OBJECTIVE ENGINEERING SPECIFICATION HC-74 To provide a structural steel
tubing material in square and rectangular shapes which has -: mechanical property requirements and provides good formability and weldability. II. SPECIFICATION Standard Grade ASTM A501 Hot Formed Welded and Seamless Carbon Steel Structural Tubing Chemical Composition (l ladle analysis) Carbon, max Phosphorus, max Surfur, max 0.26 0.040 0.050 Mechanical Property, minimum Tensile Strength, psi (M Pa) Yield Point, psi (M Pa) Elongation, in 8 in. 58.000 .(400) 36,000 (250) 20 Bend Test The bend test specimen shall stand, being bent the outside of the bent portion, to an inside thickness of the specimen as follows: Cold through 1800, diameter which has without-cracking on - a relationship to the Thickness of Material, in.(mm) 3/4!! (19.0) and tinder - Over 3/4 (19.0) to 1 (25.4) mcI. Dimensional Tolerances ,u - : Ratio of Bend Diameter to Specimen Thickness 1/2 1 - As specified in ASTFtSDJ or 501. Certification - The supplier shall include with each material or subcontracted lot shipped to Hyster Company a written statement certifying compliance with HC74 requirements signed by an authorized representative of the supplier. III. GENERAL INFORMATION (not part of requirements) Engineering Applications - - Tubing covered by this specification is intended for structural applications which - require minimum mechanical properties It may be used for parts which require cold forming operations such as overhead guard legs. - - - When round sections are required for structural tubing applications, specify HC7I pipe or HC75 drawn over-mandrel tubing. - - - - - Method of Specifying - Material HC74 - - - Dimensions related to product form shall be shown in the material block. THIS SPECIFICATION CONTAINS CONFIDENTIAL INFORMATION WHICHS THE PROPERTY OF HYSTER COMPANY. BY ACCEPTING THIS INFORMATION THE eORR0WER AGREES THAT IT WILL NOT DE USED FOR ANY PURPOSE OTHER THAN THAT FOR WHICH ITIS LOANEO. EFFECTIVE DATE (vI(Mo.4) 2002-12 I SUBJECT - Structural Tubing Welded and Seamless- Carbon. Steel - SPECIFICATION NUMBER HC74 I I Page 1 of 2 REV. No. 2 REVISED FROM (YIIMON.) 89/02 NACCO Materials Handling Group, Inc. F2.074O ENGINEERING SPECIFICATION HC-74 Manufacturing - - - - Recertification - Recertification of incoming materials or parts to a planned quality level will be performed consistent with product classification, vendor performance, and total quality cost. - Material Options - - - - - In some manufacturing areas, 45TH A500 Grade B cold formed welded steel structural tubing is more readily available. This grade may be substituted for hot formed tubing. It has higher mechanical properties and equivalent cold forming characteristics and weldability. Reference Specifications -- - - -- - - ASTM A500 Grade B Cold Formed Welded and Seamless Carbon Steel Structural Tubing ASTM A501 Hot Famed Welded and Seamless Carbon Steel Structural Tubing BS 7613 EN 10219-2 EN 10210-2 EN 10250-1 THIS Specification contains CONFIDENTIAL INFORMATION WHICH IS THE PROPERTY or HYSTER COMPANY. BY ACCEPTING THIS INFORMATION THE BORROWER AGREES THAT IT WILL NOT BC used FOR ANY PURPOSE OTHER THAN THAT FOR WHICH IT IS LOANED EFFECTIVE DATE (TI/MON) SUSJECT SPECIFICATION NUMSER REV. No 2002-12 WELDED AND SEANI.ESS CARBON NC74 2 REVISED FROM (fl/MON.) STEEL STRUCTURAL TUBING 89/02 Page 2 of 2 F2.0741 NACCO Materials Handling Group, Inc.
Welding for Challenging Environments: Proceedings of the International Conference on Welding for Challenging Environments, Toronto, Ontario, Canada, 15–17 October 1985