Professional Documents
Culture Documents
http://www.datateck.com.au/lube/castr_au/default.asp
Close window
Print this page
CASTROL WEBSITE
SEARCH
Vehicle Type:
Cars, Wagons, Utilities & Car-type 4-Wheel Drives
Commercial Vehicles - Light/Medium & 4WD
Commercial Vehicles - Heavy & 4WD
Motor Cycles
Marine - Outboard Motors
Marine - Inboard - Stern Drive
Marine - Engines Inboard
I d t i l & St ti
E i
1 of 5
02-May-15 04:09 PM
http://www.datateck.com.au/lube/castr_au/default.asp
or
CASTROL GTX MODERN ENGINE 15W-40
Castrol GTX Modern Engine 15W-40 provides greater reliability for
your modern engine: Containing an anti-sludge formula that
provides 25% better sludge protection compared to tough industry
standards. Suitable for 4, 6 and 8 cylinder engines built by most
manufacturers from 1995. Provides higher performance reserve
for the longer oil change intervals and/or smaller sump sizes in
modern cars. For all types of passenger cars, including 4WDs and
light commercials. *vs. API SN/CF Industry Standards.
or
CASTROL GTX 20W-50
Castrol GTX 20W-50 protects against problems, like sludge, that
your engine faces every day. Severe driving conditions such as
every day stop-start traffic, harsh weather conditions and extended
drain intervals, can all cause the build-up of a thick, tar-like
substance called sludge. You can't see this sludge build-up but it
can damage your engine's performance and cause premature
engine failure.
Service Refill Capacity: 2.0 Litres. See notes 508, 710 below.
CASTROL MANUAL VMX-M 75W-85
2 of 5
02-May-15 04:09 PM
http://www.datateck.com.au/lube/castr_au/default.asp
3 of 5
02-May-15 04:09 PM
http://www.datateck.com.au/lube/castr_au/default.asp
or
CASTROL BRAKE FLUID DOT 4
Suitable for use in all brake fluid systems in cars, motorcycles and
light commercial vehicles requiring either a DOT 3 or DOT 4
product (Not suitable for use where a mineral oil based fluid is
specified).
4 of 5
02-May-15 04:09 PM
http://www.datateck.com.au/lube/castr_au/default.asp
Capacities shown are approximate only. Where the manufacturer specifies the capacity as including filter/s, the capacity is
marked thus (*). Unless otherwise indicated (e.g. by a notation), capacities shown are service refill quantities. In all cases,
the dipstick or level plug should be used as a final check.
Information is current as of April 15, 2015.
Copyright Castrol Limited 1999-2015
Legal notice
Privacy statement
Copyright 2015 Infomedia Ltd.
Disclaimer
5 of 5
Back to top
02-May-15 04:09 PM