Professional Documents
Culture Documents
COM
Mahendra Institute of Technology, Mahendhirapuri
Department of Electronics & Communication Engineering
Name of the Faculty: J.Vijay anandh
Name of the Subject: Satellite Communication (080290077)
V+ TEAM
WWW.VIDYARTHIPLUS.COM
3. Explain in detail about TVRO.
4. Write short notes on MATV and CATV.
16 Mark Question bank for Unit V Satellite Applications
1. Write short notes on (i) VSAT (ii) Radarsat.
(8+8)
2. What is meant by DTH? What are the design issues to be considered for launching DTH systems?
3. (i) Discuss in detail about the Global Positioning Satellite system.
(ii) Write brief notes on the advantages and disadvantages of using satellites in LEOs, MEOs and
GEOs for mobile satellite communications.
(8+8)
4. (i) Explain the applications of GPS system.
(ii) Explain about Satellite Mobile Services.
(8+8)
5. Write short notes on (i) INTELSAT series (ii) INSAT (iii) INMARSAT.
(6+5+5)
6. Explain (i) Direct Broadcast Satellites (DBS) (ii) Digital Audio Broadcast (DAB)
(iii) GRAMSAT.
(5+5+6)
7. Discuss about (i) Business TV (BTV) (ii) Digital Video Broadcast (iii) GSM.
(5+5+6)
Two marks
Unit I Orbit Dynamics
1. Distinguish between mean anomaly and true anomaly.
2. List out the frequency bands used for satellite services.
3. State Keplers second law of planetary motion.
4. What are geostationary satellites?
5. What are polar orbiting satellites?
6. What is sub-satellite point? What is its significance?
7. What is sun transit outage?
8. What is the difference between a geostationary orbit and a geosynchronous orbit?
9. Define apogee and perigee height.
10. Mention the 3 regions to allocate frequency for satellite services.
Unit II Space Segment and Link Design
1. What is meant by Hohmann transfer orbit?
2. What is meant by momentum wheel stabilization?
3. What is meant by input back off of a transponder?
4. Give the formulae to compute the uplink carrier to noise ratio.
5. What is a transponder?
6. Define noise figure.
7. What is frequency reuse?
8. Write about station keeping.
9. What is polarization interleaving.
10. What is intermodulation noise?
Unit III Satellite Access
1. What are the limitations of FDMA-satellite access?
2. Distinguish between pre-assigned and demand-assigned TDMA satellite access.
3. What is CDMA?
4. Mention the merits and demerits of TDMA over FDMA.
5. What is the function of burst code?
6. What is single access and multiple access technique?
WWW.VIDYARTHIPLUS.COM
V+ TEAM
WWW.VIDYARTHIPLUS.COM
7. What is meant by freeze out?
8. What is SCPC?
9. What is meant by decoding quenching?
10. Define guard time.
Unit IV Earth Segment
1. In most satellite TV receivers, the first IF band is converted to a second fixed IF. Why is this second
frequency conversion required?
2. Define earth segment.
3. Define S/N ratio.
4. Explain about MATV system.
5. What is noise weighting?
6. Explain about CATV.
7. What is an EIRP?
8. Define noise factor.
9. What is noise power spectral density?
10. Define saturation flux density.
Unit V Satellite Applications
1. Give the applications of satellite.
2. What are the various compression standards used in satellite applications?
3. What is the orbital spacing of satellites?
4. What are VSATs?
5. Mention the objectives of Radarsat.
6. What is transponder capacity?
7. List out the INSAT series.
8. What is dilution of precision?
9. Give the satellite mobile services.
10. Give the frequency range of US DBS systems with high power and medium power satellites.
Prepared By
(P.RAJESH KUMAR,AP/ECE)
WWW.VIDYARTHIPLUS.COM
Approved By
(V.SENTHILKUMARAN,HOD/ECE)
V+ TEAM