Professional Documents
Culture Documents
Home Easy Electronic Projects Simple Circuits Ampliers with PCB Inverter Circuits Power Supplies More !
Categories
We is used to suggest a small integrated amplier or the power amplier with tone control circuit Were
combined on the same PCB are 20watt Integrated Amplier by TDA2005, but them is Mono.
Mini Projects (255)
Today we see the 19W stereo integrated amplier IC-TA7240AP, ideal for small rooms Or use the car
Inverters (30) because the power supply only 12 volts.
And the compact, buttons are placed on the PCB., To increase a convenient way to build. No wiring, you just
Battery & Charger (30) have to connect speakers, Enter the signals Ready to listen immediately.
Power supply (152)
Special feature
DC converters (42)
-Power amplier types : bridge ampliers
Basic Circuits (217)
-Output Power : 19 watts/channel at load 4 ohms 12volts.
Ampliers (154) -Wide supply voltage range: 9V to 18V.
-Supply current: over 1.5 amperes
Controls & Timers (130) Total Harmonic Distortion Noise(THD): 1% at 15 watts and 10% at 19 watts
Lightings (94) -Noise signal : lower than 0.14 mV
-The protection system : Thermal shutdown, over high voltage and short output.
Meters & Detectors (109) -Boost up rate of tone control : + 20dB
Digitals (90)
The working principle of circuit
RF Oscillator (87) In gure 1 Because of the two-channel circuit same, therefore, draw only one channel. The numbers in the
DIY Electronics (41) parentheses of IC1, is pin position in the circuit,other one channel.
In the tone control circuit, a signal ow to input through volume-VR1, which is adjuster a sound level as you
need.
They are C1, C2, SW1 and R1 as a loudness circuit, to boost up level sound to high and low frequencies.
While open low sound,if VR1 is turned up about halfway, the loudness circuit will do not works. When signal
Recent Posts through VR1 and VR2 that adjusted level sound between left and right channel to balance are : the loudness
button.
IC 4060 Timer project
The other way will be fed to the tone control circuit to adjust bass-treble sound level by: VR3 is adjusted as
5-30 minuts timer circuit using IC bass button and VR4 is adjusted as treble button.
555
The boost cut rate of circuit is approximately + 20dB then this signal will be entered to pin 2 through IC1
5LED Chaser-potentiometer using
amplify to pin 1.
arduino
The Button become Toggle Switch The some signal will be fed back to R5 and C7 to control level of the bass-treble sound.
using Arduino
The R6, R7 and C8 act as a reference voltage in to pin 3 of IC1 to the op-amp IC1 use with positive and
Adjustable LED asher-rst negative voltage.
potentiometer using Arduino
Which normally IC1 always required the positive, negative and ground power supply.
The signal is adjusted output pin 1 of IC1 through C11,act as the coupling signal in to the power amplier
IEEE Job Site sector. By in to C12, R8 and R9 are used to set amplitude of signal from the tone control sector that proper
feed to the power amplier sector.
Satellite
Communication
http://www.eleccircuit.com/19wstereoamplifiercircuitusingta7240ap/ 1/5
4/18/2017 19WstereointegratedamplifierICTA7240APElecCircuit
Communication
Systems Senior
IC2 is the amplier section, internally consists of two in one amplier , each set will have power output of 5.8
Home
Manager Easy Electronic Projects Simple Circuits
watts Ampliers
per channel, withwe
then when PCB Inverter
take them Circuits
to bridge together
soPower
causeSupplies
higher power
upMore ! watts per
into 19
Lockheed Martin channel.
Sunnyvale, CA
Since we set this both amplier that 180-degree phase difference the output to directly speaker. So signal is
Software boost up signal rise.
Engineering/Computer C13 is lter to protects internal IC voltage or the Ripple Filter.
Science Faculty
Position The C14, R11 And C16, R12 are the negative feedback.
Milwaukee School of
Engineering
C18 and C21 act as boost tap to add amplify gain of IC1 rise.
Milwaukee, WI
C17, C19 and C20 acts as protection oscillate in high frequency.
R13 and R14 are determined the gain of IC1.
Project Manager C10, C22,R10 are lter of the power supply to smooth.
Schweitzer
Engineering The building and applications
Laboratories, Inc. Both the power amplier circuit and the tone control circuit in same PCB, so very easy to build. Unnecessary
Tbilisi, Tbilisi wiring Avoid the extra time to create.
Systems Integration
Engineer - ELSYS -
1308
Georgia Tech Research
Institute (GTRI)
Lexington Park, MD
High Performance
Computing
Researcher SEAL 939
Georgia Tech Research
More Featured Jobs
Cautions to build are a position the IC pin, the polarity of the diode, electrolytic capacitors. Since this circuit
use quite a lot of the electrolytic capacitors, So be careful about the polarity is correct.
When put all components fully,then must attached the heat sink with TA7240-IC and to connect a ground to
all potentiometer to protects all noise.
Then later, connects the left and right signal to input and insert the power supply to the circuit, Ready to
listen to your favorite music now.
Semiconductor
IC1______LM1458, NE5532, LF353, TL072 the either number.
IC2, IC3___TA7240AP
D1_______1N5401 ___3A 50V Diode
Others.
PCB
Socket IC-8 pin
Heat sink.
toggle switch 6 lead.
Related Posts
Mini 40 watt audio car ampliers using TDA1562 datasheet-70w high car
HA13001 audio amplier
Power Amp Super Bridge 120W by IC Low voltage amplier circuit using
TDA2030 TDA7052
TDA2009 bridge amplier BCL 18W Bridge adapter circuit, stereo to high
http://www.eleccircuit.com/19wstereoamplifiercircuitusingta7240ap/ 3/5
4/18/2017 19WstereointegratedamplifierICTA7240APElecCircuit
TDA2009 bridge amplier BCL 18W Bridge adapter circuit, stereo to high
power mono amplier
Home Easy Electronic Projects Simple Circuits Ampliers with PCB Inverter Circuits Power Supplies More !
Small bridge amplier circuit diagram Car Audio amplier circuit 50W-65W
ONE COMMENT
Add a Comment
Your email address will not be published. Required elds are marked *
Marcelo
marczelo.f4@gmail.com
Website
ADD COMMENT
emailaddress
SUBSCRIBE
http://www.eleccircuit.com/19wstereoamplifiercircuitusingta7240ap/ 4/5
4/18/2017 19WstereointegratedamplifierICTA7240APElecCircuit
Home Easy Electronic Projects Simple Circuits Ampliers with PCB Inverter Circuits Power Supplies More !
Copyright 2017 ElecCircuit.com, All rights reserved. | Contact:: Facebook | Twitter | Google+ | Youtube | Feed
http://www.eleccircuit.com/19wstereoamplifiercircuitusingta7240ap/ 5/5