Professional Documents
Culture Documents
Isolated Inverter
This inverter is electrically isolated between the battery and secondary voltage.
This allows earthing of both DC and AC circuits when required. It will deliver up
to 1000 watts of continuous power, while supplying surge currents up to a
massive 2500 watts. DC input is through two 850mm, 6 gauge leads with very
heavy duty alligator clamps. The output is two standard 3 pin mains sockets.
There is a rocker on/off switch, and LED indicators for power and fault. This
unit also features fan assisted cooling.
Typical Applications:
Lamps and flourescents up to 1000W, 68cm televisions and VCRs, power
drills, blenders, belt sanders etc.
Specifications:
Output Power Continuous: 1000W
Output Power Surge: 2500W
Standby Current: <800mA
Input Voltage: 10-15VDC
Output Wave Form: Modified Sine Wave
Efficiency: >90%
Size: 310(L) x 205(W) x 75(H)
Weight: 5.0kg
Circuit Protection:
Thermal Shutdown and Alarm: 60°C +/-0.5°C (Automatic Recovery)
Battery Low Alarm: 10.5VDC +/- 0.5VDC
Battery Low Shutdown: 10.0VDC +/- 0.5VDC
High Battery Shutdown: 15.5VDC +/- 0.5VDC
External Fusing: 140A Maximum
Top of Form
91 91
Bottom of Form
Dimensions: These solar Panels are
designed for 12 volt rechargeable battery
systems. The Panels consists of 36 pieces
of single crystal silicon cells in series with
built-in blocking diode in the circuit to block
reverse flow of current to the panel at night
time. These Solar Panels are constructed to
withstand the rigors of weather. They are
waterproof, rustproof, shockproof, corrosive
and humidity resistant. Reinforced, but
lightweight housing makes it more popular
in marine, outdoor pack-packing and
camping environment.
PRODUCT SPECIFICATION:
LDR:
GEAR MOTOR: A gear motor consists of two gears, the
driven gear (attached to the output shaft by way of a key,
etc) and the idler gear. High pressure oil is ported into
one side of the gears, where it flows around the periphery
of the gears, between the gear tips and wall housing in
which it resides, to the outlet port. The gears then mesh,
not allowing the oil from the outlet side to flow back to
the inlet side.