| College of Engineering & Computer Science
| Department of Mechanical Engineering stu MEC-430 Machine Design
Time allowed: 75 minutes March 26, 2014
Please Note:
* Examination s open book, but ONLY one text book and your notes are allowed. You may use any non-communicating
caleulator. No electroni
* Make sure your name and studént number is written on the question sheet. Answer questions in allocated areas. You
‘may use the back of the page if necessary.[Il] The figure shows a shaft carrying a gear with diameter D with 3
forces; P,, P:and P, as shown. Identify the forces on the shaft in
the two planes, xy and xz. Identify possible reactions at the
bearings assuming that the bearing at point-A is a combined roller
and thrust bearing. Assume that the torque is transmitted through
the shaft from the left side of bearing-A and draw the NFD, SFD,
BMD, TD. @5 Points)
!