‘ABU-DHABI UNIVERSITY RK college of Engineering & Computer Science
MEC-430 Machine Design
| Department of Mechanical Engineering snes
| quiet =a March 12, 2014
Please Note:
ber is written on the question sheet. Answer questions in allocated areas.
* Make sure your name and student n
nu may use the back of the page
A floor crane shown in figure is used to pick up a
load of 3 KN. The cross section of the horizontal
top member is a solid rectangular with the
dimensions shown in figure. It is required to:
* Find reaction forces and draw all internal force
diagrams for link ABC.
* Plot the stress distribution at section S- just to
the left of point-B as shown in figure.
* Determine the principal stresses at the top fiber
of cross section S-S just to the left of point-B as
shown in figure, Neglect any stress
‘concentration factors.Citic pois Yin ob Sites
pal Mawes ,
We tT. phid. New groexe or}
Tt a
ae peetiol wit
Rw. phase
RE al
tre tie Bitte, 0 2) dire
Boe, AB