Professional Documents
Culture Documents
STANDARD
SPECIFICATIONS AND DRAWINGS
FOR
CONSTRUCTION OF DOMESTIC
WATER SYSTEMS
REVISION NO. 1
Approved By:
Approved By:
Principal Engineer
INTRODUCTION
These Water Standard Specifications are to be used as a guide by
Private Engineers and Contractors in the design and installation of
all additions or modifications to the San Bernardino Municipal
Water Department (SBMWD) infrastructure.
It is the intent that these Water Standard Specifications will
provide uniformity in materials and installation of piping, valves,
fire hydrants, service laterals, and other appurtenant equipment.
These Water Standard Specifications will also provide for
construction methods and controls to be used by Contractors to
construct, pressure test, chlorinate, and place into service
domestic water systems in the SBMWD service area.
Note: Any changes to Sections 2 through 7 of these Water Standard
Specifications shall be prepared as a separate document titled
"Special Conditions to the Water Standard Specifications" (Section
8 of these Specifications) and shall be approved by SBMWD prior to
construction.
Definitions
Abbreviations
Units of Measure
Scope and Control of Work
Subcontracts
Plans and Specifications
Changes in Work
Changed Conditions
Control of Materials
Utilities
Locations
Title 22 Separation Requirements
Prosecution Progress and Acceptance of the Work
Liquidated Damages
Responsibilities of the Contractor
Permits
Protection and Restoration of Existing Improvements
As-Built Drawings
Public Notification
SECTION 2 - MATERIALS
2-00
2-01
2-02
2-03
2-04
2-05
2-06
2-07
2-08
2-09
2-10
2-11
2-12
2-13
2-14
2-15
2-16
2-17
General
Ductile Iron Pipe
Special Applications Using Polyvinyl Chloride Pipe
Copper Tubing
Red Brass Pipe
Main Line Valves
Air and Vacuum, Air Release, and Combination Air Valves
Fire Hydrants
Main Line Pipe Fittings
Main Line Couplings
Service Lateral Installation
Small Meters
Thrust Restraining Materials
Shop Drawing and Material Submittals
Coatings Aboveground Installations
Access to Manufacturing and Test Facilities
Pipe Casing
Water Quality Sampling Stand
i
Inspection
Preconstruction Details
Removals and Trench Excavation
Connection to Existing Facilities
Laying of Ductile Iron Pipe Water Main
Laying of PVC Pipe Water Main
Service Laterals
Pipe Bedding and Backfilling of Trench
Repaving and Finishing
Testing, Disinfection, and Flushing
Sheeting and Shoring
Jacking of Steel Casing
Polyethylene Protective Wrapping
Dedication of Improvements to the City
Record Drawings
General
Meters
Vault Installations
Coatings - Aboveground Installations
Aesthetics - Aboveground Installations
Backflow Protection
Fire Line Assembly
General
Materials
Construction of Well
Well Development Procedures
Production Test Pumping
Capping of Well
Cleanup
Records
Abandonment
Noise Abatement
Site Inspection
General Provisions
Temporary Construction Facilities
Conduits
Underground Ductbank
Conductors
Boxes
Wiring Devices
Branch Circuit Panelboards
Disconnects
Overcurrent Protective Devices
Support Devices
Diesel Standby Generators
Transfer Switch
Solid State Reduced Voltage Starters
Switchboards
Grounding, Ground Electrode
Transformer
Lighting Fixtures
General Control Devices
Motor Control
iii