Professional Documents
Culture Documents
Features
Standard 19" rack panel, 3" high
Dual redundant power supplies
Worldwide AC input capability
Monitors converter bias currents to detect
faults
Manual or automatic operation
Manual override switch control knob on
rear panel
Options
Offline I/O
Remote panel
Block Diagram
2120 Old Gatesburg Road, State College, PA 16803 USA Telephone 814-238-2700 FAX 814-238-6589
www.tripointglobal.com
10110 C 1
Operating Modes
Automatic Mode
In Automatic mode, if a failure is detected in the on-line converter, the
standby converter is switched on-line;
switchover is accomplished in 100 milliseconds. The unit will not switch to a
defective converter.
Manual Mode
The converters can also be manually
switched from the front panel or remotely. In Manual mode, automatic
switching will not occur upon fault detection, although the monitor and alarm
circuits still function.
MODEL: BRC-1101
CONTROL
SELECT
UNIT 2
UNIT 1
UNIT 2
REMOTE
MANUAL
ALARMS
PS1
REAR PANEL
PS2
AUTO
LAMP
TEST
UNIT 1
J5
J4
J8
J2
10110 C
RF OUTPUT
BNC FEMALE
RF INPUT
TYPE N FEMALE
J1
J3
LOCAL
UNIT 2
J6
IN
OUT
STBY
IN
STBY
OUT
J7
System Specifications *
Parameter
Notes
Configuration
BRC-1101 Series
Min
Nom/Typ
Max
Units
Frequency Range
Input
Output
3.40
0.950
4.20
1.750
System Gain
BDC-3442 (Standard)
BDC-3442 w/ Option 2
10
20
Gain Flatness
Full band
1.0
Noise Figure
At +23 C
14
Power Output
At 1 dB compression
+8
+10
dBm
Output, OIP3
+18
+20
dBm
Internal to BDC
5.150
GHz
Over temperature
Phase Noise
@ 100 Hz offset
@ 1 kHz offset
@ 10 kHz offset
@ 100 kHz offset
VSWR
Connectors
RF input
RF output
Remote I/O
12
22
dB
dB
12
1.20
1.5
1.5
dB
16
dB
15
kHz
-60
-70
-80
-90
dBc/Hz
dBc/Hz
dBc/Hz
dBc/Hz
1.25
2.0
:1
:1
Type N Female
Type BNC Female (75 ohms)
37-pin D Male (2 in parallel)
Operating Modes
Manual or Automatic
Alarm Method
Window Width
Jumper selectable
5 mA to 25 mA in 5 mA steps
Remote I/O
Form C contacts
100 Vdc/250 mA
Control inputs
Power Requirements
Voltage
Frequency
Power
Size
Temperature Range
GHz
GHz
Operating
100/120/220/240
30
Vac
Hz
W
19 x 3.47 x 22
483 x 88.1 x 559
inches
mm
+10%
63
+50
* System specifications depend on choice of BDC and various options. Specifications shown are for VertexRSI BDC-3442.
When there is only one value on a line, this column is a nominal value. Otherwise it is a typical value. Typical values are intended to
illustrate typical performance, but are not guaranteed.
10110 C
BRC-1101Assigned by factory
at time of order.
BDC Model Number:
BDC-3442
(See BDC-3442 Series specification sheet.)
Option 2:
Option 5:
Offline I/O
Remote panel
10110 C