You are on page 1of 2

Introduction

Gaydar is a colloquial term referring to the intuitive ability of a person to identify the
sexual orientation of homosexuals through verbal and non-verbal cues. In 1987,
Berger et al showed that humans have the innate ability to identify someones
sexual orientation in their research, "Detection of sexual orientation by
heterosexuals and homosexuals". [1]
However, according to Diane Richardson, one cannot automatically and intrinsically
detect sexual orientation of an individual based on physical appearance alone. One
must observe social interactions that reflect sexual identity before concluding. [2]
This is a reflection of the existence of a wide spectrum of gender identities and
expressions one exhibits. As noted by Alice Dan in 1997,
We found that there were just so many different varieties of combinations of self-
identification, of attraction to women and men, and sexual behavior, either current
sexual behavior or past sexual behavior, that well over 30 different groups were
defined by the combination of those variables,
In fact, definitions of different sexual orientations vary from study to study
depending on the measures the researcher established. [3]
This study aims to determine the different factors and their interactions in the
ability of heterosexual male engineering students of UP Diliman in detecting
homosexual women.
For the purpose of the research, lesbians are defined as women who are attracted to
women and identify themselves as lesbians. This scope covers those who identify
themselves as bisexuals and homosexuals. The researchers employed the Chicago
Women's Health Study (Hughes et al., 1997) as the measure of sexual orientation
for the volunteer lesbians and population of participants of the study.[3]
The motivation of the study is to spread awareness regarding the vast and wide
gender spectrum people may belong to and establish gender sensitivity.
METHODOLOGY
The experiment shall be analyzed using 2^k factorial experiment.

[1] Berger, G; Hank, L; Rauzi, T; Simkins, L (1987). "Detection of sexual orientation by heterosexuals and homosexuals". Journal of
Homosexuality.

[2] Hart J., Richardson D. (1981), 'The Theory and Practice of Homosexuality' London
[3] Solarz, A.L. (1999). Lesbian Health, Current Assessment and Directions for the
Future, Washington D.C.
MATERIALS ENGINEERING PAPER GUIDELINES (TITLE)
J.K. Cruz , A.Z. Cruz (Authors Names)
Department of Mining, Metallurgical and Materials Engineering
University of the Philippines Diliman, Quezon City, 1101
Abstract
The abstract is a summary of your research. It is written in the past tense and should not exceed 250
words. Include a brief introduction, an overview of the methodology, and the results. The abstract
should not contain any citations. The whole paper should be written in the third person point of view.
The font, font size, and layout of this paper should be followed for consistency. Deductions will be
given for not following this prescribed format. Finally, the full paper including references (but not
appendices) should not exceed five pages.
1. Introduction

The introduction should provide information needed by the readers to understand your research.
Define terms and parameters as needed. Explain the motivation and the significance of the study.
Clearly state your objectives and limitations. Please take note that you are not limited with the factors
given to you. Other factors may be included but make sure that it is of relevance and would improve
the data presentation. Make sure that any ideas coming from any source are properly cited.
Plagiarism (copying, translating, direct quotation, or whatever one may call it) is never tolerated in
the academe. The main objective of this first exercise is to be able to gather data and present in a
manner that would use the fundamental statistical concepts.
2. Methodology

Describe the methodology and metrology. State the number of respondents and
explain the design of experiment. Survey questions may be included in the
appendix section. Methodology must be written in a manner that the reader can
replicate your study.

You might also like