Professional Documents
Culture Documents
Non-conductive hose
C
Polyurethane hose
Polyurethane Rubber
For applications requiring electrical isolation Made up of nylon core tube with polyester
by the hose, non-conductive hose has a fiber reinforcement which will withstand the
Non-Conductive
leakage factor of less than 50 microamperes, minimum SAE bend radius without shortening
considered a safe level of conductivity by SAE service life. These hoses last up to seven
standards. The covering is polyurethane and times longer than rubber hose, and are
colored orange for easy identification as non- suitable for continuous service at
conductive hose. The covering is not temperatures from -40° to 150° F.
D
perforated, preventing moisture from entering
the hose and affecting its overall conductivity. Hydraulic hose assembly
All non-conductive hoses have a minimum No. 9764 – Hose assembly consisting of
• All have plastic hose guards except burst pressure of 40,000 psi.
9767 (6' hose), 1/4" I.D. polyurethane with
B
for the 1/4" I.D. polyurethane hoses
9798 hose half coupler and 9800 dust cap
which have spring guards. Rubber hose assembled.
• 3/8" NPTF fittings on both ends. 2-ply rated hose reinforced with two braids of No. 9754 – Hose assembly consisting of
• Operating pressure is 10,000 psi. high tensile steel wire. The rubber covering is
9756 (6' hose), 1/4" I.D. rubber with 9798
HYDRAULIC ACCESSORIES
All comply with MHI standard IJ100. oil and weather resistant. These hoses are
hose half coupler and 9800 dust cap
MSHA approved. assembled.
A
B
A = 1/4" I.D. Polyurethane
B = 3/8" I.D. Polyurethane
C
C = 1/4" & 3/8 I.D. Rubber
D = 1/4" I.D. Non-Conductive
ORDERING INFORMATION
122