Professional Documents
Culture Documents
Petrophysics
7 WIRELINE LOGGING
INTRODUCTION
In this session, wireline logging is introduced. The subsequent chapters presents the
measurement principles, interpretation and evaluation techniques of the basic open
hole logging tools. The fundamentals of interpretation of gamma ray, density,
neutron, resistivity, wireline formation tester and the spontaneous potential logs are
explained. The techniques for determination of lithology, net reservoir, porosity, fluid
type/ distribution, water saturation and free water level are demonstrated. Working
knowledge of these techniques is acquired from tutorials, which include basic
evaluation of sets of logs. No pre-knowledge of wireline logging is assumed.
After working through these chapters, the reader should be able to:
v Define and determine basic reservoir rock properties
v Describe the basic principles of the common open hole logging tools
v Perform basic interpretation and evaluation on a standard set of open hole logs:
reservoir boundaries, lithology, net reservoir, porosity, fluid type/ distribution,
Archie equations, water resistivity, water saturation, fluid contacts and free water
level from pressure-depth plot
DEPTH MEASUREMENT
The depth is measured along hole (AHD) in meters below derrick floor (mbdf). When
the bottom of the tool string touches the drill floor the depth measurement is set at
zero. The distance between the various tool detectors and the bottom of the tool
Martey, A.O
7.1
Univation
Petrophysics
string is automatically compensated by the computer in the surface logging unit. The
length of cable in the hole is measured with an accuracy of around 0.1 %.
In vertical wells the AHD is equal to the true vertical depth (TVD). In deviated wells, a
deviation survey is needed to calculate the TVD from the AHD. The TVD is often
expressed in meters below a local datum, e.g. meters subsea (mss).
LOG HEADER
Data, crucial for the evaluation, can be found in the log header:
v Well name and location
v Date
v Drill floor elevation (DFE)
Martey, A.O
7.2
Univation
Petrophysics
LOG TYPES
Logs, which are used to quantify the hydrocarbon in place can be classified into
three families:
v Reservoir Thickness: Gamma Ray, Spontaneous Potential. These logs
discriminate reservoir from non-reservoir.
v Porosity: Density, Neutron, Sonic. These logs are used to calculate porosity,
identify lithologies, differentiate oil from gas.
v ResistivIty: Laterolog, Induction, Microresistivity. These logs, together with
porosity logs, are used to calculate hydrocarbon saturation.
Other types of wireline tools are:
v Side Wall Sampler: Takes small rock samples, which are used for lithology and
fluid type confirmation
Martey, A.O
7.3
Univation
Petrophysics
v Wireline Formation Tester: Measures formation pressures and can retrieve fluid
samples
v Dipmeter and Formation Micro-Scanner: Measure dip and azimuth of reservoir
layers
v Well shoot and Vertical Seismic Profile: Used to calibrate seismic
CORRECTIONS
Large and irregular boreholes can adversely affect the accuracy of the
measurements. The log corrections needed in these cases can be quantified using
charts available in logging contractorsLog Interpretations Charts.
Martey, A.O
7.4
Univation
Petrophysics
In a quick look evaluation one can limit the amount of blocks by taking average
readings over intervals with more or less constant log responses. The block
boundaries must be at the same depth on all involved logs.
Martey, A.O
7.5
Univation
Petrophysics
Tutorial
Two logs from a vertical well are plotted below. Block these logs and read off the
values for each block, such that the results could be used for a quick look evaluation
Hint: Around 11 blocks are needed.
You are advised to keep your results as they will be required in later tutorials.
Martey, A.O
Univation