P0088 FRP CONTROL SYSTEM A DTC Logic INFOID:0000000011599910
DTC DETECTION LOGIC EC
NOTE: If DTC P0088 is displayed with DTC P0090, first perform the trouble diagnosis for DTC P0090. C Trouble diagnosis name DTC No. DTC detecting condition Possible cause (Trouble diagnosis content) Fuel rail pressure remains at more D than 16.5 MPa (165 bar, 168.3 kg/ cm2, 2392.5 psi) for 1 second or more during engine idle condition after cold start [water temperature 5C (41F) - Harness or connector E HIGH FUEL PRES 40C (104F)]. (The high pressure fuel pump circuit is P0088 (High fuel pressure too high) The following condition continues for open or shorted) 5 seconds or more after engine start High pressure fuel pump (regardless of water temperature): F Actual fuel pressure Target fuel pressure 2.7 MPa (27 bar, 27.5 kg/ cm2, 392 psi) G DTC CONFIRMATION PROCEDURE 1.PRECONDITIONING H If DTC CONFIRMATION PROCEDURE has been previously conducted, always perform the following proce- dure before conducting the next test. 1. Turn ignition switch OFF and wait at least 10 seconds. I 2. Turn ignition switch ON. 3. Turn ignition switch OFF and wait at least 10 seconds. TESTING CONDITION: Before performing the following procedure, confirm that battery voltage is 11 V or more at idle. J Before performing the following procedure, check that the fuel tank is 1/8 full of fuel.
>> GO TO 2. K
2.PERFORM DTC CONFIRMATION PROCEDURE-1
1. Warm up the engine to the normal operating temperature and keep the engine speed at idle for 15 sec- L onds. NOTE: Warm up the engine until COOLAN TEMP/S on DATA MONITOR mode of ENGINE using CONSULT reaches at least 70C (158F). M 2. Check 1st trip DTC. Is 1st trip DTC detected? N YES >> Proceed to EC-523, "Diagnosis Procedure". NO >> GO TO 3. 3.PERFORM DTC CONFIRMATION PROCEDURE-2 O 1. Cool the engine until the engine coolant temperature reaches 60C (140F) or less. 2. Start the engine and wait at least 40 seconds. 3. Check 1st trip DTC. P Is 1st trip DTC detected? YES >> Proceed to EC-523, "Diagnosis Procedure". NO >> INSPECTION END Diagnosis Procedure INFOID:0000000011599911