Professional Documents
Culture Documents
Edition 15/12/2013
Identification no: CA 1
Sika Construction
SikaViscoCreteRM200
Ultra High Range Super-plasticizer with Excellent Slump Keeping
Properties
Product
Description
Uses
Concrete mixed Sika ViscoCrete RM200 is extremely flow able whilst retaining
optimal cohesion and exhibiting high self-compacting properties.
High water reduction and excellent flow ability have a positive influence on the
above mentioned applications.
Sika ViscoCrete RM200 does not contain chloride or other steel corrosion
promoting ingredients. It may therefore be used without any restrictions for
reinforced and pre-stressed concrete construction
1/3
SikaViscoCreteRM200
Tests/
Standards
Sika Construction
Product Data
Form
Type
Packaging
Shelf Life /Storage 12 months from date of production if stored properly in undamaged unopened,
Conditions
original sealed packaging, in dry conditions temperature between +5C and
+35C. Protect from direct sunlight and frost.
Technical Data
Chemical Base
0
Density at 25 C
0
pH Value at 25 C
4.5 - 6
Chloride content
System
Information
Application Details
Consumption /
Dosage
Recommended dosage:
For medium workability: 0.2 0.7 % by weight of cement
For concrete of high workability, very low water/cement ration and for selfcompacting concrete: 0.80 1.60 % by weight of cement.
Application
Instructions
Dispensing
Concrete Placing
With the use of Sika ViscoCrete RM200, concrete of the highest quality can
be produced. The standard rules of good concreting practice (production as
well as placing) must also be observed.
Curing
2/3
SikaViscoCreteRM200
Compatibility
Sika ViscoCrete RM200 can be combined with the following Sika products:
- Sika Pump
- Sika FerroGard-901
Sika Construction
- Sika Stabilizer
Combination with Silica-fume is particularly well suited for use with Silica-fume
because of its water reduction capability and superior slump control.
It is also compatible with sulphate resistant cement. Pre-trials are
recommended in case with the above products
Please consult our Technical Services Department.
Cleaning of Tools
Clean all tools and application equipment with water immediately after use.
Remarks
When accidental overdosing occur, apart from retardation of the initial set and
increased bleeding, no detrimental effect will take place.
Safety
Precautions
Accidental splashes to the skin must be washed off with water and soap.
Accidental splashes to the eyes or mucous membrane must be rinsed with
clean warm water. Seek medical attention without delay.
Skin barrier cream, safety goggles and rubber gloves are recommended.
Ecology
Toxicity
Transportation
Non-hazardous.
Legal Notes