Professional Documents
Culture Documents
Trisector Antenna
Half Power Beam Width
Adjust. Electr. Downtilt
1710-2690
65
1-12
1710-2690
65
1-12
1710-2690
Frequency Range
Polarization
Average Gain (dBi)
Tilt
1710-1990 MHz
1920-2200 MHz
2200-2490 MHz
45
45
45
45
17.417.417.3
17.817.617.5
18.017.917.5
18.017.717.3
1612
1612
1612
1612
2490-2690 MHz
Horizontal Pattern
Half Power Beam Width
Front to Back Ratio
Cross Polar Ratio
65
61
61
Typically:
Typically:
Typically:
30 dB
30 dB
25 dB
25 dB
60
> 10 dB
> 10 dB
> 8 dB
> 10 dB
5.9
5.7
Main Direction
Sector
65
Vertical Pattern
Half Power Beam Width
7.1
6.5
Electrical Tilt
Sidelobe Suppr. for First
Sidelobe above Main Beam
1612T
1612T
1612T
1612T
181818 dB
181818 dB
1817...17 dB
181817 dB
Impedance
50
VSWR
< 1.5
> 30 dB
< - 150 dBc (2 x 43 dBm carrier)
Intermodulation IM3
Mechanical Specifications
12 x 7-16 female
Input
Bottom
Connector Position
Tilt Setting
6 x at bottom
Antenna Weight
Approx. 89 kg
Approx. 50 kg
+/-10
165 km/h
838N
1680 / 522 mm
750 / 522 mm
Electrical datas shown in this dataseet is subjet to change w/o previous notice
(*) The antenna can also be used on Tilt 0 by relaxing the specs.
Powered by :
page 1/2
FLANGE INTERFACE
Two differents flanges interfaxes can be supplied in order to make an easier and customize
installation on site. Default flange interface is RING method and optional is
SLIM POLE method (order separately) as shown below:
RING INTERFACE
ACCESSORIES (OPTIONAL)
To be ordered separately
PART NUMBER
DESCRIPTION
ECOSPI
86010147_8
78210XXX
SHIPPING INFORMATION
PACKING
ECO2UB + SERVICE AREA
QUANTITY
LxWxH (mm)
WEIGHT
1x
2990x610x740
219 kg
Please note: As a result of more stringent legal regulations and judgements regarding product liability, we are
obliged to point out certain risks that may arise when products are used under extraordinary operating
conditions.
The installation team must be properly qualified and also be familiar with the relevant national safety
regulations.
The details given in our data sheets have to be followed carefully when installing the antennas and
accessories.
The limits for the coupling torque of RF-connectors, recommended by the connector manufacturers must
be obeyed.
Any previous datasheet issued has now become invalid.
www.esbsistemas.com
page 2/2