jacket away from the cable and untwist the wire pairs.
Cut the Cat5E
Ethernet cable that you need.
Using the crimper tool insert
the connector and cable into 8 wire slot and press down tightly. You are now finish terminating one end of the cable. Repeat the process on the other of the cable and when you are done. Test your cable by using it on your network.
Trim the ends of the wires. Holding an RJ-45
connector with the tab side facing down, push the 8 wires into the connector, sliding each wire into a groove.
Assemble the pairs of wires in the
following order for network cables.
3 Insert the wires into the RJ45. Be sure to keep the wires in the correct order.
Using an Cat5 cutter and
crimping tool, strip about 1/3 of the out jacket of the cat-5 cable.
Cross-over Cable
Insert the RJ45 connector into
the crimping tool. Crimp down firmly on the crimping tool to permanently attach RJ45 to the CAT5 cable.