Professional Documents
Culture Documents
MACH3
EPP
EPP BIOS
PCI USB
Reminder:
1
installation
MACH3 Mach3.exe
1, Open folder named MACH3, then double-click the Mach3.exeinstaller
file, starting installing.
NEXT
2, As shown, click NEXT.
YES
1
Next
4, Click Next, or select the install path according to your own needs.
Next
5, Click Next as shown.
Next
6, Click Nextas shown.
7, Click OKas shown.
Finish
8, Click Finishas shown.
9, Click OKas shown.
10, Click OKas shown
Mach3
By this point, installation of Mach3 has been finished. Three generated
desktop icons will be shown on your computer screen. Please pay attention
to that: dont click any icon right away, just restart your computer first
and then open the mach3 software.
mach3
2
settings
ConfigSelect Native Units MM`s
1, ConfigSelect Native Unitsset the unit as MM`s as shown below.
8
Motor Outputs
3, Motor Outputsset it as follows:
9
PS
1A B
Enabled X
1, Setup parameters about the fourth axis (A axis) and the fifth axis (B axis) are shown as pictured
above. If you havent installed the fourth axis and the fifth axis, please tick X over the
Enabled option.
Dir LowActive
Set the positive and negative rotations of stepping motor as shown below, then be sure to click
applications
10
11
A Axis: 17.777
1000
500
effective.
3
Trying out your engraving machine
Self-test
Mach3
Turn on the driving power switch and open the Mach3 control software, then manually,
respectively and orderly turn the hand wheels of XYZ on stepping motor. If you feel
the resistance during the rotating course, that is to say the three axes work properly.
13
)
If the variable frequency motor is controlled directly by the transducer, the spindle
speed button wont work. Finally, please keep in mind that once the transducer parameter
is matched, it cannot be changed. Also please make sure to turn on the water plump first
before starting the variable frequency motor.
The correct rotation direction of the spindle motor is shown as follow:
clockwise rotation
14
OK
15