Professional Documents
Culture Documents
Did you ever miss an important telephone call simply because you were away where you
couldn't hear the phone ringing? This should not happen again with this inexpensive remote
telephone bell. It is a battery-operated device that can be installed anywhere inside or
outside your home. Since it is self-powered, it requires virtually no power from the
telephone line. The input impedance of the circuit, as seen from the telephone line, is about
100,000 ohms and the input resistance is infinite. When connected across the telephone
line, it has no effect on the telephones performance.
The circuit derives its power from four rechargeable Ni-Cd cells connected in series to
provide 6 volts. Since the power is drawn from these cells only when the telephone rings,
the battery will last several months. Besides, a built-in-battery charger is included in the
circuit so that the cells remain charged at any time.
The circuit is divided into two sections: the ringer and the charger. The ringer section is built
around transistors T1 and T2 along with a few discrete components. The charger section is
built around step-down transformer X1, bridge rectifier comprising diodes D1 through D4,
and resistor R5.
When the telephone rings, a 20Hz AC voltage of about 80-90Vrms is superimposed across
the telephone line. The resistor-capacitor series circuit (comprising resistors R1, R2, R3 and
capacitors C1 and C2) connected across the telephone line provides DC isolation; there is
normally a DC voltage of about 48 volts across the telephone line when the line is not in
use. Transistor T1 responds to the 20Hz ringing signal by conducting current during each
positive half cycle applied to its base. Diode D5 prevents T1 from reverse-bias during the
negative half cycle of the ringing signal.
The emitter current of transistor T1 is applied to the base of transistor T2, causing it to
saturate and act as a switch. This applies full battery voltage to the bell (piezobuzzer),
causing it to ring. The voltage applied to the bell is essentially a 20Hz square wave, which
produces a slightly different sound from that produced by pure DC. Diode D6 and capacitor
C3 protect transistor T2 from any reverse voltage spikes produced by a collapsing magnetic
field of the bell.
In the battery charger circuit, step-down transformer X1 provides isolation from the AC
power line while reducing the voltage to about 6Vrms. The output of the bridge rectifier is
pulsating DC with about 9V peak, which is applied to the Ni-Cd rechargeable cells through