Professional Documents
Culture Documents
24.
25.
a. Earth continuity
b. Continuity
c. Open circuit
d. Verification of polarity
26.
c. Mechanical protection
d. Neatness of finish
An electrical conduit is to be
installed on the surface of a wall;
however it is to cross an already
installed conduit. Which of the following
is the best way of overcoming this
obstacle?
a. termination
b. connection
c. jointing
d. soldering
31. Which of the following symbols
represents an intermediate switch?
a.
b.
28.
c.
d.
32.
33.
c. Green
d. Blue
39.
The current rating of 2.5mm2 single
PVC cable is
a. 15 amps
b. 16 amps
c. 21 amps
d. 28 amps
40.
a. Controlling device
b. Junction box
c. Conductor
d. load
35.
36.
37.
42.
(B)
(C)
38.
(D)
43.
Insulation
Polarity
Earth leakage
Earth continuity
44.
48.
49.
be
a. twisted and terminated anticlockwise
b. stranded and terminated clockwise
c. twisted and terminated clockwise
d. twisted and terminated either clockwise or
anticlockwise
46.
50.
High voltage
Short circuit
High resistance
Low resistance
45.
Low resistance
Easy termination
High resistance
Smooth current flow
100 ohms
400 ohms
Less
Doubled
Male end
Lock nut
Bonding nipple
Metal strap
CASE STUDY
INSTRUCTION: Read the following case then answer correctly the questions that follows in the
space provided.
William, an electrician employed to Nedricks Electrical, was given the task of completing an
installation for a TWO (2) bedroom board house. On completion, he was recalled by the
customer due to discomfort expressed of having the light switch placed behind a door. The
customer also complained of lights dimming when operating the blender.
When his supervisor came to rectify the concerns he further found SEVEN (7) outlets protected
by one circuit breaker in one case.
1. What regulations did William not conform to?
___________________________________________________________________
___________________________________________________________________
___________________________________________________________________
2. What are the possible reasons that would lead to the lights slow, periodical or non-response?
___________________________________________________________________
___________________________________________________________________
___________________________________________________________________
3. What test should be carried out when finding the fault in this circuit?
__________________________________________________________________