Professional Documents
Culture Documents
AUTOMATION STRATEGY OF
MHPP Mamasa
automation
of
hydropower
station
is
full
automatic
process,
and
is
able
to
accurate
and
real-time
data
communicate etc with the scheduling department at the next higher level.
Generally it includes five subsystems.
SCADA (supervisory control and data acquisition) is a system that
operates with coded signals over communication channels so as to
provide control of remote equipment (using typically one communication
channel per remote station). The control system may be combined with a
data acquisition system by adding the use of coded signals over
communication channels to acquire information about the status of the
remote equipment for display or for recording functions. SCADA systems
are used to monitor all the parameters of the power plant and its
supporting tools. In principle, SCADA systems are used to maintain the
rotation of the turbine so that all the electrical parameters of both voltage
and frequency can be maintained. Rotation of the turbine is set by
adjusting the governor means regulate the amount of water into the
1 | Page
AUTOMATION STRATEGY
FEED MHPP Mamasa
AUTOMATION STRATEGY
FEED MHPP Mamasa
&
load
control
Once reached to Rated RPM in Auto mode, controller will start
synchronization & once all the condition are met, controller will
close the generator breaker & regulate the machine to given power
set point. This power set point can be changed either by Touch panel,
or by Analog input or by Modbus command.
Mechanical Protection
All the RTD connected to Turbine Controller are measured continuously
& once Temperature rises above given set point Turbine Controller will
give suitable alarm or Trip. Text & protection set points for RTD are
freely configurable from Touch Panel & can be changed easily.
Electrical Protection
Turbine Controller is built in protection unit in it. It measures the
voltage (of generator & mains) & current of generator & carry out the
necessary protections. All the set points & time delay for protection
function can be changed by Touch panel.
2.
3 | Page
AUTOMATION STRATEGY
FEED MHPP Mamasa
disconnect between the system and the load. It is used to secure the
load / customers from excess voltage.
3.
are
also
used
for
detecting
parameters
to
be
4 | Page
5 | Page