Professional Documents
Culture Documents
AM/SSB/FM/REMOTE
CONTROL)
BT
MCM24/EV
INTRODUCTION
MCM24/EV
Experiment board for the study of AM, DSB, SSB (LSB and USB),
FM transmitter and a 4-channel radio control transmitter.
It contains all the pre-assembled electronic components
needed to construct the experiment circuits and divided into
functional blocks which can be interconnected and modified
by means of supplied jumpers and connection cables. The
training program can be extended to cover phase modulation
with experiment board MCM24PM/EV, while experiment board
MCM24/EV and MCM25/EV can be used together to set up a
radio communication link.
TRAINING PROGRAM:
Low frequency processor (low pass filter, level matcher,
tone generator for testing)
Modulation techniques for the following transmissions:
- AM
- DSB (Double Side Band, with balanced modulator)
- SSB (LSB and USB, using quartz filter)
- FM (VCO using varicap diode)
- Of logic states (coder for 4-channel radiocontrol)
Local oscillator
Conversion mixer
RF amplifier
Radio (antenna)/cable transmission
Calibration and measurement of all stages and the
whole module
Troubleshooting
System test and measurement
21C-E-BT -MCM24-0
TECHNICAL SPECIFICATION:
AM/DSB/FM/radiocontrol channel in MW band
SSB channel in 80 m SW band (3-4 MHz)
2-tone generator: 1000 and 2000 Hz
Adj. input for external microphone and BF signal
Coder: 9 input line (4 Data and 5 Address)
2 Local oscillators: manual frequency control
(DC voltage) or automatic (PLL)
2 LEDs for PLL locking and 5 LEDs for selected modulation
IF/RF testing point: low impedance (50 Ohm) for spectrum
analyzer connection
RF output power: 40mW, adjustable
Tuned ferrite antenna in MW band
RF output impedance: 50 Ohm (BNC, antenna or cable)
Fault simulation: Possibility to insert 10 faults
Test and interconnection points, 2 mm
Rapid modifications to circuits using jumpers
37-pin connector to the fault insertion unit
8-wire connector to the power supply unit
REQUIRED
PSLC/EV
POWER SUPPLY UNIT
- NOT INCLUDED -
POWER SUPPLY
+12 Vdc - 0.5A
INCLUDED
STUDENT HANDBOOK: THEORY AND EXERCISES
TEACHER HANDBOOK:
SOLUTIONS OF EXERCISES
OPTIONAL
PERSONAL COMPUTER
MCM24PM/EV
PHASE MODULATION
ELETTRONICA VENETA S.P.A. - 31045 Motta di Livenza (TV) Italy - Via Postumia, 16 - Tel. +39 0422 765 802 - Fax +39 0422 861 901 - E-mail: export@elettronicaveneta.com
BT19