Professional Documents
Culture Documents
WALL-MOUNTED
EXQUISITE iPAD KIOSK
Items/Tools Required:
iPad
iPad data/power cable that came with your iPad. (An after-market
connector may not fit.)
4 Sets of Screws and anchors to securely mount kiosk to your specific wall
surface -- with appropriate tools
Measuring device, such as a tape rule
Level
Extension Cord (optional)
Warning: When assembling the head enclosure, never use screws other than the security
screws supplied with the kiosk. A longer screw can penetrate the head enclosure further than
designed and cause permanent cosmetic damage to the head enclosure.
3 JUL 2012
#1. Installing Your iPad into the Head Enclosure and Testing Your iPads Controls
Note: Prior to installing your iPad into the enclosure, confirm that your application is running correctly on
the iPad.
Items needed:
iPad
iPad data/power cable that came with your iPad. (An after-market connector may not fit.)
hex bit driver (supplied)
Front iPad Assembly (supplied)
Rear iPad Assembly (supplied)
8 security screws (supplied)
Torx security screw bit, large (supplied)
Button key (supplied)
Audio Cable (Supplied with Audio Kit)
3 JUL 2012
3
Part C: Assembling the Head Enclosure
1. Pick up the rear assembly and look at the inside. If needed, rotate the assembly so that the end
with the large notch is on the right.
2. Thread the USB end of data/power cable (and optional audio cable) through the center hole of
the rear assembly, out toward you.
3. Place the rear assembly on top of the front assembly so that the screw holes are aligned, and
then gently pull the cable(s) out of the back of the enclosure. Caution: Do not pull tightly on the
cable(s) or you may damage the connector.
4. Place the 8 security screws into the screw holes. Realigned the rear assembly over the front
assembly and tighten the 8 screws with the security screw bit and driver. (Warning: NEVER USE
SCREWS OTHER THAN THE SECURITY SCREWS SUPPLIED WITH THE KIOSK. A LONGER SCREW
CAN PENETRATE THE HEAD ENCLOSURE FURTHER THAN DESIGNED AND CAUSE PERMANENT
COSMETIC DAMAGE TO THE HEAD ENCLOSURE.)
The Head Enclosure is fully assembled. Important: Now is a good time to test that you have power
going to the iPad. Plug the power/data cable and power adapter into a wall socket and confirm
that your iPad is getting power.
3 JUL 2012
Items needed:
3 JUL 2012
5
2. Use the hex key to tighten each socket-head screw.
4 Sets of screws and anchors to securely mount kiosk to your specific wall surface -- with
appropriate tools
Measuring device such as a tape rule
Level
Wall plate (supplied)
3 JUL 2012
3 JUL 2012