VESSELS OFOF NONCIRCULAR NONCIRCULAR CROSS CROSS SECTION SECTION Design shall comply with the applicable requirements Design shall comply of Subsection A except with wherethe applicable otherwise provided requirements for in of Subsection this Appendix.A except where otherwise provided for in this(a) Wall thicknesses of parts of vessels described herein Appendix. shall be determined by the appropriate formulas or (a) Wall thicknesses of parts of vessels described herein methods given in Subsection A and in this Appendix. shall be determined Since, in a rectangularby the appropriate or obround formulas vessel, the walls can or methods giventhicknesses, have different in Subsectionmany ofAtheand in thiscontained formulas Appendix. herein require solution by assuming a thickness, Since, in a rectangular or obround vessel, the walls can or thicknesses, and solving for stress which is then compared have different with thicknesses, the allowable stress value.many of the formulas contained herein require (b) Design solution according byAppendix to this assuming a thickness, is based on both membrane and bending or thicknesses, stresses.for and solving Membrane stresses is stress which duethen compared to pressure and mechanical loads shall not exceed the design withstress the allowable stress value. S, the value contained in the allowable stress (b) Design tables (seeaccording UG-23). At thetoweld thisjoint, Appendix is based on both these membrane membrane and stresses shall notbending exceed anstresses. Membrane allowable design stress SE,stresses due where E is a joint efficiency factor [see 13-5, 13-18, to pressure and mechanical loads shall not exceed the design UW-12, and UG-23(c)]. The joint efficiency factor E shall stress S, the value also be applied to thecontained in the allowable design allowable stress stress for evaluation tables (see of the UG-23). calculated At stress bending the weld joint, Sb at the these location of membrane the joint only.99 See 13-1(d) and 13-8(b). stresses shall not exceed an allowable design stress SE, where E is a joint efficiency factor [see 13-5, 13-18, UW-12, and UG-23(c)]. The joint efficiency factor E shall also be applied to the allowable design stress for evaluation of the calculated bending stress Sb at the location of the joint only.99 See 13-1(d) and 13-8(b).