Professional Documents
Culture Documents
Best of Luck for Your Competitive Exams 7. In which case there is maximum extension in the wire, if
same force is applied on each wire
1. When a certain weight is suspended from a long uniform
(a) L = 500 cm, d = 0.05 mm
wire, its length increases by one cm. If the same weight is
suspended from another wire of the same material and (b) L = 200 cm, d = 0.02 mm
length but having a diameter half of the first one then the
(c) L = 300 cm, d = 0.03 mm
increase in length will be
(a) 0.5 cm (b) 2 cm (d) L = 400 cm, d = 0.01 mm
(c) 4 cm (d) 8 cm
8. In solids, inter-atomic forces are
2. The material which practically does not show elastic after (a) Totally repulsive
effect is
(b) Totally attractive
(a) Copper (b) Rubber
(c) Steel (d) Quartz (c) Combination of (a) and (b)
NEET -2 TEST SERIES TEST -3 (BULK PROPERTIES OF MATTER & FLUID MECHANICS)
density of the material is 3 103 kg / m3 , then the length of area of the wire is 106 m2 , calculate the youngs modulus
of the material of the wire
the wire which will break by its own weight will be
(a) 34 m (b) 30 m (a) 2 1011 N / m2
(c) 300 m (d) 3 m 4
l(10 4) m
(b) 2 1011 N / m2 3
16. There are two wires of same material and same length (c) 3 1012 N / m2 2
while the diameter of second wire is 2 times the diameter of 1
first wire, then ratio of extension produced in the wires by (d) 2 1013 N / m2
applying same load will be 20 40 60 80 W(N)
(a) 1 : 1 (b) 2 : 1 21. Two bodies are in equilibrium when suspended in water
(c) 1 : 2 (d) 4 : 1 from the arms of a balance. The mass of one body is 36 g
and its density is 9 g / cm3. If the mass of the other is 48 g,
17. An elastic material of Young's modulus Y is subjected to a its density in g / cm3 is
stress S. The elastic energy stored per unit volume of the 4 3
material is (a) (b)
3 2
2Y S2 (c) 3 (d) 5
(a) (b)
S2 2Y
22. A vertical U-tube of uniform inner cross section contains
S S2
(c) (d) mercury in both sides of its arms. A glycerin (density = 1.3
2Y Y
g/cm3) column of length 10 cm is introduced into one of its
arms. Oil of density 0.8 gm/cm3 is poured into the other
18. Two rods of different materials having coefficients of linear
arm until the upper surfaces of the oil and glycerin are in
expansion 1, 2 and Young's moduli Y1 and Y2
the same horizontal level. Find the length of the oil column,
respectively are fixed between two rigid massive walls. The Density of mercury = 13.6 g/cm3
rods are heated such that they undergo the same increase
in temperature. There is no bending of rods. If Oil
Glycerine
h
1 : 2 2 : 3 , the thermal stresses developed in the two (a) 10.4 cm
10 cm
rods are equally provided Y1 : Y2 is equal to (b) 8.2 cm
(a) 2 : 3 (b) 1 : 1 (c) 7.2 cm
(c) 3 : 2 (d) 4 : 9 (d) 9.6 cm
Mercury
19. The potential energy U between two molecules as a
function of the distance X between them has been shown in 23. A cylinder of height 20 m is completely filled with water.
the figure. The two molecules are The velocity of efflux of water (in m/s) through a small hole
on the side wall of the cylinder near its bottom is
U
(a) 10 (b) 20
(c) 25.5 (d) 5
0 X
24. An application of Bernoulli's equation for fluid flow is found
in
(a) Dynamic lift of an aeroplane
A B C (b) Viscosity meter
(a) Attracted when x lies between A and B and are repelled (c) Capillary rise
when X lies between B and C (d) Hydraulic press
NEET -2 TEST SERIES TEST -3 (BULK PROPERTIES OF MATTER & FLUID MECHANICS)
(b) l increases and h decreases 37. 8 mercury drops coalesce to form one mercury drop, the
l energy changes by a factor of
(c) Both l and h increase
h (a) 1 (b) 2
(d) Both l and h decrease
(c) 4 (d) 6
30. A vessel contains oil (density = 0.8 gm/cm3) over mercury 38. Two small drops of mercury, each of radius R, coalesce to
(density = 13.6 gm/cm3). A homogeneous sphere floats form a single large drop. The ratio of the total surface
with half of its volume immersed in mercury and the other energies before and after the change is
half in oil. The density of the material of the sphere in (a) 1 : 21 / 3 (b) 21 / 3 : 1
gm/cm3 is
(c) 2 : 1 (d) 1 : 2
(a) 3.3 (b) 6.4
(c) 7.2 (d) 12.8
NEET -2 TEST SERIES TEST -3 (BULK PROPERTIES OF MATTER & FLUID MECHANICS)
the larger bubble grows at the expense of the smaller one less than that at the top.
(d) The air flows from the larger (b) Bubble rises upwards because pressure at the bottom is
greater than that at the top.
40. The radii of two soap bubbles are r1 and r2. In isothermal (c) As the bubble rises, its size increases
conditions, two meet together in vaccum. Then the radius
(d) As the bubble rises, its size no change
of the resultant bubble is given by
(a) R (r1 r2 ) / 2
(b) R r1(r1r2 r2 )
(d) R r1 r2
41. When a large bubble rises from the bottom of a lake to the
surface, its radius doubles. If atmospheric pressure is equal
to that of column of water height H, then the depth of lake
is
(a) H (b) 2H
(c) 7H (d) 8H
NEET -2 TEST SERIES TEST -3 (BULK PROPERTIES OF MATTER & FLUID MECHANICS)