Professional Documents
Culture Documents
iPASOLINK VR Series
February, 2017
NEC
#1736
Contents
Service Enablement
Hierarchical QoS
Switch Bypass
Usability Enhancement
iPASOLINK VR specifications
Contents
Service Enablement
Hierarchical QoS
Switch Bypass
Usability Enhancement
iPASOLINK VR specifications
Ultra multi-level modulation (4096QAM) implementation
more
1Gbps
2048QAM
4096QAM
1024QAM 1Gbps
25% up
512QAM Commercial use
11% up
256QAM
56MHz 112MHz
1000M
500Mbps x2 bps
(56MHz/2048QAM) (112MHz/2048QAM)
1
sig2
4x4 MIMO
sig3
sig4
Quadruple capacity
* Theoretical value
on a single spectrum
N x Radio Capacity
8 radio links bundling
Full load-balancing
Full utilization
adaptive modulation
support
Radio Traffic Aggregation (RTA)
V V
1Gbps H H 1Gbps
28MHz 28MHz
Bandwidth Bandwidth
Maximizer Maximizer
Compressed
Payload
idx
FCS Payload Header IFG FCS Payload Header IFG
L2 Compression
preserved
IFG/PRE Suppression In addition, Lempel-Ziv based
data compression will be
available, if it fits on network
SLA.
56MHz/4096QAM (530Mbps/ch)
V V V V XPIC
H H H H
56MHz 56MHz56MHz56MHz
10Gbps
IPv4 IPv4
comp. comp.
10G 10G
Service Enablement
Hierarchical QoS
Switch Bypass
Usability Enhancement
iPASOLINK VR specifications
10G Optical Transport use cases
10G 10G
>1Gbps
Core
Metro Network
10G 10G
>1Gbps >1Gbps
Metro
10G
>1Gbps >1Gbps
Service Enablement
Hierarchical QoS
Switch Bypass
Usability Enhancement
iPASOLINK VR specifications
Service Enablement
HetNet Internet
(Small Cell)
* Future candidate
VPN
Hierarchical QoS helps to ensure QoS control for each services in the
network providing multi-service
Supporting hierarchical Ingress policing and Egress shaping / scheduling
Per Port
Per Port + QoS Class
Per Port + QoS Class + VLAN
When using same priority between each operators, Class queue will be separated between each
class queue will be shared with each operators. operators since it has class queues per VLAN even if
impossible to manage QoS control per each using same priority between each operators.
operators
> >
* Future candidate * Future candidate
MODEM
MODEM
MODEM
V
PHY
X CWDM
MODEM
CWDM
MODEM
Single fiber
MODEM
MODEM
MODEM
PHY
MODEM
L2 path L2 path
Includes through through
- Latency IDU IDU IDU
- Delay Variation
XPIC
CWDM
L2 aggregation
(statistical aggregation) V/H aggregation Lambda aggregation
(XPIC) (xWDM)
Service Enablement
Hierarchical QoS
Switch Bypass
Usability Enhancement
iPASOLINK VR specifications
Network performance analysis
Usage report
Path Configuration
Calculates according to the path parameter and creates optimum path,
then sets configuration of each NE by setting two end points.
Re-routing and network load-balancing
Detects the modulation change and then finds out optimum alternative
path, and reroutes before data rate degradation of affected VLAN.
BRM Controller
BRM Controller BRM Controller
Re-routing
Automatically
path creation Link
degradation
End-to-end
Provisioning
Service Enablement
Hierarchical QoS
Switch Bypass
Usability Enhancement
iPASOLINK VR specifications
Image for Backhaul and Fronthaul Convergence
For Fronthaul
80GHz
(CPRI)
RRH RRH
CPRI IDU
CPRI CPRI
CPRI 1G 80GHz
80GHz 10G (CPRI)
10G
Single fiber
60GHz 1G
CWDM RRH
60GHz/80GHz No Switch* for
For Small Cell ultra low latency CPRI CPRI
Physical connection
CWDM 2 x CPRI
1G
1G
10G
10G
1G 1G 1G
60GHz/80GHz
60GHz
80GHz
* Future candidate
TDM
Transport ETH / Layer-2 Switch
Network
Architecture TDM PWE
MPLS-TP
H-QoS
QoS Prioritization
Bandwidth Management (Policy)
SyncE
Synchronization
1588v2 TC,BC TC,BC TC,BC
Radio port
2 5 12
E1 port 64 224
16
(16p+3x16p) (14x16p)
STM-1 port (RST) 6 28
-
(3x2p) (14x2p)
STM-1 port (channelized) 3 14
-
(3x1p) (14x1p)
GbE port (RJ45) (w/o PoE) 10 8
4
(4p+3x2p) (4x2p)
GbE port (SFP) 10 8* *Until Rel2.0: 7p
2
(4p+3x2p) (4x2p) (Port 4 on slot12 is not available)
10GbE port (SFP+) 2
- 2* *Port7/8: SFP or SFP+
(2x1p)
CWDM card
- 3 14
Radio port
2 5 12
E1 port 64 224
16
(16p+3x16p) (14x16p)
STM-1 port (RST) 6 28
-
(3x2p) (14x2p)
STM-1 port (channelized) 3 14
-
(3x1p) (14x1p)
GbE port (RJ45) (w/ PoE) 2 6
- Future candidate
(2x1p) (6x1p)
GbE port (RJ45) (w/o PoE) 16 32* *Rel.4: 4x4p (4xRJ45 GbE card)
4
(4p+3x4p) (4x4p+2x8p) Future: 4x4p+2x8p(New GbE card)
GbE port (SFP) 16 16
2
(4p+3x4p) (4x4p)
10GbE port (SFP+) 2
- 2* *Port7/8: SFP or SFP+
(2x1p)
CWDM card
- 3 14
Maximum port number
MSE card is needed for PWE function
Specifications are subjected to be changed without notice
16xE1 card
Interfaces chSTM-1 with APS option card
4xGbE card (RJ45x2 + SFPx2 / RJ45x4 / SFPx4)
Optional - MSE card (64xE1 TDM PWE)
CWDM Filter card
10GbE card
MODEM-AV - - Available*1
(112Hz / 4096QAM)
MODEM-EV*2 - Future candidate Available
(without XPIC cable)
N x RTA (2 x RTA) Available (up to 8) Available (up to 8)
iPASOLINK VR10
1588v2
10G INF H-QoS (BC/TC)
Increased # of MPLS-TP/
GbE INF SDN
2 x RTA
F
A
N CS112M/
3 slot FAN control
iPASOLINK VR4 4096QAM
1588v2
H-QoS (BC/TC)
SDN 2 x RTA
400/400A VR4
1000 VR10
IAG IAG
MODEM-A MODEM-A
Equivalent to 512QAM*3 Equivalent to 512QAM*3
MODEM-EA/MODEM-EV MODEM-EA/MODEM-EV
Equivalent to 2048QAM IAG2 IAG2 Equivalent to 2048QAM
MODEM-AV MODEM-AV
Equivalent to 4096QAM Equivalent to 4096QAM
MDOEM-EA - OK OK*1 OK -
MODEM-EV*2 - OK OK*1 OK -
MIMO - - - OK
MODEM*3
*1 : Up to 56MHz/2048QAM
*2 : R4.0 or later
*3 : Future candidate
VR2 OK OK OK OK OK OK
VR4/VR10 MODEM-EA/EV OK OK OK OK OK OK
100A/200A OK OK OK OK OK OK
400A MODEM-EA OK OK OK OK OK OK
400/1000 MODEM-EA OK OK OK OK OK OK
iX OK OK OK OK OK OK