Professional Documents
Culture Documents
1 INTRODUCTION
In the third lab session of MSc in Applied Electronics lab, focus on Experiment on operational amplifiers.
During this lab session constructed the inverting, non-inverting, summing amplifier, integrator and
differentiator and precision diode configurations.
Variable and non-variable resistors, capacitors, bread board, jumping wires and the TL084 op-amp were
used to implement op amp configurations. Used the FG 273 function generator to supply input signal to
constructed op amps during this experiment and used the DSO 1102B Oscilloscope for observe op amps
output signal during this experiment session.
Page 2 of 10
2 THEORY
Voltage divider rule.
VOUT = VIN (R2)/(R1 + R2)
Output voltage VOUT is equal to total
R1
resistance
between
output
voltage
divided
by
total
resistance
R2
VOUT
Page 3 of 10
Measure the input and output voltage at 1 kHz and 10 kHz and calculate the actual gain by dividing output
voltage by input voltage.
By connecting 100 resistor between input terminal and supply voltage and connecting 1 M resistor
between output terminal and ground measure the voltages and use them to find input and output
impedance of circuit.
Then use the following non inverting circuit design shown in figure 3.2.2. And repeat the experiment again.
Page 5 of 10
4 RESULTS
Page 7 of 10
Page 8 of 10
6 REFERENCES
Page 9 of 10
7 APPENDIX
Page 10 of 10