Minitecno is a sophisticated and smart clinical chemistry
analyzer with a built in colour touch screen monitor, with the possibility to connect an external USB keyboard. The patient oriented analysis sequence allows the user to work patient by patient or method by method and the user friendly software based on Windows XP is really easy to use. This means that Minitecno takes just few minutes to be ready to help you in the laboratory. Minitecno can perform end point, kinetic, fixed time, bichromatic, differential sample blank methods. 35 micro-liters integrated glass flow cell, with stabilized temperature through peltier system (25 37C), is the perfect solution to have the possibility to use between 350 and 500 micro-liters per test. All the calibration curves, linear and not linear, are stored in memory, and all the methods are fully programmable by the user. The printer on board allows the user to print the graphical plot of all measured points. 24 months warranty is the expression of the quality of Minitecno. Of course produced by I.S.E. CLINICAL CHEMISTRY ANALYZER Test Methods - stores up to 400 test methods - stores up to 5 proles - operation by touch screen Programming - patient oriented analysis sequence Operator interface - touch screen (colour) - Embedded manager software - English language (optional multilanguage) Photometric system - quartz halogen lamp - 340/405/510/546/578/620nm plus two free positions - mono or bichromatic measurement - optical linearity to 3 absorbance units (1 cm) - photodiode detector (320-1000 nm) - 35 l glass ow cell - temperature 25C, 30C, 37C T. amb. - (peltier module) Aspiration - internal peristaltic pump Analytical modes - end point, kinetic rates, initial rates, bichromatic, sample blank Measuring time - programmable from 1 to 998 seconds Delay time - programmable from 1 to 998 seconds Warm up time - < 5 minutes Blanking - automatic zero setting Test results - graphical plot of all measured points - retrieve stored results by test or by patient Calibration modes - standard, multi standard, factor, linear, polynomial, quadratic and spline QC - Levey-Jennings plots (30 or 90 days) Dimensions - 230x260x400 mm (WxHxD) Weight - 9 kg Electric requirements - line voltage 100-240 V (+/- 10%) line frequency 50/60 Hz Regulatory approvals CE marked, 98/79 EC compliance Via delle Driadi, 45 00133 Rome ITALY Tel. + 39 06 20610289 Fax + 39 06 2018131 www.logotech-ise.com e-mail info@logotech-ise.com ISE S.r.l. PRODUCTIVITY MEASUREMENT SYSTEM DATA COLLECTION AND MANAGEMENT CALIBRATION AND QUANTITY CONTROL PHYSICAL CHARACTERISTICS I.S.E. s.r.l. MINITECNO 01/09 For continous improvement in the product, Photographs & Specications are subject to change without prior notice. A member of Consorzio NDI