You are on page 1of 3

Sri Sresti Marketing Solutions

16-3-32/C, Kowtha Street, Purnanandampet,


VIJAYAWADA 520 003. Andhra Pradesh. INDIA.
Email: srestimarketing@gmail.com www.srisms.com
Phone: 9014110759 / 9247110759
Now you can recharge partially weak or low back up giving batteries with Srisms battery
rejuvenator products. At present these are tested and recommended for 12volts batteries
up to 200Ah for inverter and car.

Sri SMS Lead Acid Battery Charger with Digital Voltmeter

This is not useful if there is any short circuit in the battery or the plates
separator is totally worn out or the battery is grown in size or over charged.
To know the battery voltage before charging, disconnect AC power,
connect clips to battery (red clip to positive terminal and black clip to
negative terminal) and switch on the unit. The displayed reading is the
present voltage. Minimum battery voltgae should be 11Volts for

proper charging. Then connect power plug and leave for charging.
After full charge of about 14.4 volts the charger goes into trikle mode.,
then you can disconnect AC power.
Srisms battery charger is designed to charge battery which has lost their rated voltage or
charge. This is a12V rated one and is to be used only for 12V rated lead acid batteries only.
This is slow process (6amps charging) and usually takes about 12 to 15 hours to fully charge
a battery of about 100ah. (This time depends upon many factors). Can be connected from a
60ah battery up to 200ah battery. MINIMUM CHARGE SHOULD BE @ 11Volts.

VERY GOOD EARTHING IS A MUST

This is useful for batteries in two wheeler and four wheeler vehicles, trucks, fork lift vehicles, inverter
batteries, emergency vehicles, boats etc where ever there is regular charging of lead acid batteries.
Red wire of the charger goes to the positive terminal and blue wire goes to the negative terminal of
the battery.

Technical Specifications of SriSMS Battery Charger


Proven Technology Fly back CVCC-PWM Control.
Very Compact Size/ Light Weight.
Wide Input Range / highly efficient.

Output over Load, Short circuit Protection


All double rated component used in product for reliability and long life.
Special Features:
Soft start on DC side.
Filter circuit to limit ripple.
Charger current limiting
Automatic voltage regulation using digital control logic.
3mts wire with battery clips for DC side
Digital Panel meter:
19.99 format 3 digits LED display. Power consumption about 2watts.
Input
Input Voltage: 150V AC TO 270V AC
Frequency: 47 TO 63 HZ.
Input Protection: Soft Start.
Inrush Protection: NTC.
EMI Compliance: Inbuilt RFI/EMI Filter Provided.
Efficiency: > 75-85%.
Output
Voltage: 14.4 VDC
Current: 10 A
Regulation: 2% Line and Load.
Ripple: < 1% PK-PK.
Protection: O/P Over load & Short Circuit.
Cooling
Natural cooling.
Isolation
I/P TO O/P: 1.5 KV AC for One minute.
O/P TO Earth: 1.5 KVAC for one minute.

Important: Due to constant upgrades there might be slight variations in technical


parameters and other specifications that are subjected to change without notice.
Take all standard precautions while charging / handling batteries.

Our other products in this segment


Srisms Battery Pulsar Electronics to enhance the electrical capacity of the battery
Srisms Battery Charger Special charger to charge battery
Srisms Solar Battery Charger Solar powered battery charger to prevent deep discharge
SriSMS Battery Digital Meter Digital meter to know the battery voltage in 19.99 format

We also have
Solar Mobile charger I Solar Tablet PC charger I Solar Laptop charger

You might also like