Professional Documents
Culture Documents
ISO 544:2003
COPYRIGHT
Standards Australia/Standards New Zealand
All rights are reserved. No part of this work may be reproduced or copied in any form or by
any means, electronic or mechanical, including photocopying, without the written
permission of the publisher.
Jointly published by Standards Australia, GPO Box 5420, Sydney, NSW 2001 and
Standards New Zealand, Private Bag 2439, Wellington 6020
ISBN 0 7337 6782 6
ii
PREFACE
This Standard was prepared by the Joint Standards Australia/Standards New Zealand Committee
WD-002, Welding Consumables.
The objective of this Standard is to provide requirements for the technical delivery conditions of
welding filler materials for fusion welding.
This Standard is identical with and has been reproduced from ISO 544:2003, Welding consumables
Technical delivery conditions for welding filler materialsType of product, dimensions, tolerances
and markings.
Its number does not appear on each page of text and its identity is shown only on the cover and
title page.
(b)
In the source text this European Standard' should read this Australian/New Zealand Standard.
(c)
ISO 544:2003(E)
iii
CONTENTS
Page
Contents
Foreword......................................................................................................................................................................v
1
Scope ..............................................................................................................................................................1
4
4.1
4.2
4.3
5
5.1
5.2
Condition of consumables............................................................................................................................4
Covered electrodes........................................................................................................................................4
Filler wires, filler rods and strip electrodes ................................................................................................4
6
6.1
6.1.1
6.1.2
6.1.3
6.2
Marking ...........................................................................................................................................................7
Marking on the product .................................................................................................................................7
Covered electrodes........................................................................................................................................7
Filler wires and strip electrodes ...................................................................................................................7
Filler rods........................................................................................................................................................7
Marking on the package ................................................................................................................................7
Packaging .......................................................................................................................................................7
Inspection documents...................................................................................................................................8
iv
iv
NOTES
1
AUSTRALIAN/NEW ZEALAND STANDARD
ISO 544:2003(E)
Welding consumablesTechnical delivery conditions for welding
filler
materialsType of product, dimensions, tolerances and markings
Scope
This European Standard specifies technical delivery conditions for filler materials for fusion welding.
This European Standard does not apply to auxiliaries such as shielding gases.
Normative references
This European Standard incorporates by dated or undated reference, provisions from other
publications. These normative references are cited at the appropriate places in the text and the
publications are listed hereafter. For dated references, subsequent amendments to or revisions of any
of these publications apply to this European Standard only when incorporated in it by amendment or
revision. For undated references the latest edition of the publication referred to applies (including
amendments).
EN 10204, Metallic products Types of inspection documents.
EN ISO 4063, Welding and allied processes Nomenclature of processes and reference numbers
(ISO 4063:1998).
COPYRIGHT
This is a free preview. Purchase the entire publication at the link below:
AS/NZS ISO 544:2005 Welding consumables Technical delivery conditions for welding filler
materials - Type of product, dimensions,
tolerances and markings