Professional Documents
Culture Documents
2013-3-25
1 , 8
Contents
1
2013-3-25
2 , 8
The solutions in the document are the operation method for particular alarm.
Actually, sometimes the different alarms will rise in a site or sector. One alarm may
be caused by another. Hence, we need to distinguish the priority of these alarms
when handle them. The structure of the document follows the priority (like the
contents).
3 , 8
Exampl e. t xt
Antenna
R
R
C
C
ANT0
ANT1
TMA
NodeB0
N0B
RET
AISG cable
NodeB1
N1B
RFU
. .
N0A
2013-3-25
N1A
4 , 8
4 The confused connection of feeders or jumpers. As the figure below, the jumper
of sector3 has be connected to the TMA of sector1. So, even there is no the alarm of
RF Unit ALD Current Out of Range, the problem is caused by wrong installation.
To judge this situation, we can turn off the dc supply in the alarm port ,then if the
current of another port in other sectors increase, that means the two ports in different
sectors are connected to one TMA. (See attachment Example2)
Exampl e2. t xt
Solution:
1Conform the ALD network and installation status, avoid to add the device which
do not exist;
2013-3-25
5 , 8
6 , 8
Succeed.
Antenna Tilt
-----------evice Name
HJZ843-N2A
Site No.
Sector No.
Cabinet No.
Subrack No.
N2A
Device Type
SINGLE_RET
40
20
2013-3-25
7 , 8
Solution:
Operate the command to calibrate RET and then set the tilt as the configured tilt.
Operation:
DSP ANTTILT DSP ANTCONCLB ANTSET ANTTITLCheck alarm
2013-3-25
8 , 8