Professional Documents
Culture Documents
INTERIOR WORKS
01. Supplying and fixing of 1400 Sft
Gypsum board panel false Sft
ceiling using galvanized
sections for hanging and
holding the gypsum board
panels of 12mmtk with
approved design 5ht cornice
works alround duly painted
with three coats of plastic
emulsion paint after
necessary Pattiworks.
Provisions are to be made for
fixing of A.C.Grills, light
fittings as per consultants
instructions including making
holes and to assist in fixing
the same etc.,
02. Dismantling the Existing 170 Sft Sft
partition and providing full
height partitions of height
100 made of 3x2 salwood
frame work finished with 2
coats of termite resistant
coating (to be approved by
architect) with vertical
member at 106, level 80
level 40 level & floor level.
The frame work to be cladded
on both sides with 9mm thick
marine plywood and finished
with 1 mm thick decorative
laminate. Front portion with
5mm tk glass 20 Ht. The
partition to be provided with
TW skirting of size 3 x on
both sides and finished to
desired wood effect by
application of melamine
polish after initial surface
preparation. with all fixing
arrangements, locks and
hardwares etc complete.
(Appraiser)
03. Dismantling the existing 160 Sft Sft
partition and Supplying and
fixing of side partition for
Audit/Inspection room &
Power Room using
aluminimum anodized section
frame work with top, middle
and bottom portion with
marine plywood particle
board (9mm tk) and finished
with 1mm tk. Decorative
laminate, with all fixing
arrangements, EPDM rubber
gaskets locks and hardwares
etc complete.
04. Low Height Storage 40 Sft Sft
Low height storage made out
of 19mm marine plywood
particle board for top,
bottom.sides, shutter and
shelves with top finished
with 1mm tk. laminate sheet,
inner surface to be with 2
coats of enamel paint.
Size 53x13x
29(Officer
Cabin/Inspector cabin)
05. Officer Table
CLAUSE:
NOTE: