4 shall hold the office for three years or till he remains a
member of the Legislative Assembly or Council of State, as the
case may be, whichever is earlier.
(3) The members referred to in sub-rule [i], sub-rule [ii] and
sub-rule [iii] of Rule 3, shall hold office for a period of three
years from the date on which this appointment is notified in
official gazette.
Provided that where the appointment of the successor of
any such member has not been notified in the official gazette on
or before the exp iry of the said period of three years, such
member shall, notwithstanding the expiry of the period of his
office, continue to hold such office until the appointment of his
successor is notified in the official gazette.
(4) If a member is unable to attend a meeting of the
committee, the state government may, after giving notice in
writing to such member and the chairperson of the State Advisory
Committee, nominate a substitute of such member to attend the
meeting and such a member shall have all the rights and
privileges of such member in respect of that meeting.
9
(c) save as p rovided in these rules, the fees paid for the
grant of registration certificate shall be non-refundable.
(2) The employer shall intimate the change, if any, in the
number of workmen or the conditions of work to the Registering
Officer within fifteen days.
(3) The employer shall, before thirty days of the
commencement and completion of any building or other
construction work, submit a written notice to the inspector,
having jurisdiction in the area where the p roposed building or
other construction work is to be executed, intimating the actual
date of the commencement or, as the case may be, completion of
such building or other construction work in Form-IV
(4) The certificate of registration of an establishment shall
be valid only for such building and other construction work
carried out by such establishment for which intimation required
under sub-rule (3) has been given.
(5) A cop y of the certificate of registration shall be
displayed at the conspicuous place at the premises where the
building and other construction work is being carried on.
18. Fees.- (1) The fees to be paid for the grant of a
certificate of registration under rule 16 shall be as specified
below:
If the number of workers proposed to be employed as
building workers for a building or other construction work on
any day:
(a) upto 100 Rs. 1,000
(b) exceeds 100 but does not exceed 500 Rs. 2,500
(c) exceeds 500 Rs. 5,000
(2) For each amendment ten percent of the above fees shall
be deposited by the employer.
19. Payment of Fees.- (1) All amounts of money payable on
account of registration, appeal, supply of copies or duplicate
copies of certificate of registration shall be paid through a
crossed demand draft in favour of the Registering Officer and
appellate officer, as the case may be, and made payable at the
branch of the bank specified by the State Government from time
to time at the headquarters of the concerned registering officer or
appellate officer.
(2) The registering officer or the appellate officer, as the
case may be, on receipt of the demand draft under sub-rule (1)
shall arrange to deposit the amount in the approp riate account
in the bank specified by the State Government from time to time
14
(a) a minimum of one year shall have lapsed from the date
of registration of the applicant to the date of marriage
of the applicants son or daughter for whose marriage
the assistance is sought;
(b) the family of a registered construction worker can avail
this assistance only twice;
(c) the registered construction worker shall have no dues
payable to the Board; and
(d) the son or daughter of the registered construction
worker, for whose marriage the assistance is sought,
shall have attained the age prescribed by law for
marriage.
The application for claiming the amount specified in sub-Rule (1)
shall be in Form - XXIII.
PART III
Safety and Health
CHAPTER - I
General Pr ovisions
50. Excessive noise, vibration, etc.- An employer shall
ensure at a construction site of a building or other construction
work that adequate measures are taken to protect building
workers against the harmful effects of excessive noise or
vibration at such construction site and the noise level in to case
exceeds the limits laid down in Schedule - VI.
51. Fire protection: Every employer shall ensure at a
construction site of a building or other construction work that,-
(a) such construction site is provided with
(i) fire extinguishing equipment sufficient to
extinguish any probable fire at such
construction site;
(ii) an adequate water supply at ample p ressure as
per national standards;
(iii) number of trained persons required to operate
the fire extinguishing equipment provided
under sub-clause (i);
(b) fire extinguishing equipment provided under sub-
clause (i) of clause (a) is properly maintained and
inspected at regular intervals of not less than once
in a year by the responsible person and a record of
such inspections is maintained;
(c) in case of every launch or boat or other craft used
for transp ort of building workers and the cabin of
26
CHAPTER II
LI FTI NG APPLIANCES AND GEAR
71. Construction and maintenance of lifting appliances.-
Every employer shall ensure at a construction site of a building
or other construction work that-
(a) All lifting appliances, including their parts and working
gear, whether fixed or movable and any plant or gear
used in anchoring authoring or fixing of such
appliances, are-
(i) of sound construction, sound material, and of
adequate strength to serve the purpose for which
these are to be used and all such appliances shall be
free from patent defects; and
(ii) maintained in good repair and working condition;
(b) (i) every drum or pulley around which the rope of any
lifting appliance is carried, is of adequate diameter
and sound construction in relation to such rope;
(ii) any rope which terminates at the winding drum of a
lifting appliance is securely attached to such drum
and at least three dead turns of such rope remain on
such drum in every operating position of such
lifting appliance;
(iv) the flange of a drum projects twice the rope
diameter beyond the last layer of such rope and if
such projection is not available, other measures like
anti-slackness guards shall be provided to p revent
such rope from coming off such drum;
(c) Every lifting appliance is p rovided with adequate and
efficient brakes, which -
(i) are capable of preventing fall of a suspended load
(including any test load) and of effectively
controlling such load while it is being lowered;
(ii) act without shock;
(iii) have shoes that can be easily removed for running;
and
(iv) are provided with simple and easily accessible
means of adjustment:
PROVIDED that nothing contained in this clause shall
apply to steam winch which can be operated as safely as
with brakes as p rovided in accordance with this clause.
(d) Controls of every lifting appliance,-
36
(a) all vehicles and earth moving equip ment are made of
good material, proper design and sound construction
and are sufficiently strong for the p urpose for which
such equipment are used and are maintained in good
state of repair and are properly used in accordance with
standard safe operating practices:
Provided the truck or trailer employed for
transp orting freight containers are of the size sufficient
to carry the containers without overhanging and are
provided with twist locks conforming to national
standards, at all the four corners of each of such truck
or trailers and such truck or trailers are certified for
such use by an authority under the relevant law for the
time being in force and is inspected by a responsible
person, at least once in a month and record of such
inspection is mentioned;
(b) all transport or earth moving equip ment and vehicles
are inspected at least once a week by a responsible
person and in case any defect is noticed in such
equipment or vehicle, it is immediately taken out of use;
(c) power trucks and tractors are equipped with effective
brakes, head-lights and tail lamps and are maintained in
good repair and working order;
(d) side stanchions on power trucks and trailers for
carrying heavy and long objects are-
(i) of sound construction and free from defects;
(ii) provided with tie chains attached to the top across
the loads for preventing such stanchions from
spreading out; and
(iii) kept in p osition while loading and unloading;
(e) safe gangways are provided for to and fro movement of
building workers engaged in loading and unloading of
lorries, trucks, trailers and wagons;
(f) trucks and other equipments are not loaded beyond their
safe carrying capacity which shall be clearly marked on
such trucks and other equipments;
(g) handles of hand trucks are so designed as to protect the
hands of the building workers working on such trucks,
or such handles are provided with knuckle guards;
(h)no unauthorized p erson rides the transport equipment
employed in such work;
58
rocks and other materials which may slide, roll or fall upon a
building worker working below such bank;
(g) adequate and suitable warning signs are put up at
conspicuous places at the excavation work to avoid any person
falling into the excavations or trenches;
(h) the responsible person referred to in Rule 160 ensures
at the excavation work that no building worker is permitted to
work where such building worker may be struck or endangered
by the excavation machinery or material or article used in such
excavation.
142. Piling, shoring and bracing.- Every employer shall
ensure at a construction site of a building or other construction
work that,-
(a) plank used for sheet piling in excavation or tunneling
work is of sound material with adequate strength;
(b) shores and braces used in excavation or tunneling work
are of adequate dimensions and are so placed as to be effective
for their intended purposes;
(c) earth supported shores braces used in excavation or
tunneling work bear against a footing of sufficient area and
stability to p revent the shifting of such shores or braces.
143. Safe access.- Every employer shall ensure at a
construction site of a building or other construction work that
ladders, staircases or ramps are provided, as the case may be, for
safe access to and egress from excavation where the depth of such
excavation exceeds one point five metres and such ladders,
staircases or ramps comply with the relevant national standards.
144. Trenches.- Every construction work that a trench or
excavation is p rotected against falling of a person by suitable
measures if the depth of such trench or excavation exceeds one
and a half meters and such protection is an imp roved p rotection
in accordance with the design and drawing of a professional
engineer, where such depth exceeds four meters.
145. Depth of trenches.- Every employer shall ensure at a
construction site of a building or other construction work that:
(a) where the depth of a trench requires two lengths of
sheet piling, one above the other, the lower piling is set inside
the bottom strings or walls of the upper piling and such sheet
piling is driven down and braced as the excavation continues;
(b) all metal sheet piles used in excavation or a trench are
welded end to end and secured by other similar means.
73
CHAPTER - XII
STRUCTURAL FRAME AND FORMWORK
mounted on each of such rope so that such safety rope with such
automatic safety device support the platform of such scaffold in
the event of failure of the primary suspension wire ropes,
winches, climbers or any part of the mechanism used for raising
or lowering such suspended scaffold:
Provided that this rule shall not apply,-
(a) where the platform of such scaffold is supported at two
independent suspension wire rope at or near each end of such
platform so that in the event of failure of one of such suspension
wire rope, the other wire rope is capable of sustaining the
weights of such platform and its load and prevent it from tilting;
or
(b) where a system is incorp orated which operates
automatically to support the platform of such scaffold and its
load in the event of failure of the primary suspension wire roe of
such scaffold.
CHAPTER XV
COFFERDAMS AND CAISSONS
shall not be disclosed to any person except for the purpose of the
enquiry.
(7) The person entitled to appear under sub-Rule (2), called
for evidence or representing in an enquiry shall be entitled to
make an opening statement, give evidence, request the Enquiry
Officer to call for specified document or evidence, cross-examine
other person or to the extent and at the stage permitted by the
authority or Enquiry Officer holding the enquiry.
(8) Any evidence in an enquiry may be admitted at the
discretion of the authority or Enquiry Officer during the enquiry,
who may also direct that documents to be tendered in evidence
may be inspected by any person entitled or permitted to appear
at such enquiry and that facilities be afforded to such person to
take or obtain copies thereof.
(9) The authority or the Enquiry Officer holding an enquiry
may authorize any person, being an officer of the State
Government to assist such authority or enquiry officer where
necessary, for the purpose of conducting the enquiry, and the
officer so authorized may enter the premises of the concerned
establishment during working hours, inspect the records relevant
to such enquiry, investigate and take such evidence as may be
required to conduct such enquiry.
(10) The findings of the enquiry along with all evidence, in
original, including statement of witness shall be forwarded to the
authority specified under Section 39 of the Act within five days
of the completion of the enquiry in cases where sub-enquiry was
not conducted by such authority itself.
(11) A copy of the findings along with a brief statement of
facts relating to an enquiry conducted under this rule shall be
forwarded to the Chief Inspector and the State Government by
the authority referred to in sub-rule (1) of Rule 246.
230. Reporting of accidents. - (1) Every Employer shall send
notice of any accident on the construction site which either,
(a) cause loss of life; or
(b) disable a building worker from working for a period of
forty-eight hours or more immediately following the
accident, shall forthwith be sent by telegram, telephone,
fax or similar other means including special messenger
within four hours in case of fatal accidents and seventy-
two hours, in case of other accidents involving building
workers, to
(i) the Workmens Compensation Commissioner having
jurisdiction in the area in which the establishment in
106
PART V
CHAPTER I
MEDICAL FACILITIES
242. Medical exam ination of building workers, etc.- Every
employer shall ensure at a construction site of a building or other
construction work that,-
(a) a building worker who is employed for a
work involving such risk or hazards, inherent in such
work as the Director General considers appropriate
for the periodical medical ex amination of such
worker, is medically ex amined at such intervals as the
Chief Inspector of Inspector of Building and
construction may direct from time to time;
(b) every operator of a crane, which or other
lifting appliance, transp ort equipment or vehicle, is
medically examined before employing such operator
and again periodically, at such intervals as the Chief
Inspector of Inspection of Building and construction
may direct from time to time;
(c) the medical examination referred to in
clause (a) and clause (b) is in accordance with
Schedule - V, and is conducted by such medical
officers or at such Hospitals as are approved by the
State Government for the purpose from time to time;
(d) in case of a building worker who is exposed
to special occupational health hazard owing to job or
work assigned to such worker, the periodical medical
examination referred to in sub-clause (a) or sub-clause
(b) includes such special investigation as may be deemed
necessary by the construction medical officer examining
such building worker for the diagnosis of occupational
disease;
(e) no building worker is charged for the medical
examination referred to in sub-clause (a) or sub-clause
(b) and the cost of such examination is borne by the
employer employing such building worker;
(f) certificate of medical examination referred to
in clause (a) or clause (b) is issued in Form -XXXII;
(g) the record of the medical ex amination
referred to in clause (a) or clause (b) of every building
worker employed by him is maintained in a register in
112
265. Char ges of foodstuff.- (1) The charges for food stuffs,
beverages and other items served in the canteen provided under
sub-rule (1) of rule 262 shall be based on no profit no loss and
the price list of such items shall be conspicuously displayed in
such canteen.
(2) In arriving at the prices of items referred to in sub-rule
(1), the following shall not be taken into consideration as
expenditure, namely:
(a) the rent for the land and building of such canteen;
(b) the dep reciation and maintenance charges for the building
and equipment p rovided in such canteen;
(c) the cost of purchase, repairs and replacement of
equipments including furniture, crockery, cutlery, utensils
and uniform provided to the employees of such canteen;
(d) the water charges and other charges incurred for lighting
and ventilation of such canteen; and
(e) the interest on the amounts spent for providing and
maintaining furniture and other equipment for such
canteen.
CHAPTER II
WAGES
266. Date of Payment of Wages under section 45.- Every
employer shall ensure at a construction site of a building or other
construction work that,
(a) the wages of every building worker employed at such
construction site where less than one thousand such
building workers are employed are paid before the
expiry of the seventh day and in other cases before the
expiry of tenth day after the last day of the period in
respect of which such wages are payable;
(b) in case the employment of such building worker is
terminated by or on behalf of such employer, the wages
earned by such building worker are paid before the
expiry of the second working day from the day on which
employment of such building worker is terminated;
(c) all payments of wages are made on a working day at
such construction site and during the working time and
on a date notified in advance and in case the work is
completed the final payment of wages is made within
forty eight hours of such completion of work.
267. Display of notices of wage regarding date of payment
of wages.- An employer shall ensure at a construction site of a
125
(VIMALA KUMARI)
Under Secretary to Government
Labour Department
To:
The Compiler, Karnataka Gazette for publication in the extra-
ordinary gazette of the next issue and to p rovide 50 copies to the
Government and 100 copies to the Labour Commissioner,
Karmika Bhavan, Bannerughatta Road, Bangalore.
Cop y to:
1. The Accountant General (A &E), Karnataka, Bangalore
2. The Labour Commissioner, Karmika Bhavan, Bannerughatta
Road, Bangalore.
3. Concerned Officers through Labour Commissioner
4. G P A to the Principal Secretary to Government, Labour
Department
5. Weekly Gazette
6. Section Guard Files / Spare copies
127
SCHEDULE - I
[See rules 72 (a), 86 (a) & 87 (a) (ii)]
Manner of test and examination bef ore taking lifting appliance,
Lifting gear and wire rope into use for the first time
Test loads:
(1) Lifting appliance.-
Ever lifting appliance with its accessory gear shall be
subjected to a test load which shall exceed the safe working load
(SWL) as specified in the following table:
TABLE
Safe working load Test load
Upto 20 tonnes 25 percent in excess of safe working load
20 to 50 tonnes 5 tonnes in excess of safe working load
Over 50 tonnes 10 percent in excess of safe working load
(2) Lifting gear.-
(a) Every ring, hook, chain shackle, swivel, eye-bolt, plate
clamp, triangular plate or pulley block (except single sheave
block) shall be subjected to a test load which shall not be less
than the load as sp ecified in the following Table:
TABLE
Safe working load (in tones) Test load (in tones)
Up to 25 2 X safe working load
Above 25 (1.22 X safe working load) +
20
(b) In the case of a single sheave block, the safe working
load shall be the maximum load which can safely be lifted by the
block when suspended by its head fitting and the load is attached
to a rope which passes around the sheave of the block and a test
load not less than four times the proposed safe working load
shall be applied to the head of the block.
(c) In the case of multi sheave block, the test load shall not
be less than the load as specified in the following Table:
TABLE
Safe working load (in tones) Test load (in tones)
Up to 25 2 X safe working load
25 to 160 (0.9933 X safe working load) +
27
Above 160 1.1 X safe working load.
(d) In the case of hand-operated pulley blocks used with
pitched chains and rings, hooks, shackles or swivels, permanently
128
attached thereto, a test load not less than 50 per cent in excess of
the safe working load shall be applied.
(e) in the case of a pulley block fitted with a bucket, the
bucket shall be tested and the load applied to the bucket when
testing that block will be accepted as test load of the bucket.
(f) in the case of a sling having two legs, the safe working
load shall be calculated when the angle between the legs is 90
degree. In case of multi-legged slings the safe working load shall
be calculated as per national standards.
(g) Every lifting beam, lifting frame, container spreader,
bucket, tub, or other similar devices shall be subjected to a test
load which shall not be less than the load as specified in the
following Table:-
TABLE
Proposed safe working load (in Test load (in tones)
tones)
Up to 10 2 X safe working load
10 to 160 X safe working load) + 9.6
Above 160 X safe working load
(h) Wire ropes:
In the case of wire ropes a sample shall be tested to
destruction. The test procedure shall be in accordance with
recognized national standards. The safe working load of the rope
is to be determined by dividing the load at which the sample
broke by a co-efficient of utilization, determined as specified in
the following table:
TABLE
Item Co-efficient of utilization
(1) (2)
(a) Wire rope forming part of
sling: Safe working load of the
Sling:
Safe working load up to and 5
equal to 10 tonnes:
10
Safe working load above 10
tonnes and up to and equal to 160 (8.85XSWL)+1910
tonnes
3
Safe working load above 160
tonnes 10
(b) Wire rope as integral part of a 8.85 X SWL) + 1910
lifting appliance: SWL of the
lifting appliance: Safe working 3
up to and equal to 160 tonnes
129
SCHEDULE - III
[See clause (a) of rule 168]
Perm issible Levels Of Certain Chemical Substances In The
Work Environment
Sl Substances Permissible limit of exposure
No Time weighted Short-term
average exposure limit
concentration (STEL (15 min)
(TWA) (8 hrs.)
ppm mg./m3 ppm mg./m3
1 2 3 4 5 6
1 Acetaldehyde 100 180 150 270
2 Acetic acid 10 25 15 37
3 Acetone 750 1780 1000 2375
4 Aerolein 0.1 0.25 0.3 0.8
5 Acrylonitrile-Skin 2 4.5 - -
(S.C.)
6 Aldrin-Skin - 0.25 - -
7 Allyl chloride 1 3 2 6
8 Ammonia 25 18 35 27
9 Aniline- Skin 2 10 - -
10 Anisidine (o-p - 0.1 0.5 - -
isomers)-Skin
11 Arsenic & Soluble - 2 - -
comp ounds (as As
12 Benzene (S.C.) 10 30 - -
13 Beryllium & - 0.002 - -
Compound (As Be)
(S.C.)
14 Boron trifluoride-C 1 3 - -
15 Bromine 0.1 0.7 0.3 2
16 Butane 800 1900 - -
17 2-Butanone (Methy1 200 590 300 885
ethy Ketone- MBK)
18 n-Buty1 acetate 150 710 200 950
19 n-Buty1 alcohol- 50 150 - -
Skin-C
20 Sec /tert. Buty1 200 950 - -
acetate
21 Buty1 mercaptan 0.5 1.5 - -
22 Cadmium dust and - 0.05 - -
salts ( as Cd)
23 Calcium oxide - 2 - -
24 Carbarly (Servin) - 5
133
25 Carbofuran - 0.1 - -
(Furadan)
26 Carbon disulphide- 10 30 - -
Skin
27 Carbon monoxide 50 55 400 440
28 Carbon 5 30 - -
tetrachloride- Skin
(S.C.)
29 Chlordane- Skin - 0.5 - -
30 Chlorine 1 3 3 9
31 Chlorobenzene 75 350 - -
(menochloroben zene)
32 Chloroform (S.C.) 10 50 - -
33 Bis (Chloromethy1) 0.001 0.005 - -
either (H.C.)
34 Chromic acid and - 0.05 - -
chromates (as Cr.)
(water soluble)
35 Chromous salts (as - 0.5 - -
Cr.)
36 Copper fume - 0.2 - -
37 Cotton dust, raw - 0.2* - -
38 Cresol, all isomers- 5 22 - -
Skin
39 Cyanides (as CN)- - 1 - -
Skin
40 Cyanogen 10 20 - -
41 DDT - 1 - -
(Dichlorodipheny1
trichloroethane)
42 Demeton- Skin 0.01 0.1 - -
43 Diazinon-Skin - 0.1 - -
44 Dibuty1 phthalate - 5 - -
45 Dicholorvos 0.1 1 - -
(DDVP)-Skin
46 Dieldrin-Skin - 0.25 - -
47 Dinitrobenzene (all 0.15 1 - -
isomers)- Skin
48 Dinitrotoluene- Skin -S 1.5 - -
49 Diphyny1 ( 0.2 1.5 - -
Biphyny1)
50 Endosulfan - 0.1 - -
(Thiodan)- Skin
51 Endrin- Skin - 0.1 - -
52 Ethy1 acetate 400 1400 - -
134
78 Methy1 collosolve 5 16 - -
(2-Methoxy-
ethannol)-Skin
79 Methy1 inobuty1 50 205 75 300
ketone
80 Methy1 isocyanate- 0.02 0.35 - -
Skin
81 Naphthalene 10 50 15 75
82 Nickel carbony1 (as 0.05 0.35 - -
Ni)
83 Nitric acid 2 5 4 10
84 Nitric oxide 25 30 - -
85 Nitrobenzene- Skin 1 5 - -
86 Nitrogen diox ide 3 6 5 10
87 Oil mist, mineral - 5 - -
88 Ozone 0.1 0.2 0.3 0.6
89 Parathion- Skin - 0.1 - -
90 Phenol- Skin 5 19 - -
91 Phorate (Thimet)- - 0.05 - -
Skin
92 Phosgene (Carbony1 0.1 0.4 1 1
chloride)
93 Phosphine 0.3 0.4 - -
94 Phosphoric acid - 1 - 3
95 Phosphorus ( - 0.1 - -
yellow)
96 Phosphorus 0.1 1 - -
trichloride
97 Phosphorus 0.2 1.5 0.5 3
trichloride
98 Pieric acid- Skin - 0.1 - 0.3
99 Pyridine 5 15 - -
100 Silane (Silicon 5 7 - -
tetrahydride)
101 Sodium hydroxide- - 2 - -
C
102 Styrene, monomer 50 215 100 425
(phenylethylene
103 Sulphur dioxide 2 5 5 10
104 Sylphur 1000 6000 - -
hexafluoride
105 Sulphuric acid - 1 - -
106 Tetraethuyl leade - 0.1 - -
(as Pb) Skin
107 Tolune (Toluol) 100 375 150 560
136
ppm p a r ts o f v a p o u r o r ga s p e r m i l l i o n p a r ts o f c o nt a m i n a te d a i r b y v o l u m e a t 2 5
mg/ m o C a n d 7 6 0 m m o f H g. m i l l i g r a m o f s u bs ta n c e p e r c u bi c m e tr e o f a i r
Note:* Not more than 4 times a day with at least 60 min. interval
between successive exposures.
Respirable dust:
SCHEDULE - IV
[Se e sub-R ule s (1 ) & (2 ) of Rule 2 28 & R ule 2 45 (c)]
(xi) to design an d con duct, either in depen dently or in colla bora tion
w ith other a gen cies, suita ble tra ining a n d educa tional
pro gra mmes for prevention of a ccidents to b uildin g w orkers ;
(xii) to fra me sa fe rules a n d sa fe w orkin g pra ctices, in consultation
w ith sen ior officia ls of th e esta blishment;
(xiii) superviz e a nd guide sa fety preca ution s to be ta ken in buil din g
a nd other con structi on w ork of the esta blishment.
Fa cilitie s to be provide d to sa fe ty office rs: The employer sh all
provi de ea ch sa fety officer w ith such facilities, equipment and
in forma tion th a t a re necessa ry to en a ble him to dispa tch h is duties
effectively.
Prohibition of pe rforma nce of othe r duties: No sa fety officer sha ll be
required or permitted to do an y w ork w hich is unconn ected to,
in con sistent w ith or detrimenta l to the performa n ce of th e duties
prescribed in this Sc hedule.
Exe mptions: The C hief In spector may, in w ritin g, exempt an y
employer or group of employers from any or a ll of the provisions of
these rules subject to complia n ce w ith such a lterna tive a rran gements
a s ma y be a pproved a nd n otified by h im in the order or such
exemption .
A rticle s for Ambulance Room
(i) A gla zed sink w ith hot an d cold w a ter a lwa ys a va ila ble
(ii) A ta ble w ith a smooth top a t lea st 18 0 cms X 1 05 cm.
(iii) Mea ns for steriliz ing instruments
(iv) A couch
(v) Tw o stretch ers
(vi) Tw o buckets or cont ainers w ith close fittin g lids
(vii) Tw o rubber h ot w a ter ba gs
(viii) A kettle an d spirit st ove or other sui ta ble mea ns of boilin g water
(ix) Tw elve pla in w ooden splints 9 00 cm X 100 cm X 6 cm.
(x) Tw elve pla in w ooden splints 350 cm X 75 cm X 12 cm
(xi) Six plain w ooden splin ts 2 50 cm X 50 cm X 12 cm
(xii) Six w oolen blan kets
(xiii) Three pa irs a rtery forceps
(xiv) One bottle of spirit us a nnemiae arema tions ( 1 20 ml.)
(xv) Smelling sa lt (660 gm.)
(xvi) Tw o medium siz e spon ges
(xvii) Six ha nd towels
(xviii) Four ki dney tra ys
(xix) Four ca kes of toilet, prefera bly a n tiseptic soa p
(xx) Tw o gla ss tumblers a nd tw o w ine gla sses
(xxi) Tw o clinical th ermometers
(xxii) Tw o tea spoon s
(xxiii) Tw o gra dua ted (1 20 ml.) mea suring glasses
141
SCHE DULE - V
[Se e Rule 9 7, 2 42 (c) a nd Ru le 24 6 ]
SCHEDU LE - V II
[Se e Rule 2 44 ]
Ha zardous processes:
(1) Roof w ork
(2) Steel erection
(3) Work under a nd over w a ter
(4) Demolition
(5) Work in confined spa ces
SCHEDU LE VIII
[Se e sub-R ule (b) of Rule 24 4]
Qualifica tion of con struction Me dica l Office r: (1) MBBS degree from
a Medica l Institute recognized by th e Medical Coun cil of Indi a; a nd
(2) Diploma in indust ria l health or equiva len t post gra dua te
certifica te of tra ining in industria l hea lth or hea lth .
(3) A Medica l Officer ha vin g w orking experience in organ ization
/ esta blishments involved in policy, execution a nd a dvice a n d safety
a nd h ealth of w orkers employed in mines, ports a n d d ocks, fa ctories
a nd building a nd other constructi on w ork, for a period of n ot less than
three yea rs ma y, subject to th e sa tisfa ction of the Director-Genera l, not
be required to p ossessin g th e tra ining referred to in item (2 ) above.
(4) The syllabi of th e courses lea ding to th e a bove certificates
a nd the orga niza tion con ducting such courses sha ll be approved by the
C entral Government w ho ma y a lso from time to time prepare a pa nel
of such organ izations.
(5) C omplete pa rticula rs including n ame, qua lifica tion a nd
experience of the construction medical officer w ill be in timated to the
Inspector ha ving juri sdiction.
146
FORM I
[See sub-rule (1) of rule 15 & Section 7]
.
APPLICATION FOR REGISTRATION OF ESTABLISHMENTS
EMPLOYING BUILDING WORKERS
To:
.
Karnataka Building and Other
Construction Workers Welfare Board,
..
1. Name and location of the establishment where :
building or other construction work is to be
carried on:
2. Postal address of the establishment: :
3. Full name and permanent address of the :
establishment, if any:
4. Full name and address of the manager or :
person responsible for supervision and
control of the establishment:
5. Nature of building or other construction :
work carried / is to be carried on in the
establishment:
6. Maximum number of building workers to :
be employed on any day:
7. Estimated date of commencement of :
building or the other construction work:
8. Estimated date of completion of the :
building or other construction work:
9. Particulars of demand draft, enclosed name :
of the bank, amount, demand draft No. and
date):
Declaration by the employer
(i) I hereby declare that the particulars given above are true to
the best of my knowledge and belief;
FORM- II
[See sub-rule (1) of rule 16]
.
No. Date:
GOVERNMENT OF KARNATAKA
(c) Save or provided in these rules, the fees paid for the grant
of registration certificate shall be non-refundable;
(d) The rates of wages payable to building workers by the
employer shall not be less than the rates p rescribed under
the Minimum Wages Act, 1948 (2 of 1948) , for such
employment where applicable, and where the rates have
been fixed by agreement, settlement or award, not less than
the rates so fixed; and
(e) The employer shall comply with the provisions of the Act
and the rules made thereunder.
FORM - III
[See sub-rule (2) of rule 16]
.
Register of Establishments to be maintained by the Registering
Off icer for the month of ..
Sl. Registration Name and Name of the Nature of
No. No. and date address / Employer and building
location of his address: or other
the constructio
establishme n work
nt
(1) (2) (3) (4) (5)
FORM- IV
[See sub-Rule (3) of Rule 17]
.
NOTICE OF COMMENCEMENT / COMPLETION OF
BUILDING AND OTHER CONSTRUCTION WORK BY THE
EMPLOYER
To:
The Inspector,
FORM V
[See sub-rule (1) of rule 20]
.
Application for Registration as a Beneficiary
Passport
size Photo
To: .
Karnataka Building and Other
Construction Workers Welfare Board,
..
1. Full name and permanent :
address of the applicant:
2. Date of birth/age :
3. Sex : Male/Female
4. Nationality :
5. Whether belongs to : SC/ST/OBC/Others
6. Local address :
7. Name and address of the :
present employer
8. Nature of work :
9. Date of employment :
10. Wages per day/per month :
11. Name of the nominee & :
relation with address
I hereby declare that the above information is true and correct
to the best of my knowledge and belief.
Place:
Signature/Left Hand Thumb impression of
Date: the Applicant
FORM-VI
[See sub-rule (3) of rule 20]
.
Nomination
Registration No
To:
The Secretary,
Karnataka Construction Workers Welfare Board,
Bangalore 560 ..
Place:
Signature/Thumb impression of
the registered construction worker
Date: with register
number
CERTIFICATE
Certified that the above declaration has been signed / thumb
impression has been impressed by Sri/Smt./Kumar/Kumari
after he/she has read the entries (or after the entries
have been read over to him/her by me and understood by him/her.
Place:
FORM- VII
[See sub-rule (3) of rule 20]
.
Change of Nomination
Registration No.
To:
The Secretary,
Karnataka Construction Workers Welfare Board,
Bangalore 560 ..
Place:
Signature/Thumb impression of
Date: the registered construction
worker.
CERTIFICATE
Certified that the above declaration has been signed / thumb
impression has been impressed by Sri/Smt./Kumar/Kumari
after he/she has read the entries (or after the entries
have been read over to him/her by me and understood by him/her.
Place:
FORM VIII
[See sub-rule (4) of rule 20]
.
Photo
Page 2
1. Name of the Member with address: :
2. Sex: : Male / Female
3. Nature of work: :
4. Registration Number & date: :
5. District: :
6. Name of Bank & Branch in which :
subscription is to be paid
7. Subscription rate: Rs. 20/- per :
month
Page 3
8. Date of birth and age: :
9. Date of retirement: :
Marital status: :Married / Unmarried
10. Name of wife / husband with :
address:
11. Whether wife/husband, a member : Yes / No
of this Board:
12. If so, name and registration :
number
13. Name of nominee (s) :
FORM IX
[See sub-rule (5) of rule 20]
Register of Beneficiaries
1. Full name: :
2. Permanent address: :
3. Date of birth/age:
4. Sex: : Male/Female
5. Registration Number and date:
6. Name of the nominee & relation :
with address
7. Particulars of employment:
Present Nature of Name of the Date Date of Signa-
address work & present of complet- ture of
designatio employer with emplo ion of board
n address & Tel. y- work official
No. ment
1 2 3 4 5 6
FORM - X
(See rule 22)
.
REGISTER OF BENEFICIARIES TO BE MAINTAINED BY THE
EMPLOYER
for the month of ..
Sl. Name A ge & Sex: Nature Designa tion Da te of
No. a n d full date of Ma le / of commen ce
a ddress birth Fema le w ork ment of
of the employ-
benefici- men t
a ries
(1) (2) (3) (4) (5) (6) (7)
Rate Date & Monthly contribution of the beneficiary Remarks
of No. of J F M A M J J A S O N D
wage registra
per t-ion as
day a
/ per benefi-
mont ciary
h
Employers Signature
156
FORM-XI
(See rule 34)
..
Building and Other Construction Workers Welfare Board,
Karnataka
Annual Rep ort for the year .
I. Board:
1. Full registered address: :
2. Date of constitution: :
3. Name of Chairperson: :
4. Member of the Board: :
5. Regional offices with address if :
any):
6. No. of staff of the Board with :
grade-wise including regional
offices):
II. Membership:
i) No. of beneficiaries registered :
with the Board:
ii) No. of registered employers: :
iii) No. of beneficiaries registered :
during the audit period:
III. Meetings:
State the number of meetings :
held with dates during the year
and names of the members
remaining absent:
IV. Audit:
i) Date of the last audit: :
ii) Have any irregularities been :
mentioned in the previous audit?
If so, state the position regarding
compliance thereof.
V. Internal audit:
a) Is there a formal internal audit :
system in operation?
b) Any special areas which are :
taken up by the internal; auditor?
If yes, list them:
c) Who had done the internal audit? :
157
FORM-XII
[See sub-rule (2) of rule 39]
..
Application for pension
To:
The Secretary,
Karnataka Construction Workers Welfare Board,
Bangalore 560 ..
Place:
FORM-XIII
[See sub-rule (4) of rule 39]
..
Register of payment of pension
Remarks
Order on cancellation of pension, etc.
May be noted here with reason and date
Effect under initials of Secretary / ..
(10)
Form XIV
[See sub-rule (2) of rule 40]
Application for Disability Pension
To:
The Secretary,
Karnataka Construction Workers Welfare Board,
Bangalore 560 ..
Place:
Signature/Thumb impression of
Date: the Applicant
Name:
163
FORM-XV
[See Rule 41]
..
Applicati on No. Fee Rs.
L oa n A p p l i c a t i on f or p u r c h a s e of ( To o l s ) I n s t r u m e n t :
To:
T h e Se c r e ta r y,
K a r n a ta k a C o n s t r u c ti o n W o r ke r s W e l f a r e B o a r d ,
B a n ga l o r e 5 6 0 . .
1. N a m e o f th e a p p l i c a n t: :
2. Fa th e r s / H u s ba n d s n a m e : :
3. Re s i d e n ti a l A d d r e s s : :
4. Re gi s te r N u m be r : :
5. N a m e o f B a n k i n w h i c h c o n tr i bu ti o n r e m i t te d : :
6. A ge & D a te o f B i r th : :
7. M o n th l y I n c o m e : :
8. D e ta i l s o f o th e r p r o p e r ti e s , i f a n y , o w n e d o r p o s s e s s e d :
b y th e a p p l i c a n t:
9. D e t a i l s of Su r e t i e s : :
Name & Address:
O c c u p a ti o n & A dd r e s s :
P r e s e n t n e t m o n th l y i n c o m e :
D e ta i l s o f o th e r p r o p e r ti e s o w n e d / p o s s e s s e d b y th e s u r e t y :
W h e th e r th e s u r e t y h a s o f f e r e d h i m s e l f a s s u r e t y f o r a n y
o th e r tr a n s a c t i o n e a r l i e r , i f s o , th e d e ta i l s :
10. W h e th e r s a l a r y c e r t i f i c a t e f r o m th e e m p l o y e r i s
a tta c h e d :
11. Pa r t i c u l a r s of I n s t r um en t s t o b e p u r c ha s e d:
( a ) D e s c r i p ti o n :
( b) M a ke :
( c ) M o de l :
( d) I n v o i c e p r i c e ( c o p y e n c l o s e d ) :
(e) Name & Address of supplier / dealer:
12. (a) Amount of loan applied for:
( b) N o . o f m o n th l y i n s ta l l m e n ts p r o p o s e d f o r
r e p a y m e n t:
D E C L A R A TI O N
1 . I/We co nfirm that the funds wi ll be use d for the sta ted purpose on ly a nd will n ot be
used for speculati on an d / or anti-soc ial purpose.
2 . I/We understa nd tha t the Boa rd ha s the right to reca ll the funds if they are no t use d f or
the stated purposes.
3 . I/We understand tha t the sanction of the fa c ility is a t the discreti on of the Boa rd a nd
I/We w il l exec ute necessary Secur ity Documents as per the Board s req uire ments to its
satisfaction.
Place:
D a te : S i gn a t u r e of a p p l i c a n t
S u r e t y 1 : N a m e & S i gn a t u r e
F or of f i c e u s e o nl y
T h e a p p l i c a ti o n s u bm i t te d b y S r i . . e m p l o ye d a s
i n . H a s be e n v e r i f i e d . T h e c e r ti f i c a te o f
e m p l o ym e n t a n d s u r e t y i n r e s p e c t o f th e bo r r o w e r h a s be e n a t ta c h e d a l o n g w i th
th e u n d e r ta k i n g b y th e e m p l o ye r .
A n a m o u n t o f R s . ( Ru p e e s . )
m a y be s a n c ti o n e d f o r t h e p u r p o s e be i n g t h e a m o u n t r e q u e s te d / a m o u n t e l i g i b l e
7 5 % o f th e i n v o i c e a m o u n t to b e r e c o v e r e d o f Rs . ( R u p e e s
) i n . e q u a l m o n th l y i n s t a l l m e n ts . T h e l a s t i n s ta l m e n t
w i l l be th e a m o u n t o u t s ta n d i n g a f te r r e m i tta n c e o f th e . I n s ta l m e n t
i nc l u d i n g o th e r du e s t o th e B o a r d a t t h e ti m e o f c l o s i n g o f th e l o a n a m o u n t.
S a nc tio n ed / R ej ec t ed / S ec r et ar y
164
FORM-XV I
[See Rule 42]
..
D E CL A RA T IO N
I he r eb y d ecl a r e th a t t h e a b o v e st a t em e nt s a r e tr u e a nd c o rr ec t to th e
b es t o f m y kno w l ed g e a nd b eli ef .
P lace:
Na me D et ai ls o f d oc u me n t s t o b e p rod uc ed :
1. Pl a n a nd es ti m a t e ( a p pr o v ed ) ;
2. Enc u mb r an c e Cer tif ic a t e o f 1 4 y ear s;
3. Lo ca t io n Ce r tif ic a te;
4. La nd t a x r ec ei p t;
5. Or ig i na l d oc um ent;
6. Att es t ed co p y o f r a tio n c a rd ( p age 2, 4) f or m ai nt e na nc e ap p l ic at i o n;
7. Ow ner s hi p o f t h e b u i l d i ng ( f o r m ai n t en a nc e onl y) ;
8. T er mi n a l b en ef i t d ec l a ra tio n;
9. Att es t ed co p i es of id e nt it y c ard a nd p a s s b o o k;
1 0 . Ti tl e cl ea r a nc e c er ti f ic a t e;
1 1 . Ag e c er tif ic a t e of t he b u ild i n g ( f or m a int e na nc e o nl y) ;
1 2 . Va l u at io n c er t if i c at e o f t h e p r o p er t y;
1 3 . No o b jec tio n c er tif ic a t e f ro m th e a u tho r i ti e s f o r co n s tr u ct io n;
1 4 . Dec l ar a tio n f r o m t h e ap p l ic a nt t h at n eit h er h e / sh e / nor hi s / h er
sp o u s e / c hi ld r en o w n a ho us e ( f o r ne w c o ns tru ct io n ) ;
M O R T G A GE D EE D
Th is D eed o f M o rt g a g e i s exe c u t ed o n t h i s th e . Da y
o f .. tw o tho u s a n d f i v e b y S r i / S m t. ..
s o n/d a u g hte r/ w if e o f a ged . . r es id in g at
Vi ll a g e
T a lu k . D is tr ict a nd S r i
/ S m t. .. s o n /d a u gh t er /w if e o f a g ed
.. r es id i ng at v il l ag e
. . T a lu k . . D i s t ric t . .
( the r ei n af t er c a ll ed t he M o r t g ago r / M or t g ago r s w hi c h exp r es s io n
s ha l l i nc l ud e hi s / h er / t h eir exec u t er s, a d m i ni st er s, l eg a l r ep r e s en t at iv es
a nd a s s i g ns ) in f avo u r of t h e K ar n at a k a B u i ld ing a n d o t her Co ns tr uc tio n
W o rk er s W elf a r e B o ar d est ab l is h ed u n de r the B u i ld i ng a nd o t her
Co n st r u c t io n Wo r ker s ( R egu l a tio n of E mp lo y m en t a nd Co n dit i o ns o f
S er v ic e) Ru l es, 2 0 0 5, a nd ha vi n g it s c hi ef o f fi c e a t B a ng l ao r e ( t h er ei n af ter
c a l l ed t h e M o r t g ag e w h ic h exp r es s io n s hal l i nc l ud e i ts s u cc es s o rs o r
a s s i gn s w h er ev e r t he c o nte xt o r m ea ni n g the r eo f s ha ll s o r eq u ir e o r p er m it)
W h er ea s t h e M o r t ga go r / M o r tga go r s ha s / h av e ap p l i ed to th e
M o r tga g ee fo r a lo a n o f R s . 5 0, 0 0 0 ( R up ees f if t y t ho us a nd o n l y) f o r th e
c o ns tr u c tio n of a ho us e o n th e l a nd mo r e p ar tic u l ar s m en ti o ned a nd
d es c ri b ed i n th e s c h ed ul e h er e u nd er w r i tt en:
A nd w h er eas o n t h e r equ es t of t h e M o r tg a g er /M o r t g ago r s th e
M o r tga g ee ha s a gr ee d to l en t an ad v a nc e i n t wo in s t al l m ent s to t h e
m or tg a g er a lo a n o f R s. 5 0 , 0 0 0 /- ( Ru p ees F i f ty tho u s an d o n ly) s u b jec t to th e
c o v en a nt s, t er m s a nd co nd it io ns h er ein co nt a in ed a nd h a vi ng th e r ep a y m e nt
th er eo f , s ecu r e d i n th e m a n ner h er ein a f t er exp r es s ed .
N O W T H IS DE E D W IT NE SS E T H A S FO L L O W S
1. In p u r s u a nc e o f t h e s a id agr eem ent a nd i n c ons id er at io n o f t h e s u m of
R s . 5 0, 0 0 0 /- ( R u p ees Fif t y t hou s a nd o nl y) n o w r en t a nd ad v a nc e a nd
166
pa i d b y t h e M o rt g a g ee to t h e M o r tg a go r /M o r tg a go r s , ( t he r e c ei pt
w h er e o f t he M o r tg a g er h er eb y a m id st a nd ac kno w l ed g es) th e
M o rtg a go r /M o r tg a go r s her eb y tr a n sf er s /t r a ns f er b y w a y o f si mp l e
M o rtg a g e th e i mm o v a b l e p ro p ert y, mo r e p a r ti cu l ar l y m en t io n ed a nd
de sc r i b e i n t he S c he du l e h er e u nd er; w r i t te n to g et h er w i th th e
b u ild i n g to b e c o ns tr u ct ed t he r e o n a nd o t h er i m pr o v em en t s t h er e o n
f ro m ti m e to ti m e to t h e i n t end t h at o f t he s ai d p r o p er t y a nd t h e
b u ild i n g a nd o t h er i mp r o v em en ts s ha ll r em ai n an d b e c h ar g ed a s
s ec ur it y f o r p ay m e nt to the M or tg a g ee o f th e s aid lo a n a mo u nt
in ter es t a nd c o st and the M o r tg a g ee s hal l h av e th e f ir st c h ar g e o v er
the s a m e.
2. Th e lo a n a mo u nt s h al l b e p a id to t he M o r t g ago r /M o rt g ago rs b y th e
M o rtg a g ee in t w o i ns t a ll m ents t h a t t he f i r s t i ns t al l m en t o f a s u m of
R s . 2 0, 0 0 0 /- ( R up ees t w ent y t ho u s a nd o n l y) eq u a l to 4 0% o f t he l oa n
s a nct io n ed s h a ll b e p a id to th e M o r t ga go r /M o r tg a go r s f o r s t ar t in g
co n str uc tio n, t h a t t h e 2 n d a nd F i n al i n st a ll m en t of R s . 3 0, 0 0 0 /-
( R u p ees t hi r t y t ho u s a nd o nl y) equ a l to 6 0 % o f t he lo a n s h al l b e p a id
af t er co mp l eti n g th e c o ns tr u c tio n o f ro o f a nd on s t a rt in g f ini s hi ng
wo r ks. T h e c o n st r u c tio n of th e b u i ld ing s ha l l b e co mp l et ed in a ll
r es p ec ts u t il i zi n g t h e 2 n d i n s ta l l m ent s a nd c er t if i c at es o f c o m p l et i o n
sh a l l b e p r od u c ed w i t hi n t wo m o nth f r o m th e r e c ei p t o f l as t
in s t al l m e nt.
3. Th e i ns t a ll m en ts s h a ll b e p a id o nl y su b jec t t o the av a il a b i li t y o f f u nd s
a nd no n p ay m en t of a m ou n ts d u e to p a u ci ty o f f u nd s h a l l no t en ti tl e
the M or tg a go r /M or tg a go rs to r eal i z e a n y lo s s th a t h e / s h e / t he y
m a y s u s t a i ned o n th a t ac co u nt f r o m t h e M o r t g age e.
4. M o rtg a go r /M o r tg a go r s h er eb y as su r es /a s s u r e u p to t he M o rt g a g ee
tha t h e/ sh e/t h ey i s ar e t h e a b so lu te o w ner s o f t he p ro p er t y
m en tio ned i n t h e s c hed u l e h er e to a nd t ha t th ey ar e f r ee f r o m a ny
enc u mb r an c e o r c ha rg e o f a n y d es c ri p t io n w h a tso ev er o r a ny
a tt ac h m en t o r r es tr a i n ts o n a li e na t io n.
5. Th e M o r tg a go r /M o r t g ago r s s h a ll no t a t a ny t i m e d ur i ng th e
co n ti nu an c e of t hi s s e cu r i ty c r eat e a ny M o r tg a ge li en o r c h ar g e b y
w a y o f hyp o t hec a t io n , p l ed g e, o r o t h er w is e cr e a t e en cu mb r a nc e of
a n y k i nd w h a tso ev er i n r es p ec t of t h e p r o p ert i e s d esc ri b ed i n th e
sc hed u l e he r eto o r a n y p ar t th er eo f , o r l et o r l eas e t h em exc ep t w i t h
the p r i or p er m is sio n i n wr it i ng o f t he S ec r et a ry , K ar nat a k a B u i ld i ng
a nd O t her Co ns tr uc t io n W o r k er s W elf ar e B o a rd u nt il t h e w ho l e
a mo u nt w i t h i n t er e s t a r e f u l ly r ep a id.
6. Th e lo a n s ha l l b ear int er es t at t h e r a te o f 5 % p er a nnu m o r s u c h o t h er
hi gh er r a t e o f i nt er es t a s m ay b e f i xed b y t h e M o rt g ag ee f r o m ti m e to
ti m e.
7. Th e lo an s hal l b e r ep a i d b y t h e M o rt g a go r /M o r tg a go r s i n mo n t hl y
in s t al l m e nt s at t he r a t e as w o u ld b e f i xed a nd i n ti m a t ed b y th e
M o rtg a g ee. T h e f i r s t ins t al l m ent b ec o m in g d u e o n t he exp ir y o f 6
mo nth s fr o m t h e d a t e o f di s b ur s e m en t o f th e f ir s t i ns t al l m en t,
su b s eq u en t i n s ta ll m ent s s ha l l b e p ai d on o r b ef o r e the 1 0 t h of
su cc eedi ng mo nt h. A n y in t er e s t d u e o n t he lo a n a m o u n t o ut s ta nd i ng
o n t h e d at e o f p a ym en t of an i ns t a l l m en t s h a ll b e p a id a lo ng w it h th e
in s t al l m e nt.
8. A t t h e t i m e o f d i sb u r s em en t o f t h e s eco nd i ns t a ll m ent t h e M o r tg a g ee
sh a l l d e du c t the i n t er es t a nd o th er e xp en s es d u e o n t h e f ir s t
167
in s t al l m e nt ti ll t h e d a t e o f p ay m en t o f t h e s ec o nd ins t al l m ent. If th e
M o rtg a g ee p a ys o n ly a p a r t o f th e lo a n a mo u nt to t he M or tg a go r d u e
to t h e no n- av a il a b i li t y o f f u n ds s u c h p ar t of t h e lo a n s hal l b e r ep a id
b y t he M o r tga go r i n st a l l m en t at t he r a te a s w o u ld b e f i xed a nd
in ti m a t ed b y t he M o rt g ag ee.
9. If t h e M o r tg a go r / Mo r tg a gor s di es /d i e b e f o r e t h e d i s b u r s em e nt of
the r em a i ni n g i ns t al l m ents o f t h e lo a n af t er ha v in g r ec ei v ed o ne o r
mo r e in s t al l m ent s o f th e lo a n a nd i f hi s / h er /t h eir h ei r o r h eir s
exec uto r /e xec u tor s r ef u s es /r ef u s e to av a il o f t he r e m a in i ng
in s t al l m e nt s a nd a l so r ef u s es o r r ef us e to c o m p l et e th e co ns tr uc t io n
o f the ho u s e a cc or d i ng t h e a pp ro v ed p l a n a nd es t i m at e w i t hi n on e
y ear af t er t h e d a t e o f d is b u rs em en t o f t h e f i r st in s t al l m ent o f t he l o a n
the w ho l e lo a n ad v a nc ed w it h i nte r es t s h al l b e l i ab l e to b e s u m m a ril y
r eco v er ed by t he p ro c e edi n g p r op er t y mo v a b l e or i m mo v a b l e o f th e
de c ea s ed M o r t g a go r /M o r tg a go r s u nd er t h e p ro v is i on s o f th e R ev enu e
R ec ov er y A ct, f o r t h e ti m e b ein g i n f o rc e a n d t h e r el ev a nt p r o v is i o ns
o f the Ka r n at a k a Bu i ld i ng a nd O th er Co ns tr uc ti o n W o r k er s
( R eg u l a tio n o f emp lo y m en t & Co ndi tio n s o f S er v i c e) R ul es a s i f s uc h
su m w er e ar r ea r s of p u b li c r ev en u e du e o n l a nd or s u c h o t h er m a n n er
a s t he M o rt g a g ee m a y de em f i t.
1 0. If t he he ir /h ei r s e xe cu to r s o f t he d ec ea s e d M o r t ga go r /M o r t g ago r s
do es /d o no t r eq u i r e th e b a l a nc e i n s ta l lm en t of th e lo a n a nd a r e
ho w ev er wi ll i ng to c o m p l et e t he co n s tr u ct io n a t h er /hi s /t h eir co s t
the a m o u nt a lr e ad y pa i d to t h e M o rt g a g o r/M o r tg a go r s o u t o f th e
s a nct io n ed l o a n wi ll b e tr e a t ed a s t h e ac t u al a mo u n t o f th e lo a n
s a nct io n ed a nd t h e r ec ov er y s h al l b e ef f ect e d at th e r a t e of
in s t al l m e nt pr esc ri b ed f o r t h at amo u nt of lo a n.
1 1. Th e M o r tg a go r /M o r tg a go rs sh a l l r em it t h e in s t al l m ent s i n t h e b a n ks
pr es cr ib e d b y t h e M o r tg a g ee i n t h e m a nn er s p e cif i ed f o r t hi s p u rp o s e
o r b y t h e c h a ll en p r es cr ib ed b y t h e K ar na t ak a B u i ld i ng a nd Ot h er
Co ns t ru c t io n W o r k er s W el f a r e Bo a r d.
1 2. If a n y i ns t a ll m en t o f p r i nc ip a l o r i nt er es t i s no t r em i tt ed o n t h e d u e
da t e s a p e nal i nt er es t a t t h e r a te of 5% i n a d di ti o n to t he u su a l r a t es
sh a l l b e p a i d a nd s u c h a m o u n t a s ar e no t p a i d o n d u e d a te s.
1 3. Th e lo a n a mo u n t s h al l b e u ti l i z ed o nl y f o r th e p u r po s e f o r w hi c h it i s
s a nct io n ed . E a c h i ns t al l m ent o f the lo an r ef er r e d to i n Cl a u s e 1 1
ab o v e s h al l b e u ti l i z e d w it h i n t h e ti m e l i m it pr esc r ib ed . In c a s e th e
M o rtg a go r /M o r tg a go r s f a i ls /f a il to c l a i m t h e s ub s eq u ent i ns t al l m e nt
wi t hi n t hr ee mo n t hs f ro m t h e d r aw a l o f t he p r ev i ou s i n s t a ll m ent s
su ch p r ev io us i ns t a l l m en t s ha l l b e tr ea t ed a s t h e l as t i n st a l l m e nt
un l es s t h e t i m e is ext end e d b y t h e mo rt g ag ee a nd r e co v er y sh a l l
co m m e nc e a s p r o vi d ed in th e t er m s a nd co nd i t io ns p r es c r i b e d f o r th e
gr a nt o f t h e lo a n.
1 4. If t h e M o r t g ago r /M o r tg a go r s f ai l s/f a i l to u ti li z e an y i ns t al l m e nt of
lo a n w it hi n th e m a xi m u m p e rio d ad mi s si b l e a nd do es no t a p p l y f o r
su b s eq u en t i ns t a ll m ent o f l o a n a s p ro v id ed i n th e c o nd i tio n s th e
en tir e a m o u nt alr e a d y d i s b ur s e d s h al l b e r eco v er a b l e f ro m
hi m /h er /t h em wi t h in t er est i n lu m p.
1 4. A . If the Mo r t g a gor /Mo r tg a gor s i s / ar e f o u nd to ha v e f a i l ed i n
ut il i zi ng t h e a mo u nt f o r th e c o ns tru ct io n o f ho us e a s s p ecif i ed i n th e
mo r tg a g e d eed w i t hi n th e p r esc r i b e d p er io d, t he mo r tg ag ee i s en ti tl ed
to r ea l i z e t h e ent ir e lo a n a mo u nt p l u s o t h er ch ar g es wi t h i n t er es t i n a
168
T HE S CH E DU LE A B O VE RE FE R R E D T O
( h er e ent er d et a il s o f a ll l a nd a nd bu i ld i n gs )
IN WIT NE S S W H E RE OF
Sr i. .. .. ... . .. .... ... ... .... .. . .. .. ... ... ... ... . ... .. .. ... . .. .... ... . T h e M o r t ga go r /s h er e to
s et hi s /h er /t h eir h a n d t he d a y a nd y ear f i r st a bo v e, w r i tt en s ig ned b y
Sr i /S mt. .. ... . .. ... . ... ... ... . ... ... . ... ... ... ... . ... . i n t h e p r es enc e o f w it n es s es :
1
2
S i gn ed b y S r i /S mt ... ... .... .. . ... .. .. ... . .. .... . .. ... ... . ... .. .. i n th e p r es e nc e of
wi t n ess es :
1.
2.
S T A GE CE RT I FI CA T E F O R R EL E A S E O F S E C ON D IN S TA L LM E NT O F
AD VA N C E S A N C TI O NE D B Y TH E K A R NA TA K A B U IL DI NG A N D
OT H E R CO NS T RU CTI ON W O RK E RS W E L FA RE B OA RD U N DE R
H OU S I NG L OA N S CH EM E
B EN E FI CIA R Y P R O P E RT Y
1 R e g. No .. ... .... .. . ... .. .. ... . ... ... .. . ... .. .. ... . ... Di s tr i c t. ... ... .... .. . ... .. .. .. . ... .... ...
2 N a m e.. .. . ... .. .. ... . ... ... ... . ... ... .. . .... . .. ... . ... . T a l u k. ... ... . ... .. . .... . .. ... . . .. ... ... . ..
3 A dd r ess ... ... . ... .. . .... ... .. .. ... ... ... ... . ... .. .. ... Vi ll a ge. .. .... ... ... .... .. . ... . ... ... .. .. .
4 S ig n a tu r e.. .. . .... ... ... .... . .. ... ... . ... .. . .... . .. ... S y. N o ... ... . ... .. . .... . .. ... . . .. ... ... . ...
T h e Co ns tr u c tio n o f b u ild i n g i n t h e p ro p er t y d et a il e d ab o v e b y th e
b en ef i c i a ry s p ec if i ed a b ov e h a s r ea c hed /co m p l etio n o f fo u nd at io n b a s em ent
a nd o n c o m p l eti o n wo r k u p to li n t el l e v e l/c om pl e t ion o f t h e li n t el
w o r k/ co mp l et io n o f t h e li n t er w or k a nd 5 0% o f t he w or k o f t h e r o o f an d
s to r ed t h e m at er i a l s f o r the w or k o f s hu tt e r s /co mp l etio n o f th e ro o f wo rk
a nd h as b een c o mp l e t ed 4 0 % o f t h e f i ni s h ed wo r k a s p er t h e pl a n and th e
b en ef i c i a ry is el ig ib l e f o r th e s eco n d i ns t a l lm en t o f t h e lo a n s a nc tio ne d b y
th e K ar n at a k a B u ild i n g a nd o t h er Co n str uc t i o n W o rk er s W e lf ar e B o ar d.
Cer t if i ed t ha t t he wo r k v a l u ed at R s. . ... ... . ... ... ... ... . ... .. .. h a s b ee n
ca r ri ed o u t b y t he b en ef ic i ar y a s o n. ... .. . ... .. .. ... .... . .. ... . .
P l a c e: Si gn at u r e of S ec ret a ry or an y
A ut h ori z e d o ffi c e r wi t h
na m e an d D e si g n at i on .
D at e: N a m e o f Of f ic e
170
FO RM - XV II
[See s ub-Rule (3) of Rule 43]
A pp l ic at i on f o r t h e p a y men t o f a ssi s t a nc e at t h e t i me o f D el i v e r y of a
Ch i l d b y a r e gi s t er e d wo ma n co n st ruc ti on wo rk e r
To:
T h e S ec r et a r y,
K ar n at a k a Co n s tr u ct i o n W o rk er s W e lf a r e Bo ar d,
B a n g a lo r e 5 6 0 . .
1. N a m e o f th e r eg is t er e d w o m a n co n str uc tio n w o r k er :
2. A dd r e ss :
( a) P erm a ne nt:
( b ) P r es ent:
3. A ge:
4. N at u r e o f w or k:
5. R eg is tr at io n N u m b e r a nd D a t e:
( X er o x co p y o f Id en ti t y Ca rd to b e en clo s ed )
6. ( a) P ar ti c u a l r s o f so n s or d a u ght er s of t he r egi s t er ed co ns tr u ct io n w o r k er :
S e ri a l Name Age M ar i t al st a t u s
N u m b er
( 1) ( 2) ( 3) ( 4)
7. P a rt ic u l ar s o f t h e so n o r d au g ht e r o f t he r eg is ter ed
co n str uc tio n wo r k er f o r who s e b ir t h t he as si s t a nc e
is so u gh t:
8. H as t hi s a ss i st a nc e u n d er c l a us e . . . Of th e
S ch em e b een a v a i l ed p r ev io u s ly, if so , f u r ni s h
de t a il s:
P l a c e:
S ig n a tu r e/T hu m b im p r es s io n of
D at e: t h e r eg is te r ed w o m a n co ns tr uc t io n wo r k er .
CE R TI F I CA TE
I h er e by c er ti f y t hat t he a b o v e p ar ti cu l ar s a r e co r r ec t.
P l a c e:
M em b er ,
D at e: K a rn a t a k a B ui l d in g an d Ot h e r
Con st ru c t i on W o rk e rs W el fa r e B o a rd
S A N CTI O N
1. I her eb y s a nc t io n a su m o f R s. 2 , 0 0 0 ( R u p ees T w o t ho u s a nd o nl y) to
th e r eg i st e r ed wo m a n c o ns tr u ct io n w or k er a s a s si s t a nc e f o r d e l i v er y o f a
c hil d.
P l a c e: S ec r e ta ry,
K a rn at a k a Bu i l di n g a nd
D at e: Ot h e r Con st ru ct i on W o rk e rs W el fa re Bo a rd .
171
FORM- XVIII
[See sub-Rule (2) of Rule 44]
.
Bangalore 560 ..
SANCTION
1. I hereby sanction a sum of Rs. 2,000 (Rupees tw o thousand only)
as assistance for the funeral of Sri / Smt. .. a registered
construction w orker.
2. I hereby sanction a sum of Rs. 5,000 (Rupees five thousand only)
as assistance on the natural death of Sri / Smt. a
registered constructi on w orker.
Place: Secretary,
Karnataka Building and
Date: Other Construction Workers Welfare Board
172
FORM- XIX
[See sub-rule (3) of rule 42]
.
Application for Educational Assistance
To:
The Secretary,
Karnataka Construction Workers Welfare Board,
..
Bangalore 560 ..
CERTIFICATE
I hereby certify that the above information is true and
correct to the best of my knowledge and belief.
Place:
Member,
173
SANCTION
1. I hereby sanction a sum of Rs. 750 (Rupees Seven
hundred and fifty only) / Rs. 1,000 (Rupees one thousand only) to
the claimant as education assistance.
Place:
Secretary,
Karnataka Building and
Date: Other Construction Workers
Welfare Boar d
*Strike out whichever is not applicable.
174
FORM- XX
[See rule 46]
.
Application to meet Medical expenses to a beneficiary
To:
The Secretary,
Karnataka Construction Workers Welfare Board,
Bangalore 560 ..
FORM-XXI
[See rule 47]
..
Application for assistance to a beneficiary in case of accident
resulting in death or permanent disablement (incapacitation)
To:
The Secretary,
Karnataka Construction Workers Welfare Board,
Bangalore 560 ..
Place:
FORM- XXII
[See sub-rule (3) (a) of rule 48]
.
To:
The Secretary,
Karnataka Construction Workers Welfare Board,
Bangalore 560 ..
Place:
FORM- XXIII
[See Rule 49]
To:
T h e S ec r et a r y,
K ar n at a k a Co n s tr u ct i o n W o rk er s W e lf a r e Bo ar d,
B a n ga lo r e 5 6 0 ..
1. N a m e o f th e r eg is t er e d c on s tr u ct io n wo r k er:
2. A dd r e ss :
( a) P erm a ne nt:
( b ) P r es ent:
3. A ge:
4. N at u r e o f w or k:
5. R eg is tr at io n N u m b e r a nd D a t e:
( X er o x co p y o f Id en ti t y Ca rd to b e en clo s ed )
6 ( a) D et a il s o f s on s o r da u ght er s o f t he r e gi st er ed co n st r u c ti on w o r k er :
S e ri a l Name Age M ar i t al st a t u s
N u m b er
( 1) ( 2) ( 3) ( 4)
( b ) N a m e o f the so n o r d a u gh t er o f t h e r egi s te r ed
co n str u c tio n w o r k er f or w ho s e m ar r i a g e t h e
a s s i s t a nc e i s so u g ht:
( c) H as m arr i a g e as s i st a nc e u nd e r cl a u s e o f
th e s c h em e b e en a v a il ed f o r a n y so n o f
d a u gh t er ? If s o , f u r n is h d et a il s :
P l a c e:
S ig n a tu r e/T hu m b im p r es s io n of
D at e: t he r egi st er ed co ns tr uc t i on w o rk er .
CE R TI F I CA TE
I h er e b y c er ti f y t ha t th e m ar r i a g e of Sr i / S m t. .. so n / d a ug h t er
o f w i t h K u m a r /K u m a r i s o n / d a ug h t er of
w i l l t a k e pl ac e o n .. . at ...
P l a c e:
M e mb e r of P a rli a m e n t o r M e mb e r
of L e gi sl at i v e A ss e m b l y or P r es i d en t o f
D at e: V i l l a g e P an c h a y at or M e m be r o f t h e
Loc a l B od y o r V i l l a ge A d mi n i st r at iv e O f fi c e r
i n wh o s e ju ri sd i c t i on t h e ap pl i c a n t r esi d e s.
S A N CTI O N
1. I h er eb y s a nc tio n a s u m o f R s. 1 , 0 0 0 ( Ru p e es o n e t ho u s a nd o n ly ) to
th e r eg is ter ed c o n s tr u ctio n wo r k er .
P l a c e: S ec r e ta ry,
K a rn at a k a Bu i l di n g a nd
D at e: Ot h e r Con st ruc t i on W o rk e rs W el fa re Bo a rd
178
FORM - XXIV
[See rules 86 (d)]
..
CERTIFICATE OF INITIAL AND PERIODICAL TEST AND
EXAMINATIONS OF THE LOOSE GEARS
Safe
Description, working
Distinguishing
dimension Test load load
number or Number Date of
and applied SWL)
mark tested test
material or tonnes) tonnes)
gear/device
Name and Initial test and Name and address Name and
Address of examination of public service position of
manufacturer certificate No. and association, competent person
supplies date (only in case company or firm or in public service,
of periodical test testing association,
and examination) establishment company or firm
making the test and or testing
(7) (8) examination
(9) establishment
(10)
Seal
Registration/authority number of the competent person
FORM - XXV
[See clause (a) of rule 90, schedule I]
.
REGISTER OF PERIODICAL TEST-EXAMINATION OF
LIFTING APPLIANCES AND GEARS, ETC.
PART-I
Initial and periodical load test of lifting appliances and
their annual thorough examination:
Thorough examination means a visual
examination supplemented if necessary, by
other means such as a hammer test, carried
out as carefully as the conditions permit, in
order to arrive at a reliable conclusion as to
the safety of the parts examined, and if
necessary, for such examination parts of the
lifting appliances and gear shall be
dismantled.
(A)
Initial and periodical load tests of lifting appliance
(B)
Annual Thorough examination
I certify that on the date to which I have appended my signature, the Remarks
lifting appliance shown in column 1) was thoroughly examined and (to be
no defects affecting its safe working conditions were found other signed
than those shown in column 12) and
dated)
Date and Date and Date and Date and Date and Date and Date and
signature Signature Signature signature signature signature signature
with seal with seal with seal with seal with seal with seal with seal
FORM XXVI
[See rules 90 (b) (i) (a), schedule I]
..
CERTIFICATE OF INITIAL AND PERIODICAL TEST AND
EXAMINATI ON OF WINCHES, DERRICKS AND THEIR
ACCESSORY GEAR
FORM - XXVII
[See rules 90 (b) (i) (b), schedule I]
..
Registration/Authority number
of the Competent Person
FORM- XXI X
[See rules 90 (b) (iii)]
.
I certify that the above particulars are correct and that the test
and examination were carried out by me and no defect affecting its safe
working load (SWL) were found.
Registration/Authority number
of the Competent Person
FORM XXX
[See rules 90 (b) (iv)]
.
Number of certificate
Distinguishing
Description of initial and
number or Remarks
of gear periodical test and
mark
examination
(1) (2) (3) (4)
(5) (6)
185
(b) Non-Fatal
Place:
Signature
Designation
Date:
..................................................................................................
..................................................................................................
6. Date of birth, if available.. .................................................... .
. . . and / or certificate of age ..............................................
7. Physical fitness............... ............................................ ....... . .
I hereby certify that I have personally examined
name)........... ... . . . . ........................................ son / daughter /
wife of ........................... ................. ................................. residing
at ...................................... .......who is desirous of being
employed in building and construction work and that his/her age
as nearly as can be ascertained from my examination is
..................................years and that he /she / is fit for
employment in ............................................
as an adult / adolescent.
8. Reason for :
................ . . . . . . . . . . . . . . ....................
Signature / Left hand thumb Signature with Seal
Impression of building worker Medical Inspector /
C.M.O
FORM - XXXIII
[See clause (g) of rule 242]
.
RECORD OF MEDICAL EXAMINATION / HEALTH REGISTER
(In respect of persons employed in building and other
construction work involving hazardous processes)
Name of the Construction Medical Of ficer / Medical Inspector:
a) Mr...........................From.......................to...........................
b) Mr...........................From.......................to...........................
190
c) Mr...........................From.......................to................................
FORM-XXXIV
[See s ub-R ule (a) of Rule 2 49]
.
FORM XXXV
[See rule 258]
.
FORM - XXXVI
[See clause (a) of sub-rule (1) of rule 259]
.
MUSTER ROLL
FORM- XXXVII
[See clause (a) of sub-rule (1) of rule 259]
.
REGISTER OF WAGES
Daily
rate of Amount of wages earned
wages Basic Dearness overtime Other cash Total
/ piece wages Allowances payments
rate (nature of
payment to
be
indicated)
(7) (8) (9) (10) (11) (12)
FORM- XXXVIII
[See p roviso to clause (a) of sub-rule (1) of rule 259]
.
building
workers
(1) (2) (3) (4) (5) (6)
1. 1.
2. 2.
3. 3.
4. 4.
5. 5.
FORM - XXXIX
[See clause (b) of sub-rule (1) of rule 259]
.
Nature of building or
other construction
work
196
FORM - XL
[See clause (b) of sub-rule (1) of rule 259]
.
REGISTER OF FINES
Name and address of Name and permanent address
Establishment where carried on of building or construction
/ is to be carried on. work establishment
FORM - XLI
[See clause (b) of sub-rule (1) of rule 259]
.
REGISTER OF ADVANCES
FORM - XLII
[See clause (c) of sub-rule (1) of rule 259]
.
REGISTER OF OVERTIME
FORM - XLIII
[See clause (a) of sub-rule (2) of rule 259]
.
WAGES BOOK
Name and address of the Name and permanent address
employer of Establishment
..................................................
Signature
FORM - XLV
[See R ule 260]
.
AN NU A L RE T U RN O F E M PL O Y E R T O B E SE N T T O T H E RE G IS TE RI N G
OF F ICE R
Y ea r endi n g 3 1 s t D ec em b er ... .... .. ... .... .. . .. ..
1. Fu ll n a m e an d f u l l ad dr es s o f t h e e st a b l i s hm e nt of th e bu i ld i ng a nd o th er
co ns tr u c tio n w o r k ( p l a c e, p o st of f i c e, D is tr ic t)
2. N a m e a nd p er m a n ent a d d r es s of t he es t ab l i s h m en t.
3. N a m e a nd a d d r es s of t he em p lo yer
4. N at u r e o f b u i ld in g a n d o t h er co n st r u c t io n w o r k c a r ri e d o n.
5. Fu ll n a m e o f t h e m a n a g er or p er s on r e sp o ns ib l e f o r s u p e rv is i on a nd
co ntr o l o f t h e e s t ab li s h m e nt
6. Nu m b er o f b u il d i n g w o r k er s o r d i n ar il y em p l o y ed.
7. To t al nu mb er o f d a ys du r i ng t he y ear o n w hi ch b u i ld i ng w o rk e r s w e r e
em p lo y ed
8. To t al N o . o f m a n d ay s wo r ked b y b u i ld i ng w o rk er s d u r i ng t h e yea r
9. Ma xi m um n u mb er o f b u il d i n g w o r k er s em p lo y ed o n a ny d a y d u r in g th e
ye ar.
1 0 . Th e nu mb er o f a cc i d en ts t hat to o k p l ac e d ur in g t he y ear a s u nd er :
(a ) Th e to t al nu mb er o f ac cid ents ;
(b ) Th e nu mb er o f a cc i de nt s r esu l ti n g i n di s a b l em e nt o f b u i l d i ng
wo r ker s f o r l e ss th a n 4 8 ho u r s , the nu mb er o f b u i ld i ng w o r k er s
in vo l v ed a nd t he nu m b er o f m a n- d a y s lo s t ;
(c ) Th e nu mb er o f a cc id ent s r es u lt i ng i n d i s ab l em ent of b u il d i ng w o r k er s
b eyo nd 4 8 ho u rs b u t no t r e su l ti ng i n a n y p er m a n en t p a r ti a l o r
p er m a n ent to t al di s ab l em e nt , t h e nu m b er o f b u il di n g w o rk er s
in vo l v ed , a nd t he nu m b er o f m a n- d a ys l o st o n a c co un t o f s uc h
ac c id en t s ;
(d ) Th e n um b er of acc id e nts r es ul ti n g i n p er m a n ent p a r t i al o r t o ta l
dis a b l em ent th e n u mb er o f b u i ld in g w o r ker s i nv o lv e d a nd t h e
nu m b er o f m a n- d ay s l o s t o n ac c ou nt o f s u c h a cc i d ent .
(e) Th e n u m b e r o f ac ci d ent s r es u lt i ng i n d e a t h o f b u ild i n g w o rk er s a nd
the nu m b er o f r es u lt a nt d ea th s.
T h e C hi e f I ns p ec tor or I ns p ec to r s ap po i n t ed by a S t at e
G o v er nm e nt u nd er t h e A ct s h a ll d ir ec t t h e o w n er s of es t a b l is h m en ts
r eg is t er ed u nd e r t h is A ct, to s end t h e c o p i es o f a n nu a l r e tu r ns su b m i tt ed
b y t he em p lo y er s o f r eg is t er e d es t ab l i s h m ent s i n r es p ec t o f t h e co nc er n ed
201
E mpl oy e r
P l a c e... . ... .. . ... .. .. ... . ... ... ... ....
D at e. .... ... ... .... .. . ... .. .. ... ... .... . ..