Professional Documents
Culture Documents
OPERATION MANUAL
In order to keep elevator run comfortably and safely, please read this manual carefully
before putting into service. This manual introduces to you the right operation method.
The improper operation will cause accident. Keep this manual for reference.
2 Operation Manual for Passenger Elevator Operation Manual for Passenger Elevator 3
.General Introduction of Product and Its Constructive Name 3)Machine-Roomless elevator
1)General Introduction
The elevator can be used at public buildings ,office ,apartment ,and hotel
Which has already installed safety device.
C/ P
Traction Machine
C/ P
<C/P in jamb>
Governor
Rail
Hall Door
Note) the above picture will change according to difference elevator mode, please refer to design paper.
MRL:Machine-Roomless
4 Operation Manual for Passenger Elevator Operation Manual for Passenger Elevator 5
2. Safety Device
Safety gear
Hall Door
Jamb Stop the elevator safely through the activity of governor.
Hall button
Safety edge
In case of clipping passenger when closing door. Door operator
Lighting Ventilation
Photo-electric Safety Device
Install photo-electricsafety device on door.
Car Position Indicator Detect whether passengers or goods is at the door.
And then decide to open or close the door.
Car Door
Interphone
Operation panel
6 Operation Manual for Passenger Elevator Operation Manual for Passenger Elevator 7
2)Notes for Passenger
Do not close car door in case of clipping The old and children take elevator under
When opening or closing the door. the supervisor. It will cause accident by
Follow the tips on elevator. Overload will Do not jump in car it will cause the safety Be careful, especially when you take
cause accident, do not do it. wrong operation by children when elevator
device actived. children or pets. stops because some special situation.
Emergen
cy call
Do not let dust fall into sill. Press button by hands. Use umbrella or some Do not load goods in passenger elevator . Elevator stops between two floors by accident
sharp things will damage the button.The buttons, It will cause accident when it is too heavy or power cut. Do not try to escape from car.
besides open door button, close door button or large. It is dangerous to get out through car door or
emergency call button, are all used by manager emergency exit, because it may cause fallen
accident. You should press emergency call to
or technical personnel .Do not touch. contact outside for helping.
10 Operation Manual for Passenger Elevator Operation Manual for Passenger Elevator 11
3.Notes in Operation Process
Warn
Buffer For the safety of passenger, please abide by the following rules.
Interlock
Keep the hall door locked. When one hall door is open ,
.Notes for Operator(or manager personnel)
Elevator can not run.
When elevator operator gets sick or tired, please report the manager personnel .
When operation is finished, park the elevator at setting floor, turn on stop switch,
Interphone in Car
Lock the key switch box and report it to manager personnel.
When occurs emergency incident,
contact with outside through interphone
No problem of handwheel, brake release lever when taking emergency
8 Operation Manual for Passenger Elevator Operation Manual for Passenger Elevator 9
3) Notes for Manager Personnel
Machine Room
Warn
Stuff Only
Do not smoke in car. In order to prevent fire. Keep an eye on the floor you reaches.
Especially in emergency rescue. Enter into car until door is completely opened.
1.Manager Personnel 2.Machien Room
The manager personnel should be familiar Lock machine room .In order to go smoothly,
with rescue measure and contact with
relevant department. when manager personnel do not put aside too much thing beside
is out, find a deputy to take care. machine room.
Fire Extinguisher
Do not open door by force. It will cause When bring umbrella or liquid into car .
fallen accident, when door opens suddenly. Do not let it slip into hoistway. 3.Machine Room Inside 4.Hall Door
Prevent rain or snow enters into machine When water enters into hoistway, it will destroy
room, it will affect T/M,C/P. normal run. Be care when clean elevator with
Equipped with fire extinguisher. Water.
12 Operation Manual for Passenger Elevator Operation Manual for Passenger Elevator 13
4)Notes for Hall Door Key
Notes .Open hall door by hall door key when elevator stops caused by fault and
passengers are trapped in car.
.Do not use others keys except for special designed key for hall door.
It will be the reason for fault.
Warn
.Do not let other person take key for hall door and key switch box except for
manager personnel. It may cause fallen accident because of improper using
of hall door key.
5.Hall Door 6.Car Inside
After hall door is opened, check whether car .Use hall door key to open hall door about 5cm and check whether car is at
Only tips about safety can be sticked on car.
cage is at this floor and then enter into car. this floor. Keep body balanced, lean back ,open the door.
Behind the hall door is hoistway when car is not at this floor. So be careful.
(When car is not at this floor ,close hall door.)
7.Using Neutral Detergent to clean Operation Panel 8.Forbit to keep door open by using things blocking door
Erosive chemical material will erase the Let an operator to help when moving house.
mark and number on operation panel. Take some protective board to protect car wall and ground.
14 Operation Manual for Passenger Elevator Operation Manual for Passenger Elevator 15
4.Operation Methods
5)Operations for Hall Button and Car Operation Panel 1)Type of Operation
Atuo
Hall button Car Operation Panel Method without elevator operator. Elevator run automatically according to hall and car call.
(Door open and close are also automatically.)
Indepent(option)
Elevator runs according to UP and DOWN button in operation panel. It will stop at the
floor and door open automatically. But you need press the close door button until door closed.
16 Operation Manual for Passenger Elevator Operation Manual for Passenger Elevator 17
2)Construction of Car Operation Panel 3)Operation of Car Operation Panel
Floor Button
18 Operation Manual for Passenger Elevator Operation Manual for Passenger Elevator 19
4)Operation Method for Key Switch Box 1.Power Switch
POWER
Park car a one floor.
Warn Press switch to [OFF],elevator opens door and turns off light.
When press switch to [OFF] during running, elevator stops at
.Only elevator operator can operate switch in key switch box.
bottom floor and turns off light.
OFF
.Operator leaves car with key switch box opened may be the reason for accident.
20 Operation Manual for Passenger Elevator Operation Manual for Passenger Elevator 21
6.Attendant Switch 12.FIRE2 Switch
AUTO
Press switch to [ATT],door is open and waiting for operation. OFF The elevator can run with door opened which will be convenient
Elevator can change running direction according to operator. for rescuer to operate in fire operation. Only FIRE1 switch is on
ON and FIRE2 switch can work. The UP and DOWN button can only
Operator needs pressing close door button until door is closed.
Elevator is respond to destination floor call after door is closed. be used once.
When press PASS button ,it is not respond to hall call.
FIRE2 Notes
ATT Do not use except for maintenance personal, fireman,
rescue personnel.
7.Fan Switch
FAN
Turn on or turn off the car fan.
13.UP Button
Press switch to [FAN] and car fan is on and vice versa. UP
Change elevator's running direction(independent &inspection mode)
ATTENDANT operation: Press button to change to UP running
OFF Direction, when elevator stops.
INSPECTION operation: press button and car runs slowly.
Using top floor button to stand for UP running button.
8.Independent Switch(option)
AUTO
There are many elevators in building. Specify one elevator
for independent operation to use this switch. 14.PASS Button
PASS
Press switch to [IND] for independent operation.
Only in attendant mode.
Press switch to [AUTO] for automatic running.
IND Car is respond to car call only(not respond to hall call).
9.ODD&EVEN Switch(option)
ODD
Stop car at odd floor or even floor only.
Press switch to [ODD], car stops at odd floor.
Press switch to [EVEN],car stops at even floor.
Press switch to middle position , car stops at any floor. 15.DOWN Button
EVEN DOWN
Change elevator's running direction(independent &inspection mode)
OFF Fireman turns on switch for fire operation when occurs fire.
Press switch to [FIRE1] for fire operation.
ON Press switch to [OFF] to turn off fire operation.
Notes
FIRE1 Do not use except for maintenance personnel, fireman,
rescue personnel.
22 Operation Manual for Passenger Elevator Operation Manual for Passenger Elevator 23
5)Ready for Running
6)AUTO Operation
And elevator starts to enter into auto operation. OFF E-STOP HAND DR OFF ATT
According to demand of customers, elevator stops when door is in open or close status.
Press hall button at car stops floor, the door will open .
Press the other hall button ,elevator will go to that floor
and open door automatically.
During the door closing process, press the same direction hall
button as elevator running direction, door will open right now.
Elevator stops at one floor
Press close door button and the door will close right now.
OVERLOAD
24 Operation Manual for Passenger Elevator Operation Manual for Passenger Elevator 25
7)Attendant Operation 8)Independent Operation(option)
in auto mode ,press switch to [ATT]. Independent operation is designed for sending patient in
DR ON AUTO PASS ODD AUTO hospital. Turn on independent switch and elevator only
responds to car call.
when turn on attendant switch, door is in open status. Press the destination floor button and press close door
Elevator operator registers the destination floor and button until door is closed. During closing door process,
press close door button to close door. During closing door will reopen when release button.
Door, release close door button and door will reopen.
when elevator reaches destination floor, door will open
automatically. But door will not close automatically,
it remains in open status.
PASS
when there are too many passengers in car, press After independent operation is finished, turn switch
PASS button to pass through directly. Elevator ODD AUTO to [AUTO].Or elevator stops running.
does not respond to hall call.
EVEN IND
26 Operation Manual for Passenger Elevator Operation Manual for Passenger Elevator 27
5.Troubelshoot/Emergency Rescue Measure
<Precautionary Measure>
.For safety running and prevent accident ,please do
Elevator Parks at Base Floor maintenance on a regular basis.
Turn off park switch at hall indicator to enter into stop mode. .Plan rescue measure for emergency accident.
(It is necessary for maintenance personnel and
elevator manufacture to inspect.)
Press park switch to [OFF], elevator will not enter into stop mode immediately.
Turn off park switch ,elevator responds to all registered floors with
the same running direction as elevator. Then park to specified floor.
Reaches destination floor ,open the door ,cancel all registered floor. After 20
seconds, buzzer rings 3 times ,close the door, turn off all the light and
position indicator.
<Using Tips When Happens Accident>
Elevator does not respond to any call in this situation. When elevator happens fire ,power cut and other accident,
Accoring to demand of customer ,the elevator could stop with door open. open hall or car door to get passenger out of cage. But
be care in case fo fallen accident.
Others should not keep hall door key, except for manager
Elevator parks at one floor personnel.
Before using key to open hall door, please check
Open the key switch box.
elevator's location and status.
Press POWER switch to [OFF], elevator enters into stop mode.
(According to different mode, it may set power switch to [POWER] to stop mode.)
Press POWER switch to [OFF], elevator will not enter into stop mode immediately.
Set power switch to [OFF] when elevator stops at one floor ,door will Open ,
light will be off and enter into stop mode.
Set power switch to [OFF] during running ,elevator stops at bottom floor , <Using Tips When Happens Accident>
.Emergency exit on car top only can be used by elevator
open the door and turn off light.
Confirm Notes manufacture and maintenance personnel for rescuing passengers.
.Using interphone to confirm the following things
when rescuing passenger.
location of elevator.
Warn the number of passengers.
there are the old ,young, sick, pregnant in car or not.
Do not take above measure except for maintenance and manager personnel.
car door is open or not.
It may be different according to different type.
28 Operation Manual for Passenger Elevator Operation Manual for Passenger Elevator 29
2)Emergency Rescue Tips
Elevator stops because of power cut
When receive elevator accident from passenger, make right judgement, give proper instruction
1.If power supply will recover in a short time ,please tell passengers
to passenger ,take correct measure. Or manager personnel take emergency measure in person.
to stay in car.
2.After power recovers ,tell passengers to press destination floor button
-It does not work. Press floor and close door button to let elevator run.
2.The above method can not work. Manager personnel and rescuer should.
Open door by hand through door operator on car top to get passengers Happens fire, earthquake, water leak and such kind of accident.
out of car
1.Let passengers get out of building through safety stairway.
3.After finishing above measure ,analysis the reason of accident to prevent it.
2.According to real situation to stop running elevator.
Elevator stops between two floors 4.Take effective action. Let specialist to solve the case.
with personnel in machine room. When children trapped in car ,they are very afraid .
- The other 2 personnel, one presses brake lever and another
enhance safety education about elevator.
moves handwheel.
- 3 personnel cooperate with each other to rescue passenger .
The distance between sill and car location is above 150~600mm. Brake lever
Brake lever
Handwheel
Using brake lever to place elevator to door zone and then rescue passengers.
(Turn off main power. Using interphone to confirm car door is not opened and
no one is crossing car door )
Press brake lever repeatedly to let elevator go slowly. Pressing brake lever
for a long time will cause elevator run fast which may lead accident. So be careful.
( Adjust elevator location through the mark on main rope)
The above job need 2 personnel to cooperate with each other to finish.
Notes: It will be different according to variable mode.
Above
Below
32 Operation Manual for Passenger Elevator Operation Manual for Passenger Elevator 33
Warn
5)Troubleshooting Tips
Machine-Roomless Elevator For solving trouble and reducing stop time caused by fault, please know the situation when
(1)Brake release lever in C/P happens trouble. Contact HYUNDAI service center when you can not solve the trouble.
For machine-roomless elevator, using foot or hand brake release lever to release
brake to rescue passengers. Item Trouble Type Reason Measure
There is obstruction in hall sill.
(STVF) (STVF) (ELEX) (ELEX)
Safety device of door is not
Good.(door,safety shore switch)
Door open and Open and close door button
close is not well. is not good Clean sill and guide
Door
Fuse of door is broken. Whether open door button
<Foot brake release lever> <Hand brake release lever> <Hand brake put down> <Hand brake release lever> There is obstruction in hall is locked
Cut off main power(or it will cause accident) door guide. Contact with HYUNDAI
Connect brake release lever and its line There is obstruction in sill. Service Center
<Brake contactor in C/P.> (STVF) NoiseVibration Door shore is distorted.
.Short contact of brake contactor's output side. Abnormity of door open
and close.
Take off short line of main circuit when brake contactor is on.
Abnormity of controller
. Release lever to change elevator's location to rescue passengers. Running is
. Adjust brake contactor to OFF. Take off short line. Safety switch is active.
not good
<Brake> Fuse is broken
.Release brake release lever by 0.5sec repeatedly.
There is obstruction in hoistway.
Through check point to confirm elevator's location. Running
The above job need 2 personnel to cooperate with each other to finish. Noise,Vibration Not enough oil
Please be operate directly like pictures when machine- roomless elevator Abrasion of rail guide Contact with HYUNDAI
is ELEX type.
Abnormity of LCD Service Center
(2) Brake release lever in machine room LCD is not good Adjustment of brake is not good
Connect lever to brake to release .shown as picture beside. Overload
The brake contactor has shorted line in C/P, you need not Confirm key status of
key in key switch box should
do anything in electric work. key switch box
Call respond be off
Call respond Contact with HYUNDAI
is not good Abnormity of controller(Solve fault)
Hydraulic elevator <brake release lever in C/P> Service Center
Abnormity of fuse
For hydraulic elevator ,using manual valve to change elevator's location.
The procedure is as follow: Abnormity of light change light
Light& Light &indicating
Cut off main power(or it will cause accident) Indicating lamp lamp is not good Abnormity of fuse Contact with HYUNDAI
Using hand valve in machine room to change elevator's location Service Center
and rescue passengers in car. Abnormity of interphone power Contact with HYUNDAI
Interphone is not interphone circuit is not good
The above procedure should be done by 2 personnel Interphone Well, buzzer not Service Center
Ring Abnormity of interphone
Misoperation
Abnormity of controller Contact with HYUNDAI
Warn The above procedure may be different according to different mode. Others Stops between
The job should be done by manufacture and technical personnel. 2 floors Abnormity of control Service Center
Abnormity of fuse
34 Operation Manual for Passenger Elevator Operation Manual for Passenger Elevator 35
6.Manage Tips
It needs maintenance to keep safety and prolong its life. 2.Only elevator manufacture or maintenance can take maintenance business.
3.After elevator has been installed, HYUNDAI offer free service in warranty period. 3.Maintenance company has its own maintenance criterion which is accord with
(after that we charge according to elevator maintenance contract) "Elevator Installtion, Supervision ,Check, Periodic Check Standard".
4.We offer free service in first 3 years under correct operation and management. 4.Elevator Features
But the substitute and expendable are not including it. We do not take responsibility for 1)No limit for user
problem caused by misoperation. 2)Used by many people
3)Heavy load
5.Elevator manage tips including measures of customer and maintenance company. 4)Caused by accident
5)Casualty when happens safety accident
2) Terms 6)Maintenance on spot
1.MaintenanceAction for solving trouble or precaution. 7)Complex construction, hard to maintenance
2.Periodic Check: Maintenance personnel to check, maintain, clear elevator every month. 8)Long maintenance time
Adding lubricant ,adjustment ,changing substitute. 9)Has big fluence when happens accident. Need to fix in time.
3.TroubleshootingMaintenance personnel who has certificate to fix trouble when happens 5. Problem of Choosing Maintenance Company
accident. 1)Is there any elevator specialist
4.Maintenance Personnel:Person with elevator maintenance certificate . -Because elevator consists of many mechanical part,
only specialist can deal with trouble quickly.
-Only maintenance personnel with certificate can do maintenance job.
36 Operation Manual for Passenger Elevator Operation Manual for Passenger Elevator 37
4)Manage Measure 5)Management of Maintenance Personnel
The items about passenger in Remark should done by manage side
1.For safety of passengers, confirm all Warn signs and its position.
Rules about
1.Check Items in Machine Room
manufacture and 2.The elevator needs education training .
Periodic Check
management on NO. Check Items Items (Per/Month) Remark
law and 3.According to safety supervision rules ,check by self. Keep record in 2 years. Confirm Warn, Notes sign
1.0 Common items 1/1
Management 4.When finding trouble ,stop car and take proper measures. If Warn, Notes sign is broken or off ,change new ones
Content No obstacle
5.Apply and take periodic inspect every year.
1.1 Door to Machine Room Lighting facility 1/1 Passenger
Door locked
No irrelevant device in machine room
According to law ,take corresponding punishment if not obey the above content. Light ,ventilation in Lighting and ventilation is good
1.2 1/1 Passenger
machine room
Keep temperature at 0-40
1.For safety of passengers, confirm all Warn signs and its position.
No rain from windows and proof
Handwheel
1.3 Direction of handwheel ,brake release lever 1/1
2.Chose maintenance personnel to check and manage elevator.
No damage and abrasion
3.When happens abnormal situation during running, inform maintenance Distribution Box Passenger
Fixed well
personnel and take proper measure to prevent accident. 1.4 1/1 (Distribution Box)
Control Panel No heat, vibration
4.Keep cage clean. Take education about correct operation of elevator. Switches work steadily
Rules for safety
Please refer to"Notes in Operation" No aging .No not enough lubricant
operation and
Management 5.Light in elevator not belongs to maintenance range. Elevator operator can 1.5 Reduction Gear Abrasion and corrosion of gear surface has not effect on car running 1/3
change light if happens abnormal situation. Ask for help of maintenance
personnel when meets trouble. Abrasion of groove sheave should be within standard value
Entered rope depth of groove sheave is above 1mm
Traction Machine
6.Clean sill. When there is obstacle in sill, it will cause trouble. Height between 2 main ropes is within 2mm
38 Operation Manual for Passenger Elevator Operation Manual for Passenger Elevator 39
Periodic Check
NO. Check Items Items Periodic Check
Remark NO. Check Items Items Remark
(Per/Month) (Per/Month)
Abrasion of groove sheave should be within in standard value No aging and damage of button&switch
Traction machine
No vibration noise caused by abrasion bell ring when pressing alarm button
1.11 Governor Normal work of safety gear 1/6 2.5 Interphone 1/1
No shaft damage
Communication among car , machine room, duty room is normal
Periodic Check
NO. Check Items Items Remark
(Per/Month)
same standard as item 1.0 3.Check Items in Car Top
2.0 Common items 1/1
"
Periodic Check
Car wall,ceiling No heavily distort, abrasion, rust, erasion, corrosion NO. Check Items Items (Per/Month) Remark
2.1 1/3 Passenger
and flooring
can not use flammable material
40 Operation Manual for Passenger Elevator Operation Manual for Passenger Elevator 41
Periodic Check
NO. Check Items Items Periodic Check
Remark NO. Check Items Items Remark
(Per/Month) (Per/Month)
Abrasion of groove sheave should be within in standard value No obvious abrasion, rust, corrosion
Distance between car and hall door is within 30mm
Rotate smoothly
3.3 Upper pulley of car 1/6 3.12 Hall door and sill 1/1
No abnormal noise
Open/close door well
Avoid abrasion
No obvious distortion ,prolongation , rust of main rope 1/6
3.4 Rope of governor 1/6 3.14 Traveling cable
No obvious abrasion, rust, corrosion of connection part
Avoid damage of cable connection part
3.15 Hoistway wall No other irrelevant device of elevator (fire sensor ,broadingcast) 1/12 Passenger
Treatment of end terminal
42 Operation Manual for Passenger Elevator Operation Manual for Passenger Elevator 43
Periodic Check
NO. Check Items Items Remark
(Per/Month)
Keep clean
5.3 Flooring 1/1
No water
The above "Check Items" will change according to different project and technical update.
The check of group control board, voice synthesizer, remote controller has another
management operation.
According to customer's demand, the installation of CCTV, Card system, air condition
not belongs to management and quality control of HYUNDAI elevator.