Professional Documents
Culture Documents
DISCUSSION OF RESULTS
In this section you need to provide critical analysis and interpretation of results. Figures and tables
should be contained within the typing area and count towards the total length of the report of 10
pages.
Figures and tables should all be numbered and have a caption underneath that briefly describes the
contents. Figures should be of good quality and show information in a clear way (see, for instance,
Figure 1). Colour plots should contain a legend, and details that can be seen with the naked eye, line
plots should clearly differentiate between multiple lines (where applicable). Along the axes of the
figures labels need to be present detailing the quantity shown - with proper SI units where
applicable. All figures and tables need to be referenced in the text by their number (i.e. Fig. 1 shows
or Figure 1 displays .).
Citations of books, journal articles etc. need to be numbered in the order of appearance e.g. [1] or
[2, 3, 4]. The citations refer to a list of references on the last page of the report. Two relevant pages
of the ANSYS summary report need to be attached to the actual report in an appendix to confirm
that it is your work. The two page appendix does not count towards your total allowed page limit of
10 pages. Be aware that any further information provided in the appendix (extra figures / tables/
formulae) will not be marked.
Secondary headings. To improve the readability of your report it is recommended to use secondary
headings where appropriate. Apart from the hardcopy that needs to be submitted to TPO, you are
expected to store all your work (including an electronic version of the report) in a save place in case
we need you to provide more details. You are expected to make regular backups of all your work.
The hardcopy of the report should be printed single sided and you are expected to check the quality
of the printed report for completeness before submission. While writing the report please keep in
mind that we do not want to see an ANSYS manual. Instead we need you to present the results
obtained with ANSYS in a professional way with a proper analysis/discussion (not just stating the
obvious). You are not required to produce the maximum number of pages allowed. It will be looked
upon favourably if you can write a good quality concise report using fewer pages.
CONCLUSIONS
This section should contain a very brief description of the computational problem and a list of your
findings. You should not add any figures or tables to this section.
2 | Page
REFERENCES
[1] Ritchie, G.S. (1983), Nonlinear Dynamic Characteristics of a Finite Journal Bearing, Trans.
ASME, J. Lub. Tech., Vol. 1, No. 3, pp 375-376.
[2] Kincaid, D. and Cheney, W. (1991), Numerical Analysis, Brooks/Cole Publ. Co., Pacific Grove,
California.
[3] Silver, K. (1991), Electronic Mail: the New Way to Communicate. In: D.I. Raitt, ed., 9th
International Online Information Meeting, 3-5 December 1990 London. Oxford: Learned
Information, pp. 323-330.
[4] Holland, M. (2004), Guide to citing Internet sources [online]. Poole, Bournemouth University.
Available from: http://www.bournemouth.ac.uk/library/using/guide_to_citing_internet_sourc.html
[Accessed 4 November 2004].
Please note: [1] is an example of a journal paper, [2] is a book, [3] a conference paper and [4] an
online webpage or e-book.
3 | Page
4 | Page