Professional Documents
Culture Documents
22. Which among the following gates are known as the digital building blocks ?
a) NAND gate
b) OR gate
c) NAND and NOR
d) All the above are correct
Ans. c
31. In a capacitor the capacity of parallel plates
a) Depends only upon plate area
b) Depends upon separation between the parallel plates
c) Directly proportional to plate area and inversely proportional to distance between plates
d) All are wrong
Ans. c
33. For full wave rectifier how many diodes are used
a) 4 forward biased diodes
b) 4 reverse biased diodes
c) 2 forward biased and 2 reverse biased diodes
d) 2 forward biased diodes
Ans. c
38. Electrical power and energy are expressed in terms of
a) Kilo-watt and kilo-watt hour respectively
b) Watt and joule respectively
c) Watt and watt-hour respectively
d) Watt and Newton
Ans. b
39. Thermocouple is used to convert
a) Electrical energy to heat energy
b) Electrical energy to mechanical energy
c) Heat energy to Electrical energy
d) Both (a) and (b) are correct
Ans. c
44. If the 28volt current is passed through the resistance of 10 , the power consumed by the component
is
a) 78.4 watt
b) 780 watt
c) 784 watt
Ans. a
67. An A.C circuit consist of inductance of 10, capacitance of 4, and resistance of 8, the impedance
of the circuit is
a) 6
b) 10
c) 5
d) 8
Ans. b
71. To convert a galvanometer into an ammeter
a) Connect high resistance in parallel to galvanometer
b) Connect low resistance in series to galvanometer
c) Connect low resistance in parallel to galvanometer
d) Connect high resistance in series to galvanometer
Ans. c
76. White masses around Ni-Cd battery vent cap seals should be cleaned with
a) Distilled water
b) Mineral water
c) Warm water with detergent
d) All the above are correct
Ans. a
86. Which is designed to allow current to pass when the circuit potential is equal to or in excess of the
desired voltage
a) Zener diode
b) PNP transistor
c) Triode
d) All the above
Ans. a
26.
(c)
(a)
a. A circuit in which two or more electrical resistances are connected across same voltage
b. A circuit in which two or more electrical resistances are connected across same current
c. Both a and b
d. None of the above
28.
Which device makes it possible to obtain more than one voltage from a single power
source
(b)
a. Current divider
above
29.
b. Voltage divider
(c)
(a)
In p-n junction diode, holes flow from p-region to n-region due to (c)
a. Higher concentration of holes in p-region
b. Potential difference across p and n region
c. electron attracts the holes from p-region
d. both a and b
33.
The opposition to the flow of current which inductor put in a circuit is called (b)
34.
36.
a. Capacitive reactance
b. Inductive reactance
c. inductance
d. capacitance
(d)
(d)
38.
b. negative to positive
d. none
(b)
(d)
a. 0.12 amps.
b. 2.1amps.
c. 0.5amps.
d. 10amps.
(a)
(c)
a. The negative plate lose oxygen and begin forming metallic Cadmium.
b. The positive plate lose oxygen and begin forming metallic Cadmium.
c. as in(a) the active material of the positive plates, nickel hydroxide, become more
highly Oxidised.
d. as in(b) the active material of the positive plates, nickel hydroxide, become more
highly oxidised .
1. A micro will close or open a circuit with the movement of (FAA-9A, PG-319)
a) 1/16 inch or more
b) 1/16 inch or less
c) Both a & b
d) none
Ans:-
b
2. Clevis pin used
a) With head up position
b) As in (a) & washer must be applied under it
c) With head down position
d) None
Ans:-
Ampere tun
b)
Newton meter
c) Both a & b
d) None
Ans:-
a
4. Galvanometer is transferred in ammeter
c
5. The resistance of conductor depends upon
a)
temperature
Ans:-
d
6. Which one of the following is not a primary cell :
a)
Zn-carbon cell
b)
c) Alkaline cell
Ans:-
8.
a) 6
b) 10
c) 5.5
d) 8
Ans:-
a) OR-gate
b) X-OR-gate
c) AND-gate
d) NAND-gate
Ans:-
11. The modulation in which, amplitude is kept constant and frequency is changed is called:
a) Amplitude modulation
b) Space modulation
c) Frequency modulation
d) Phase modulation
Ans:-
c
12. Which of the following is used to neutralize the surface of Ni-Cad battery compartment:
a) Boric acid
b)
Water
c)
Backing soda
d) All
Ans:-
(D) Potentiometer has two terminal and has low resistance value
Answer:(C)
18. Best method suited for checking discontinuity is:
(A) ammeter
(B) ohmmeter
(C) bonding tester
(D) Voltmeter
Answer:(B)
19. If an alternator has 4poles and 1800rpm frequency is:
(A) 60 cps
(B) 120 cps
(C) 100 cps
(D) 140 cps
Answer:(A)
20. Charge stored in capacitor wings varies
(A) directly with area and voltages
(B) directly with area and distance between plates
(C) directly with distance between plates
(D) inversely with area and distance between the plates
Answer:(B)
(A) 1010001
(B) 1100001
(C) 1100000
(D) 1100010
Answer:(C)
29. Mark the correct statement regarding transistors :
(A) Collector current increases when CB is forward biased
(B) Collector current decreases when CB is forward biased
(C) Collector voltage decreases when CB is forward biased
(D) Both (A) & (C) are correct
Answer:(D)
30. For constant voltage, generator used is:
(A) series
(B) shunt
(C) differential compound
(D) None of the above
Answer:(B)
(D) HCL
Answer:(A)
(D) either a or b
Answer:(B)
65. 1 Millibar:
(A) 0.75cm
(B) 0.75 inch
(C) 1.013 cm of hg
(D) none
Answer:(A)
68. Which type of synchronous motor uses servo systems:
(A) single phase
(B) two phase
(C) three phase
(D) both a and c
Answer:(C)
69. Field flashing, in brushes of alternator is achieved by:
(A) by using permanent magnet
(B) by increasing speed
(C) by increasing voltage
(D) both b and c
Answer:(A)
73. Lamination core of transformer provides:
(A) low reluctance for magnetic flux
(B) high reluctance for magnetic flux
(C) none
(D) both
Answer:(A)
74. Electrometer bearing is:
(A) rubber or plastic layer in between bond
PAPER-II (FEB-2008)
1. Convert this number in binary of 11.75:
a) 1101.11
b) 1011.11
c) 1010.11
d) 1001.10
Ans. b
2. For neutralize the Pb-acid battery spillage with:
a) Sodium bicarbonate/backing soda
b) Boric acid and as in (a)
c) Vinegar
d) All of the above
Ans. a
3. Piezoelectric effect is caused on:
a) Quartz
b) Rochellsalt
c) As in (a) & (b) are correct
Ans. c
5. In pure semi-conductor having resistance
a) Infinite resistance having 00C
b) Finite resistance with increasing temperature
c) Finite resistance with decrease in temperature
Ans. c
6. Language of computer is:
a) Decimal
b) Octal
c) Binary
Ans. c
8. In florescent penetrate inspection the defect will show:
a) Brilliant yellow & green color in black light
b) Deep blue violet
c) None
Ans. a
9. Capacitor plate in a capacitor type fuel quantity gauge depends upon:
a) Directly proportional of plate area
b) Inversely proportional with distance b/w the plates
c) Type of dielectric material
d) All are correct
Ans. d
10. PN JUNCTION diode is not used as a:
a) Light intensifier
b) Rectifier
a) X NOR gate
b) X OR gate
c) C MOS NOR gate
d) NOR gate
Ans. a
22. Calculate power when voltage = 28 volts & Resistance = 10
a) 28.4 W
b) 784W
c) 78.4W
d)7.84W
Ans. c
32. In an electric ckt. If capacitance is 100 microfarad & charge is 1 micro colomb, then voltage rating
would be:
a) 100v
b) 10v
c) 1v
d) 1000v
Ans. c
34. Given figure indicates :
Ans. b
38. Ac motor is used in respect of DC motor due to :
a) Less weight
b) Less manufacturer cost & maintenance
c) Brush & commutator is not used in A.C. motor
Ans. c
41. High resistance load in electrical circuit is checked by:
a) AVM meter in DC ohm
b) DC battery with lamp
c) Magneto synchronizer
d) Both (b) & (c)
Ans. a
43. Conductor having 4 resistance, stretched twice in length then new would be:
a) 4
b) 8
c) 16
d) 12
Ans. a
45. If two batteries A & B such that A having grater plate area than , then internal resistance of A will be:
a) Greater than B
b) Smaller than B
c) Equal to B
d) None
Ans. b
50. Kirchoffs law is applicable for:
a) A.C. circuit
b) D.C. circuit
c) Both A.C. & D.C. circuit
d) Both A.C. & D.C. excluded capacitive & inductive element
Ans. c
57. Resistance of conductor does not depend upon:
a) Length
b) Shape of cross-section
c) Area
d) Temperature
Ans. b
58. Unit of electrical power & energy is:
a) KW & KWH respectively
b) KWH & KW respectively
c) Joule & KW respectively
d) KW & Joule respectively
Ans. d
61. If V=volt, W=weber, A=Ampere & S=sec. then correct equation is:
a) A=WS-1
b) V=WS-1
c) None
Ans. b
63. Rheostat has:
a) Two terminal
b) Three terminal
c) Two terminal, one is attached to one end & other is attached to jockey type
Ans. c
69. MTCS for the Pb-acid battery is tested using a hydrometer:
a) Correction is required when 1000 F
b) Correction is required when less than 800 F or more than 800 F
c) No correction is required
Ans. b
71. Convert the binary no. (110) in decimal no:
a) 2
b) 7
c) 6
d) 16
Ans. a
72. MTCS regarding thermocouple:
a) Sensing the Hot & cold in due to temperature variation
b) Its act as a transducer
c) Both (a) & (b)
Ans. a
75. In Pb-acid battery corrosion treatment are:
a) Sodium bicarbonate of soda & water
b) Vinegar
c) Ammonia
d) Both (a) & (b) are correct
Ans. d
77. Same mass of two object, one object charged with +ve & other charged with ve, then what will be
effect in the mass of both object:
a) Increases
b) Decreases
c) Same
d) None
Ans. c
10.Which of the following has a negative coefficient of resistance:
a) Conductor
b) Thermocouple
c) Thermistor
d) None
Ans. c
17. Best method suited for checking discontinuity is:
a) Ammeters
b) Ohm meter
c) Bonding tester
Ans. b
18. In an inductor circuit current:
a) Lags voltage by /2
b) Leads voltage by /2
c)
d) None
Ans. a
19. Binary equivalent of (296) is:
a) (1100001)2
b) (1010001)2
c) (1100000)2
d) (100101000)2
Ans. d
25. Resistance of conductor doesnt depend on:
a) Material
b) Strength
c) Shape of cross section
Ans. c
26. Speed of motor increases, when load decreases, current decreases, current decreases because of:
a) Induced back emf. Increases
b) Frictional less bet winding other part
c) Induced back emf.
Ans. a
27. Identify the figure
a) NAND Gate
b) OR gate
c) And Gate
d) NOR gate
Ans. b
28. P N Junction is transistor has:
a) Reverse biased
c) Forward biased
d) None
Ans. a
29. P N Junction is not used as:
a) Rectifiers
b) Light intensity
c) Light radiation
d) Transformer
Ans. b
39. Vicious cycle is related to:
a) Generator
b) Battery
c) Motor
Ans. b
40. If frequency of a transformer is changed from 50 to 60 voltage in secondary winding:
a) Increases in ratio of 60/50
b) Decreases in ratio of 50/60
c) Value remains constant
d) Both a & b are wrong
Ans. a
44. If transformer ratio is 2:1 of a step up transformer then what about the secondary current:
a) Current will be doubled of original
b) Current will be half of original
c) No change in current
d) Current becomes on third
Ans. b
45. Current transformer is:
a) Step up
b) Step down
c) Transformation rated is unity
d) None
Ans. b
46. Diode conducts when it is reversed biased:
a) Zener diode
b) PN diode
c) None
Ans. a
49. Microprocessor at least consist of :
a) CPU
b) Memory
c) Arithmetic logic unit
d) All
Ans. d
64. Mark the correct statement:
a) Output will be high of any one of input become AND gate
b) Output will be high if all of input will be low for AND gate
c) Output will be high if any one or all of the input becomes high for or gate
d) None
Ans. c
76. If a generator fails to show any voltage due to less of the residual magnetism in its field. This can be
corrected by:
a) Flashing the field
b) Charging the field
c) Magnetizing the field permanently
d) All are correct
Ans. a
80. Electric wiring that offers the advantage of ease off installation simple maintenance and reduce weight
is known as:
a) Single wiring method
b) Open wiring method
c) Closed wiring method
d) None
Ans. b
82. If a magnet is dropped through a current varying coil, it will fall with:
a) Uniform acceleration equal to g
b) Uniform acceleration less than g
c) Uniform acceleration more than g
d) Non-uniform acceleration less than g
Ans. d
84. Through which material magnetic lines force pass the most:
a) Copper
b) Iron
c) Aluminum
d) Zinc
Ans. b
85. A prime limitation with directly heated cathode is due to:
a) Low frequency
b) Voltage fluctuation
c) High frequency
d) Phase
Ans. b
17. Best method suited for checking discontinuity is:
a) Ammeters
b) Ohm meter
c) Bonding tester
Ans. b
19. Binary equivalent of (296) is:
a) (1100001)2
b) (1010001)2
c) (1100000)2
d) (100101000)2
Ans. d
18.Frequency of generator depends
a)No. of poles
b)rpm
c)filed strength
d)All
ans:-4
25. Alternator is
a)Alternating current generator
b)Ac Motor
c)Dc generator
d)Induction alternating motor
ans:- 1
ans:-2
c) Sodium Hydroxide
ans : a
19. When installing battery
a) Put positive lead first
b) Put negative lead first
c) Either of the above
ans : a
20. If p.f is 0.6 it means
a) Ratio of wattless to wattfull is 0.6
b) Active power is 0.6
c) Reactive power is 0.6
d) Ratio of wattful to apparent power is 0.6
ans : d
23. Mark the correct statement
a. Bicarbonate of soda for lead-acid and boric acid for ni-cd battery.
b. Bicarbonate if soda for ni-cd battery and boric acid for lead acid battery
36.Long shunted compounal wound generator has
a.shunt field across both armature and series field
b.series field across both armature and series field
c.shunt field across armature only
51.For converting galvanometer into voltmeter connect
a.high resistance wire in series with meter for increase range
b. low resistance wire in series with meter
c. high resistance wire in parallel with meter
d. low resistance wire in parallel with meter
52.For increasing the range of ammeter resistence connected in
a.high in series
b.high in parallel
b)
c)
Ans:2
Ans:4
auto transformer
Excessive sulphation
b)
Rapid charging/Discharging
Pure semiconductor :
a)
Infinite resistance at 0C
Plate area
b)
c)
Strength of dielectric
d)
All
Ans:7
i/p impedance
b)
Inductance
c) Inductive reactance
Ans:-
Continuity of ckt.:
a) Ammeter
b) ohmmeter
c) Bonding tester
use ohmmeter
NAHCO3
13 CRPF :
Ans:-
14 Purpose of flux :
Ans:-
to prevent oxidation
both a & b
17 Hi-tigue :
Ans:-
b)
across
c) To indicate charge/discharge
d) To indicate charge/discharge of the battery
Ans:-
19 Connectors :
Ans:-
20 Synchronization is altemeter :
Ans:-
21 In short cut
Ans:-
22 1 milli bar :
Ans:-
= 0.75 mm Hg
perpendicular to conductor
Image to be
downloaded
b)
Reverse biased
c)
Not biased
a)
Forward biased
d) None
Ans:- b
2. The following is a:
Image to be downloaded
a) Secondary transformer
b)
Auto transformer
c)
d) None
Ans:-
Image to be downloaded
c)
d) None
Ans:-
c)
d)
Both b and c
Ans:- d
d)
Both b and c
Ans:- d
6. To switch on a transistor :
a)
b)
c)
d) None
Ans:- a
9.
SCR has :
a)
Two junctions
b)
Three junctions
b)
Speed of rotation
c)
An assigned statement
1011.10
b)
1101.11
c)
1011.11
d)
1110.10
Ans:- b
B
0
1
0
1
V
0
1
1
1
OR GATE
AND GATE
NAND GATE
NOT GATE
Ans:- a
c)
d)
Requirement changes
Ans:- c
c) Plate, cathode, heater & a wire mesh b/w plate & cathode
Ans:- c
d) As an amplifier
Ans:- c
23. To check a circuit for continuity it must be:
a) Connected to a power source
b) Connected to a battery
c) Isolated
d) Both a and b
Ans:- c
Decimal system
c)
Octal system
d) Hexadecimal system
Ans:- a
Infinite resistance at 0C
Ans:- c
Ans:- a
16:- In 3Q a/c generator ,if 8 pole & 1600 rpm is used then frequency will be
a)800 Hz
b)1600 Hz
c)400 Hz
d)1200 Hz
ans:-3
ans :-1
ans:-4
ans :-2
ans :-3
ans :- 1
16:- In 3Q a/c generator ,if 8 pole & 1600 rpm is used then frequency will be
a)800 Hz
b)1600 Hz
c)400 Hz
d)1200 Hz
ans:-3
20:-Shunt a/c motor is used to drive
a)landing gear
b)gyro & servo motor
c)tap
ans:-2
ans :-1
ans:-4
25:- Copper bar in 3 phases motor is placed deep in stator coil
a)improve power factor
b)high starting torque provided
ans :-2
ans :-3
ans :- 1
ans:- 4
ans:-3
38. In a inductor if no. of turns is increased & core length is doubled then self
inductance of inductor would be
a)doubled
b)triple
c)half
d)remain same
ans:-1
44. In lead-acid battery spilled electrolyte is neutralized by
a)sodium bicarbonate & water
b)as in a & ammonia
c)vineger
d)none
ans:- 2
49. If two battery A & B such that A having greater plate area
Than B,then internal resistance of A will be
a)greater than B
b)smaller than B
c)equal to B
d)none
ans:-2
55. Kirchoffs law applicable for
a)A.C circuit
b)D.C circuit
c)Both A.C and D.C circuit
d)Both A.C and D.C excluded capacitive & inductive element
ans:- 3
66. Capacitance of capacitor does not depend upon
a)plate area
b)plate separation
c)plate thickness
d)di electric material
ans:- 2
69.P-N junction diode does not used in
a)rectifier
b)amplifier
c)light detection
d)for light radiation
ans:-3
73. PN Junction diode, not used as
a)Rectifier
b)For radiation
c)To deflect intensity of flight
d)To amplify AC low signal tohigh
ans:-3
6. Resistance of conductor does not depend upon
a)length
b)shape
c)area
d)temperature
ans:- 1
ans:-1
6.
ans:-3
24.Kirchoffs law is applicable for
a)A.C.ckt
b)D.C.ckt
c)Both A.C & D.C.ckt
d)Both A.C & D.C excluded capacitive & inductive element
ans:-3
30.If two battery A & B such that A having greater plate area than B, then internal
resistance
Of A will be
a)Greater than B
b)smaller than B
c)Equal to B
d)None
ans:-2
Ans:-1
39. Conductor having 4 resistance, stretched twice in length then new resistance
would be:
a)4
b)8
3)16
4)12
Ans:- 1
46. High resistance load in electrical ckt. Is checked by:
a)AVM meter in DC ohm
b)DC battery with lamp
c)Maneto synchronizer
d)both b and c
ans:-1
50. Universal gates
a)AND & OR
b)NAND & NOR
c)XOR & EXNOR
d)none of the above
ans:- 2
ans:-3
Ans:1
ans:-4
55. In transformer , the induced emf in secondary depends upon
a)Number of turns in secondary
b) Number of turns in primary
c)Both a and b
d)None
ans:-3
ans:- 3
60. The frequency of 8 pole generator with an armature speed of 180 rpm.
a)120
b)220 HZ
c)400 HZ
d)320 Hz
ans:- 3
63 . In an electrical circuit ,if capacitance is 100 pf & change is 10mf colomb, then
voltage giving would be:
A)50 V
b)10 V
c)25 V
d)100 V
ans:-2
ans:-2
ans:-2
94. In electrical conductor when the temperature increases, resistance
a)Decrease
b)Remain same
c)Increase
d)none
ans:-2
ans:- 3