You are on page 1of 4

44

A depth of 2-00 m below bad level is carried out within the cofeedam . The water level within
the cofeedam is kept at excavation level by pumping. If the flow of water into the cofeedam is 0-
25 m/hour per unit length , what is the coefficient of permeability of the sand ? what is the
hydraulic gradient immediately below the excavated surface ?
The section and flow net appear in fig . 2.10. in the flow net there are 6-0 flow channels
and 11 equipotential drops. The total head loss is 4-50 m . The coefficient of permeability is
given by :

The distance between the last two equipotentials is measured as 0-9 m . The required
hydraulic gradient is given by :

2.5 Anisotrop Soil Conditions


It will now be assumed that the soil , although homogeneous , is anisotropic with respect
to permeability . Most natural soil deposits are anisotropic , with the coefficient of permeability
having a maximum value in the direction of stratification and a minimum value in the direction
normal to that of stratification n: these direction are denoted by x and z respetively , i.e.:
Kx = kmax and kz = k min
In this case the generalised form of Darcys law is :
44

Also , in any direction s, inclined at angle to the direction , the coefficient of


permeability is defined by the equation :
44

Sebuah kedalaman 2-00 m di bawah permukaan laut dilakukan dalam bendungan


tersebut. Tingkat air dalam bendungan disimpan di tingkat penggalian dengan memompa.
Jika aliran air ke bendungan adalah 0-25 m / jam per satuan panjang, bagaimana
koefisien permeabilitas pasir tersebut ? apa gradien hidrolik langsung di bawah galian
permukaan tanah ?
Bagian dan aliran bersih muncul dalam gambar. 2.10. dalam aliran bersih ada 6-0
saluran aliran dan 11 tetes ekuipotensial. Total kerugian adalah 4-50 m. Koefisien
permeabilitas diberikan oleh

Jarak antara dua equipotentials terakhir diukur sebagai 0-9 m. gradient hidrolik yang
diperlukan diberikan oleh:

2.5 Kondisi Tanah Anisotropic


Sekarang akan diasumsikan bahwa tanah, meskipun homogen, adalah anisotropic
sehubungan dengan permeabilitas. Sebagian timbunan tanah alami yang anisotropik, dengan
koefisien permeabilitas memiliki nilai maksimum dalam arah stratifikasi dan nilai minimum
dalam arah normal yang stratifikasi n: arah ini dilambangkan dengan x dan z masing-masing,
misalkan :
Kx = kmax and kz = k min
Kasus ini berdasarkan hukum darcy :
44

Juga, di setiap arah s, cenderung pada sudut ke arah, koefisien permeabilitas


didefinisikan oleh persamaan :

You might also like