Professional Documents
Culture Documents
ANS. PRENUMBRA
2. What temperature scale using absolute zero as the zero point with scale divisions
the same as Centigrade scale?
4. What refers to the temperature of boiling water under the pressure of exactly
760mm of mercury or 100OC?
5. What refers to an electromagnetic waves shorter than visible light but longer
than x-rays?
6. The force between two point charges is directly proportional to the product of
their magnitudes and inversely proportional to the square of the distance between
them.
7. The force between two magnetic poles is directly proportional to the strengths of
the poles and inversely proportional to the square of their distance apart.
9. Which of the following is the policy guidelines to govern the operations of cable
TV in the Philippines?
10. What law is about the vesting of jurisdiction, control and regulation over the
Philippine Communications Satellite Corporation with NTC?
11. The executive order signed by former President F. Ramos last March 1998
providing the national policy in the operation and use of international satellite
communications in the Philippines.
14. Which of the following is considered the first instance of government regulation
of radio technology?
15. Which among the Philippine Congressional Issuances provides for the
installation, operation and maintenance of public telephones and/or public calling
stations in each municipality in the Philippines?
17. R.A 9292 was approved by President Gloria Macapagal Arroyo on what date?
ANS. E.O. 59
19. What E.O. regulates the operation of CATV systems in the Philippines?
20. The law governing the regulation of radio communications in the Philippines is
___.
21. What is the maximum fine for any violation of R.A. 3846, an act regulating radio
stations and radio communications in the Philippines?
ANS. P 4,000
22. The process used to separate liquids due to the difference in their boiling point.
ANS. DISTILLATION
ANS. DECREASE
ANS. CONDENSATION
26. When enough energy is supplied, the rigid pattern of molecules is disrupted in
_____.
ANS. MELTING
28. A liquid solution is made by dissolving gas, liquid, or solid in a liquid. If the liquid
is water, the solution is called _____.
29. Refers to the ability of the substance to mix with another substance.
ANS. MISCIBILITY
31. If the volume of one mole of gas is remains constants, lowering the temperature
will make pressure
ANS. DECREASE
32. If the volume available to the gas is increased, the pressure exerted by one
mole of gas molecules will ____.
ANS. DECREASE
33. The highest temperature at which a gas phase be changed to the liquid phase
by increasing pressure is called ____.
34. The branch of physics which is concerned with low temperature phenomena.
ANS. CRYOGENICS
ANS. IODINE
36. .. the potential difference between when one erg of work must be move
one statcoulomb of between the points.
ANS. STATVOLT
37. Objects that are similarly charged repel each other; bodies with unlike charges
attract each other.
ANS. VOLT
ANS. CONVECTION
41. ___ is heat transfer from molecule to molecule through a body or through bodies
in contact.
ANS. CONDUCTION
42. What is a quantity that expresses how well a substance conducts heat?
ANS. BLACKBODY
44. What is formed if the rays actually pass through the image after refraction?
45. What is formed if the rays only come from the image after refraction?
46. A converging lens forms ___ image when the real object is farther from the lens
than the principal focus.
ANS. REAL
47. A converging lens forms ____ image when the real object is between the lens
and the principal focus.
ANS. VIRTUAL
48. The ratio of the size of the and the size of the object is called ____.
49. What is a defect of a lens by which entering near the edge of the lens and
brought to a focus nearer the lens than the rays that enter near the center?
50. ____ is a form of lateral spherical aberration whereby rays from object points not
on the principal axis are focused in a comet-shaped image.
ANS. COMA
51. ___ is a defect whereby horizontal and vertical lines are brought to a focus at
different distances.
ANS. ASTIGMATISM
52. ___ may occur when light passes from a medium of less speed to one of greater
speed.
53. If the angle of incidence in the denser material is greater than the critical angle,
___ occurs.
ANS. REFLECTION
54. What is the ratio of the speed of light in empty space to the speed in the
medium?
ANS.
ANS. DISTORTION
56. The average human ear is sensitive to frequencies over a range of ___ vibrations
per second.
ANS. 20 to 20,000
57. The process of putting two materials into close association and then separating
them to produce above effect is called ___.
ANS. ELECTRIFICATION
58. The ___ is one that will act upon a similar change with a force of 1 dyne when
the charges are 1 cm apart, in empty space.
59. The ratio of the universal gas constant to Avogadros number is called ____.
ANS. COHESION
ANS. ADHESION
62. ____ takes place because the molecules of gas or liquid move between the
molecules of the substance that is being penetrated.
ANS. DIFFUSION
ANS. OSMOSIS
64. ___ are motions of small particles that are bombarded by molecules.
65. ___ is the mass of water vapor per unit volume of air.
66. The ratio of the actual vapor pressure to the saturated vapor pressure at that
temperature is called ____.
67. The heat per unit mass required to change a substance from solid to liquid at its
melting point.
68. The term atom comes from Greek atomos which means ____.
ANS. INDIVISIBLE
69. Who came up with the idea that matter can be broken down into smallest
particles?
ANS. DEMOCRITUS
70. When electrons enter a sublevel containing more than one orbital, they will
spread out over the available orbitals with their spins in the same direction before
they pair up with opposite spins.
ANS. DIAMAGNETIC
80. The minimum amount of energy required to dislodge the least firmly attached
electron from an atom in the gaseous state is called the ___.
81. In periodic table, Groups IA through VIIA or Group A are classified as ___.
ANS. OXYGEN
84. The chemical reaction between a metal and a non metal usually forms ionic
compound? Which is not an ionic compound?
ANS. C6H12O6
85. Within how many years after the effectivity of R.A. 9292 will the Board issue
certificate of registration without examination to applicants for Registered
Electronics Technicians?
ANS. 5 YEARS
86. Under R.A. 9292, one qualification to become a member of the Board is being a
citizen and resident of the Philippines for at least how many years?
ANS. 5 YEARS
87. A licensed and registered ECE may apply for Professional Electronic Engineer is
he registered for at least how many years after the effectivity of R.A. 9292?
ANS. 7 YEARS
ANS. TESDA
ANS. 3
90. The member of the Board of Electronics Engineer shall hold office for a term of
how many years?
ANS. 3
ANS.
92. Unit used to measure dosage made of x-ray radiation from x-ray is ___.
93. Heavy loading as defined in the Phil. Electronics Code refers to the loading taken
as the resultant stress due to wind and weight for __ km per hour wind velocity.
ANS. 245?
94. Limit of x-ray level set by DOH. The limit is ___ milli roentgen per hour a
measured from a point ___ from any surfaces of the receiver.
ANS.
95. Under RA 9292, Electronics technicians may apply for registration without
examination within ___ years after the effectivity of the republic act.
ANS. 5
96. The maximum continuous term of office of members of the Board of Electronic
Engineers is ___ years.
ANS. 6?
97. In accordance with the Philippine Electronic Code, the maximum radiation from
electronic equipment must not exceed __ per week in order not to experience
genetic or some kinds of damage to cells.
ANS. 100 ms
ANS. 11. 7
ANS. UV ABSORPTION
100. In every drawing, the title block shall b ea standard strip, which shall contain
the name of the project owner, title of the sheet, scale used, name and signature of
the PEE. How wide is this strip?
ANS. 40 mm
ANS. TRANSMUTATION
103. What is the unit of intensity of a light source, which is also defined in terms of
the blackbody radiation emitted at the temperature of freezing platinum?
ANS. CANDLE
104. A substance which changes the rate of a reaction without taking part in the
chemical reaction itself.
ANS.CATALYST
ANS. 7
107. In hospitals, the general lighting load required shall be ___ VA/sq.m.
ANS. 16
ANS. 50 mm
110. What values form the moral philosophy which constitutes in the foundation of
ethics?
ANS. INTEGRITY
112. What refers to the act of giving advice and information to a client in the area of
electronics engineering and its related fields in line with current international
accepted standards and practice?
113. What refers to the act of conceptualizing, planning and projecting scheme,
system and facility using the arts and science of electronics along with social,
economic, financial and technical consideration?
114. What is the act of putting together parts of a whole in order to build-up; to
erect or to form and/or set or establish electronics equipment, systems and
facilities?
ANS. INSPECTION
ANS.
ANS. MAINTENANCE
ANS.
ANS. MANUFACTURING
ANS. P 500
ANS. P 1 000
122. What is an integer which determines the total energy of the hydrogen atom?
123. What refers to the energy needed to move an electron completely from an
atom?
ANS.
125. What is emitted when an electron changes from a higher energy orbit to a
lower energy orbit?
ANS. PHOTON
127. What are the most common training programs designed for managers?
128. What type of training is where the trainee is placed in a situation almost
exactly the same as the workplace where machines, materials, time constraints are
present with the trainer working full time?
130. When recruiting managers, the engineer manager will likely to rely on:
131. What type of environment refers to the variables that are outside the
organization and not typically within short-run control of top management?
132. What is sometimes referred to as the heart of all the management functions?
134. What type of environment refers to the organizational activities within a firm
that surrounds decision-making?
135. When the decision-maker is able to assign probabilities to the various events,
the use of probabilistic decision rule called ___ become possible?
138. What style of leadership should the engineer manager use when his unit is
manned by professionals?
139. When there is a unexplained decline revenues and profits in the company, its
a sign that the engineer manager:
141. What refers to the payoffs granted to the employee by the company, such as
, benefits, promotions, , status and praise?
ANS.
142. Motivating workers through rewards, the engineer manager must identify the
rewards as either:
ANS. or INTRINSIC
143. To determine a qualified applicant, the engineer manager will subject the
applicant to psychological test. What type of psychological test is used to measure a
persons capacity or potential ability to learn?
ANS.
146. What refers to the process of determining the contributions that units can
make with allocated resources?
147. Under Percent cost method in professional fee, what is the design fee
under Group III
ANS.
148. Under unit cost method, professional minimum fee of ___ for each detached
power supplies of system.
ANS.
149. The electronic designer will furnish how many sets of drawing specifications
and contract documents?
ANS. 3
150. For electronics design jobs, using cost plus reasonable profit method, the
percentage the designer get from the client should not be less than ___ of the profit
cost.
ANS. 25%
151. The basic law providing for the regulation of radio station, communications in
the Philippines and other purposes.
152. What is the minimum carrier power output of a standard AM broadcast where
effective and direct supervision of an Electronics Engineer is required?
ANS. 1 kW
153. The variation of the index of refraction with the wavelength of light is called
the ___ of a substance.
154. The property of lens to converge to different foci the rays of light of different
wavelengths coming from a single point is called ___.
ANS.
155. ___ is a combination of a prism and achromatic lenses used to segregate the
various wavelengths in a beam of light and thus to permit examination of its
spectrum.
ANS. SPECTROSCOPE
ANS. CAMERA
157. Much information about the composition of the sun has been obtained by
comparing its absorption lines called ___.
158. A process in which a substance absorbs radiant energy and then immediately
reemits an appreciable part of it with its wavelengths longer than those absorbed.
ANS.
159. ___ is the monochromatic image of the slit through which the light is received
in a spectroscope.
ANS.
160. In some materials the molecules disturbed by the absorption of light do not
immediately return to their original rate, and their emission of light continues after
the exciting radiation is This delayed fluorescence is called ____.
ANS.
161. A ___ is a succession of tones which bear a simple relation to each other.
ANS.
163. The band of colors produced when sunlight is dispersed by a prism is called
___.
ANS.
164. What is an electronic tube designed to separate the useful component from a
complex signal?
ANS. DETECTOR
165. The exchange particles associated with the strong interaction and the strong
binding of quarks within hadrons and of protons and neutrons within a nucleus are
called ___.
ANS. GLUONS