Professional Documents
Culture Documents
Description
This alarm is reported when the maintenance link between the RF unit and the ALD
(RET antenna, TMA, or SASU) malfunctions
Possible Causes
The ALD current of the RF unit is out of range, or the configured ALD switch does
not match the actual type of the ALD port on the RF unit.
The data configuration of the antenna, such as vendor code and device serial
number, is incorrect.
There are feeder problems, such as water damage, connector fault, or bent cable.
(AISG Cable/Feeder Cable/Jumper)
Handling Procedure
1. Check for the correlated alarm on the M2000.
a. Check for the correlated alarm of the RF unit on the M2000:
26530 RF Unit ALD Current Out of Range
26531 RF Unit ALD Switch Configuration Mismatch
Y => The correlated alarm exists. Go to sub-step b .
N => The correlated alarm does not exist. Go to step 2 .
DSP ALDDEV (Display ALD Version) Run command DSP ALDVER to check all
ALD software are upgraded to latest version. See Below example