Professional Documents
Culture Documents
program had a mix of successes and failures, but did birth the wildly
popular Mars Pathfinder/Sojourner rover mission that landed in 1997.
NASA started building cheaper spacecraft under the Mars Surveyor program. MGS
at just $154 million (excluding launch costs) in 1996 dollars was to be the first
of a series of spacecraft launching every 26 months. The Mars Surveyor concept
was altered after two Mars spacecraft failed in 1998.
Early days on Mars
MGS launched successfully on Nov. 7, 1996, on board a Delta II rocket. From its
launch pad at the Kennedy Space Center, it bounded into orbit and then fired its
engines again to accelerate towards Mars. Ten months later, on Sept. 12, 1997,
MGS successfully made it into orbit at the Red Planet.
To save on the cost of hauling fuel to Mars, mission planners used a new
technique aerobraking to finalize MGS in its orbit around the planet. MGS
pushed against the atmosphere gradually in its first several months at Mars to
put itself in the final orbit. This technique proved so successful that it was used
again for the Mars Reconnaissance Orbiter and Mars Odyssey missions.
Mars Global Surveyor photographed the "Face on Mars" in greater detail.
Credit: NASA/JPL/Malin Space Science Systems
One of MGS' first targets was the "Face on Mars," an infamous feature snapped
by the orbiting Viking 1 spacecraft on July 25, 1976. The shadows appeared to be
a human face gazing up at the sky, which sparked a generation of conspiracy
theories on Earth.
MGS passed over the same location at the Cydonia region on April 5, 1998, to get
a more detailed look. Although NASA already knew the "face" came from a trick
of shadows, MGS' pictures were in higher-resolution and were used by the agency
to debunk the theory. The European Space Agency confirmed the finding in
pictures taken with Mars Express in 2001.
NASA carefully selected its first targets to include areas of public interest. Other
spots that MGS imaged in the early days included the Viking landing sites and the
Mars Pathfinder landing site.
A planet in flux
Mars, revealed by MGS, was a rapidly changing planet that probably had a
different environment in the past. Pictures in February 1998 showed apossible
ancient river channel. Other snapshots over the years showedslowpoke dunes,
regolift drifts and sandsheets on the surface, suggesting that wind was a big
factor in shaping Mars history.
As MGS skimmed the planet from pole to pole, it tracked changes in carbon
dioxide ice deposits near the south pole of Mars. After three Martian summers of
observations, data from MGS revealed that the deposits were shrinking a
possible indication of climate change.
The spacecraft mapped Martian terrain with a laser altimeter, detected traces of
magnetic fields with its magnetometer, and mapped at least 20 new impact
craters between the time it started operations and the time it fell silent.
When MGS spotted hematite a mineral that forms in water from orbit, the
discovery spurred NASA to land the Opportunity rover in a hematite-rich area.
Just weeks after landing, Opportunity found hematite "blueberries" just a short
distance from where it touched down in Meridiani Planum.
End of the extended mission
MGS lasted four times longer than its design lifetime, but the end came rather
unexpectedly. On Nov. 2, 2006, controllers ordered MGS to shift its solar panels
a routine adjustment. The spacecraft reported back several errors, but the
transmission also indicated that things had stabilized. Then MGS fell silent.
"The spacecraft reoriented to an angle that exposed one of two batteries carried
on the spacecraft to direct sunlight," read a NASA press release describing the
most likely cause of the failure.
"This caused the battery to overheat and ultimately led to the depletion of both
batteries. Incorrect antenna pointing prevented the orbiter from telling controllers
its status, and its programmed safety response did not include making sure the
spacecraft orientation was thermally safe."
NASA tried for weeks to get in touch with the dead spacecraft, with no success.
An independent review board determined that the MGS team did follow the
correct procedures to help the spacecraft, but added that the procedures
themselves were not strong enough to "catch the errors that occurred".
The agency pledged it would overhaul its procedures to improve other Mars
missions. Indeed, NASA has since had more success in resurrecting spacecraft
that had software problems.
A notable example is the Mars Odyssey mission, which has entered safe mode
several times but been successfully recovered. Odyssey, as a side note, is
currently the longest-running Mars mission with more than a decade in service.
But it was MGS that got there first, and that paved the way for more Mars
missions to follow. The spacecraft kickstarted a new age of Martian exploration,
and provided the first detailed look at the Red Planet in a generation.
Still contributing
Although MGS' mission is long over, there still are occasional science results
publicized in the media. For example, in March 2016 NASA released an improved
gravity map of Mars that in part used data from MGS. The goal of the map is to
better understand variations in the Red Planet's gravity to track the geological
history of Mars, such as the differences between the northern lowlands and the
southern highlands.
In 2013, researchers suggested that Eden Patera, previously believed to be a
crater basin, may instead be remnants of an ancient supervolcano. Based on data
in part from MGS, researchers noted a lack of ejecta debris in the region as well
as features that usuallly point to volcanism, such as "bathtub rings" created when
lava recedes from the area.