Professional Documents
Culture Documents
In this post I have given the list of the questions that were asked in oral examinations
of 4B. In this post I have picked some of the famous questions that were asked in
the Electro technology and control engineering oral exams. Answer to these will be
published shortly. If you have any suggestions, please drop a reply below.
Question Bank
Protection Against
Fashion Industry
Job interview questions
Class Iv
.................................................................................................................................................
...............
How do you test, reverse power trip, high current trip, preferential trip?
102. What is residual magnetism? Where is it important?
103. Sometimes, when you change the running direction of a E/R blower
(from supply to exhaust) it trips. Why?
104. What is the function of the friction clutch mechanism used in
purifiers?
105. What is the regular maintenance done on batteries?
106. What safety precautions need to be taken during maintenance on
batteries?
107. Why is special lighting used in battery rooms?
108. What is the voltage available from each cell in a lead acid battery?
109. What is the full battery voltage ?
110. How is this voltage achieved?
.................................................................................................................................................
...........
111. What is the meaning of a normally open contact?
112. How does a Salinometer function?
113. How does the air compressor start and stop automatically?
114. How is the cold room temperature maintained?
115. What is a self-monitoring alarm circuit?
116. Out at sea, if there is a black out during your watch, what action
will you take?
117. After a black out the emergency generator comes on; On restoring the
main supply we are closing the circuit breaker of the main generator with
out bothering about synchronizing. How is this possible?
118. How does the emergency generator start automatically?
119. If all your air bottles are at low pressure and there is a blackout
how do you start the generators?
120. What is a shaft generator?
121. Even though the main engine runs at varying speeds, how does the
alternator maintain constant frequency?
122. Is the alternator connected star or delta
123. Why is 440 V used for motors and 110/220 V used for lighting?
Hope you liked my article.
Q1 Tell the engine specification, SFOC, lube oil consumption, bore diameter of the
ship that you sailed in.
Fashion Industry
Home Work
Job interview questions
Online work at home
Q2. Tell me the main engine and auxiliary engine lube oil properties and also for
cylinder oil. Also tell the TBN value and how to calculate the same.
Q3 How you will change boiler to EGB. Why circulating pump kept running, what
will happen if not, hydrogen fire, what is primary detonation and secondary. What
would be effect from the same?
Q4. What seawater pump you had in your previous ship. After dismantling that
pump what are all the checks you will carry out. How you will check shaft
trueness.
Q5. Tell me the configuration of your main engine.
You may also like to read:
MSC Shipping Line Interview Questions
Q6 How it was controlled, means through camshaft or what?
Q7 Are you sure camshaft controlled and not moment compensated?
Q8) What type of exhaust valve control engine had?
Q9) What type of exhaust valve wear protection?
Q10 Tell me the Crankcase safeties like explosion doors, omd, bearing oil
temperature indicators,lube oil high temp and low pressure trips.
Q11 Type of material in temperature sensors.
Q12 Type of moments in that- primary and secondary and explain the same.
Q13) Moment compensators for primary, webs, for secondary, separate weights
etc.
Q14 Vibration dampers types like axial and torsional.
Q15 How axial damper works, explain this by the diagram.
Also read: Oral question bank for class 4
Q16 Do dampers have any type of speed reducing or increasing arrangements?
Q17 Drawn power and compression cards.
In this post we have given the list of the questions that were asked in
oral examinations of 4B. In this post I have picked some of the famous questions that
were asked in the Marine engineering practice oral exams. Answer to these will be
published shortly. If you have any suggestions, please drop a reply below.