2123-4 CASES OF ASME BOILER AND PRESSURE VESSEL CODE
Approval Date: February 7, 2000
See Numeric Index for expiration and any reaffirmation dates.
Case 2123-4 (b) The minimum design temperature shall be
Use of ASTM A 240-93, 16Cr-4Ni-6Mn, Type 320F (196C). The maximum design temperature 201LN (UNS S20153) Plate, Sheet, and Strip for shall be +100F (40C). Pressure Vessels (c) The maximum allowable stress values shall be Section VIII, Divisions 1 and 2 27.1 ksi for Division 1;1 the maximum allowable design stress intensity value, Sm, in tension shall be 30.0 ksi for Division 2. Inquiry: Under what conditions may ASTM A 240-93 (d) Separate welding procedure qualification and per- UNS S20153 plate, sheet, and strip be used in the formance qualification shall be conducted in accordance manufacture of Section VIII, Divisions 1 and 2 welded with Section IX. pressure vessels for low temperature service? (e) The applicable rules of Section VIII, Division 1, Part UHA, or Division 2, shall be met. All cold formed materials resulting in an extreme fiber elongation by more than 4% as determined by UCS-79(d) formula for Division 1 and AF-605(a) for Division 2 shall be reheat-treated in accordance with (a), above. Reply: It is the opinion of the Committee that ASTM (f) For external pressure use Fig. CS-2, Section II, A 240-93 UNS S20153 may be used for the manufacture Part D, for both Division 1 and Division 2. of Section VIII, Divisions 1 and 2 welded pressure (g) This Case number shall be identified in the vessels for low temperature service provided the follow- documentation for the material and shown on the ing requirements are met. Manufacturers Data Report. (a) The heat treatment requirements are given in 1 The revised criterion of 3.5 on tensile strength was used in establish- ASTM A 480-93. ing this value.
125
COPYRIGHT American Society of Mechanical Engineers
Licensed by Information Handling Services COPYRIGHT American Society of Mechanical Engineers Licensed by Information Handling Services